Documente Academic
Documente Profesional
Documente Cultură
Comportamiento
Sísmico de Pórticos
Especiales
PART 2
1
Moment Resisting Frames
Panel-Zone Behavior
2
Column Panel Zone
3
Joint deformation
due to panel zone
shear yielding
"kink" at corners of
panel zone
4
5
6
Observations on Panel Zone Behavior
7
Moment Resisting Frames
Panel-Zone Behavior
8
2016 AISC Seismic Provisions
9
Section E3
Special Moment Frames (SMF)
10
AISC Seismic Provisions - SMF
Basis of design
11
AISC Seismic Provisions - SMF - Beam-to-Column Connections
Requirements
Beam-to-column connections shall satisfy the following
requirements:
12
Example of Successful Conformance Demonstration Test
per Appendix S:
40000
M 0.04 0.8 M p
Beam Moment at Face of Column (in-kips)
30000
0.8 Mp
20000
10000
-10000
-20000
- 0.8 Mp
-30000
M 0.04 0.8 M p
-40000
-0.08 -0.06 -0.04 -0.02 0 0.02 0.04 0.06 0.08
Interstory Drift Angle (rad)
13
Required Shear Strength of connections
14
Required Shear Strength of Beam-to-Column Connection
Lh
Vu Vu
Vu = 2 Mpr / Lh + Vgravity
15
AISC Seismic Provisions - SMF - Beam-to-Column Connections
Conformance Demonstration
Demonstrate conformance with requirements of Sect. E3.6b by one
of the following methods:
Tests conducted specifically for the project, with test specimens that
are representative of project conditions.
or
Tests reported in the literature (research literature or other
documented test programs), where the test specimens are
representative of project conditions.
16
Conformance Demonstration
17
Section K2
Cyclic Tests for Qualification of Beam-to-
Column and Link-to-Column Connections
Testing Requirements:
18
Typical Test Subassemblages
19
Typical Exterior Subassemblage
Δ
Lbeam
Δ
Interstory Drift Angle =
Lbeam
20
Typical Exterior Subassemblage
21
Typical Interior Subassemblage
Hcolumn
Δ
Interstory Drift Angle =
Hcolumn
22
Typical Interior Subassemblage (with concrete floor slab)
23
Conformance Demonstration
........by use of Prequalified Connection
24
25
ANSI/AISC 358 - "Prequalified Connections for Special and
Intermediate Steel Moment Frames for Seismic Applications"
26
Reduced Beam Section (RBS) Moment Connection
RBS Concept:
• Trim Beam Flanges Near
Connection
• Reduce Moment at
Connection
• Force Plastic Hinge Away
from Connection
27
Examples of RBS Connections.....
28
ANSI/AISC 358:
Prequalification Requirements for RBS in SMF
29
Bolted Unstiffened and Stiffened Extended
End Plate Moment Conection
30
Bolted Unstiffened and Stiffened Extended
End Plate Moment Conection
31
Bolted Flanged Plate Moment Connection
32
Welded Unreinforced Flange-Welded Web Moment
Conexion (WUF-W)
33
Welded Unreinforced Flange-Welded Web Moment
Conexion (WUF-W)
34