Artificial Lift Comparison of AL DSTs PCP (Top Drive) Jet Pump ESP Range 3 to 3500 BPD 0 to 9000 BPD 50 to 50,000 Depth < 6000Ft 10,000 Ft >10,000 Ft Temperature < 250F < 400F Sand / Solid Good Good Good for short run Good for short run (will over heat if run Gas dry) Good Need ASH or Gas Separator Viscous fluid Good Good Above API 12 is acceptable Chemicals Poor, elastomer stator will be damaged Good Good Aromatics Poor, elastomer stator will be damaged Good Good Good for DST (none-permanent H2S Poor, elastomer stator will be damaged Good installation) Good for DST (none-permanent CO2 Poor, elastomer stator will be damaged Good installation) Intallation time Long, two trips for tubing and rods Short Medium Direct control, can not use choke, need Direct control by using Choke or Variable Flowrate @ surface surface Variable Speed Drive Indirect control, difficult to measure. Speed Drive Downhole pump monitoring Possible (check latest on CTS gauges) No Good, real time data to surface Reservoir data monitoring Possible (check latest on CTS gauges) No Good, real time data to surface Annulas pressure control Good Good Good Downhole sampling No No Yes Only after separation, downhole fluid Surface sampling Yes mixed with injected power fluid. Yes Yes, has to inject power fluid from the Contamination of downhole fluid No surface No No, has to inject power fluid from the Well cleanup Yes surface Yes Oil leak at surface Yes No No Access to reservoir No (Yes with Y-tool and BD-PCP) No Yes, by using Y-tools. Acid and fraction job without pulling out string No No Yes, with limitation Combine with TCP No No Yes Surface pumping units Not required Yes Not required Surface electricity supply Yes No Yes Well control Very difficult Yes Yes, by using ESP packer. Fluted Hanger BOP Can and Fluted Hanger Assembly