Documente Academic
Documente Profesional
Documente Cultură
F / CDTE / 16
REV. NO. ISSUE DATE 00, 01-07-2018
ASSIGNMENT NO. 03
i) The insulation used between two stampings of core of induction motor is-------
ii) The scratches on super enameled coating of copper of conductor can create-------fault.
iii) The brushes of slip ring of I.M. are made up of -------
iv)Long form of TEFC motor uses -------for cooling purpose.
v) The thumb rule says that there is ---------moisture is present in cellulose layer
insulation
vi)The capacitor used in single phase I.M. for--------
vii) The sleeve is used to insulate the winding--------
viii) The earth electrode should not have the resistance more than-------ohms.
Page 1 of 3
4. Select right answers
i) In the 1-ph transformer, the polarity of HV & LV winding should be
a) Same
b) 180° opposite
c) Additive
d) Subtractive
ii) The transformer core are laminated to minimize
a) Eddy current loss
b) Cu loss
c) Power factor
d) Hysteresis loss
iii) In 3-ph transformer, the winding placement should be
a) LV over HV
b) HV over LV
c) HV parallel on next limb.
d) None of these
iv) The stator- rotor air gap gets deformed during running, the most probable
reason is
a) Stator core is deformed
b) Rotor core is deformed
c) Motor foundation un proper
d) Motor bearing jammed
v) Winding resistance found 20% reduced; the reason is
a) Conductor is broken
b) Short circuit between winding and core
c) Turn to turn fault in winding
d) Stator to core short circuit
i) Motor temperature becomes very high
a) Motor has short circuit in stator winding
b) Motor has short circuit in rotor winding
c) Motor has over load.
d) Motor run on high voltage
Page 2 of 3
9. What should be the hysteresis area of loop for motor core wide or narrow? Justify your
answer with reason.
10. The motor stator core should be of which material? NGO, CRGO, HRGO or GO. Justify
your answer.
11. If the sleeves of 1-ph I.M are found damaged what sort of fault it can develop? Justify
your answer.
12. Write a short note on
i) Magnetic Imbalance in 3-ph I.M.
ii) Excessive vibrations in 3-ph I.M.
iii) Duty cycle of motor.
iv) Difference between routine test and type tests on I.M.
Page 3 of 3