Documente Academic
Documente Profesional
Documente Cultură
com
PROPRIETARY NOTE
THIS SPECIFICATION IS THE PROPERTY OF BOE DT AND SHALL NOT BE
REPRODUCED OR COPIED WITHOUT THE WRITTEN PERMISSION OF BOE DT AND
MUST BE RETURNED TO BOE DT UPON ITS REQUEST
Product Specification
MODEL: HM236WU3-100
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
REVISION HISTORY
REV. ECN No. DESCRIPTION OF CHANGES DATE PREPARED
0 Initial Release Dec. 26. 11’ Kim Woong
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
Contents
50
5.0 I t f
Interface Connection
C ti 10
12 0
12.0 H dli & C
Handling& Cautions
ti 21
14.0 Packing 23
15.0 Appendix 25
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
1.1 Introduction
HM236WU3-100 is a color active matrix TFT LCD open cell using amorphous silicon
TFT's (Thin Film Transistors) as an active switching devices. This open cell has a 23.6
inch diagonally measured active area with FHD resolutions (1920 horizontal by 1080
vertical pixel array). Each pixel is divided into RED, GREEN, BLUE dots which are
arranged in vertical stripe and this module can display 16
16.7M
7M colors
colors. The TFT-LCD
panel used for this module is adapted for a low reflection and higher color type.
Gate Driver
Mini LVDS Tx
TFT LCD Panel
1920 Ý 1080
VDD DC/DC
1 Gamma
)
Vcom
1.2 Features
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
1 3 Application
1.3
<Table 1
1. General Specifications>
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
The followings are maximum values which, if exceed, may cause faulty operation or
damage to the unit. The operational and non-operational maximum voltage and current
values are listed in Table 2.
Note : 1) Temperature and relative humidity range are shown in the figure below.
Wet bulb temperature should be 39 OC max. and no condensation of water.
ڋڋڌ
ڋڔ (39,90)
ڋړ
ڄڣڭڀڃٻ۔ۏۄڿۄۈېڣٻۀۑۄۏڼۇۀڭ
ڋڑ
(50,50)
ۀ ۂ ۉ ڼ ڭٻ ۂ ۉۄۏ ڼۍ ۀ ۋ ڪ
ڋڏ
(60,30)
ڋڍ
ۀ ۂ ۉ ڼ ڭٻ ۀ ۂ ڼۍ ۊۏ ڮ
ڐ
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
Notes 1. The supply voltage is measured and specified at the interface connector of LCM.
The current draw and power consumption specified is for VDD=5.0V,
Frame rate=75Hz,Clock frequency = 92.9 MHz.
Test Pattern of power supply current
a) Typ : Color Test
b) Max : Skip Subpixel255
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
Note :
1. The value in upper table are based on BLU provided by BOEDT
2. Viewing angle is the angle at which the contrast ratio is greater than 10. The viewing
are determined for the horizontal or 3, 9 o’clock direction and the vertical or 6, 12
o’clock direction with respect to the optical axis which is normal to the LCD surface.
3. Contrast measurements shall be made at viewing angle of ǂ= 0ǂ and at the center
of the LCD surface. Luminance shall be measured with all pixels in the view field set
first to white
white, then to the dark (black) state
state. (See FIGURE 1 shown in Appendix)
Luminance Contrast Ratio (CR) is defined mathematically.
4. Luminance of LCD module shall be made without signal input. Cell transmittance is
defined mathematically, BLU provided by BOEDT.
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
HM236WU3-100
Transmitter Interface Remark
Input (CN11)
Signal TFT-LCD
Pin No. Pin No. System (Tx) Pin No.
(Rx)
OR0 51
OR1 52
OR2 54
48 OUT0- RXO0- 1
OR3 55
47 OUT0+ RXO0+ 2
OR4 56
OR5 3
OG0 4
OG1 6
OG2 7
OG3 11
46 OUT1- RXO1- 3
OG4 12
45 OUT1+ RXO1+ 4
OG5 14
OB0 15
OB1 19
L
OB2 20
V
D OB3 22
S OB4 23
42 OUT2- RXO2- 5
OB5 24
41 OUT2+ RXO2+ 6
Hsync 27
Vsync 28
DE 30
MCLK
C 31
3 40
0 CLK OU
C OUT- O CLK-
RXO C 8
39 CLK OUT+ RXO CLK+ 9
OR6 50
OR7 2
OG6 8 RXO3-
38 OUT3- 10
OG7 10 RXO3+
37 OUT3+ 11
OB6 16
OB7 18
RSVD 25
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
y n i y n i y n i y n i
XGwGdGZGk
y n i
y n i y n i y n i y n i
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
Frame Period Tv 50 60 75 Hz
20 16.7 13.3 ms
Vertical Display
p y Period Tvd - 1080 - lines
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
tRIP2
tRIP3
tRIP4
tRIP5
tRIP6
tRIP0
tRIP1
RXz +/- Rx3 Rx2 Rx1 Rx0 Rx6 Rx5 Rx4 Rx3 Rx2 Rx1 Rx0
* Z = 0, 1, 2,3
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
HS
H-Sync
Tv
Tvd
MCLK
Th
DE
R7 ~ R0
G7 ~ G0 Invalid Data x,1 x,2 x,y x,1050 Invalid Data x+1,1
B7 ~ B0
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
Th
Thd
MCLK
Tc
DE
RA7 ~RA0
GA7 ~GA0
D1 D2 Dn D1048 D1049 D1050 Invalid Data D1 D2 D3
BA7 ~BA0
Tch Tcl
2.0V
MCLK 1.5V
0.8V
Tds Tdh
2.0V
Data Valid Data
0.8V
Tes
DE 2.0V
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
8.0 INPUT SIGNALS, BASIC DISPLAY COLORS & GRAY SCALE OF COLORS
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
0.9VDD 0.9VDD
Power Supply 0.1VDD 0.1VDD
0V
T1
T3 T4
T2
Valid
Interface Signal
0V
T5 T6
Back- light 0V
̻ 0.5 ms T1 d 10 ms
̻ 0 d T2 d 50 ms
̻ 0 T3 d 50 ms
̻ 1 sec d T4
̻ 200 ms d T5
̻ 200 ms d T6
Notes:
1. When the power supply VDD is 0V, keep the level of input signals on
the low or keep high impedance.
2. Do not keep the interface signal high impedance when power is on.
3. Back Light must be turn on after power for logic and interface signal are valid.
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
FIGURE 6 (located in Appendix) shows mechanical outlines for the model HM236WU3-100.
Other parameters are shown in Table 5.
<Table
Table 5. Dimensional Parameters
Parameters>
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
The Reliability test items and its conditions are shown in below.
Notes:
1. The test are done with LCD modules ( Use BOE BLU)
2. The test is done with a package (20Pcs open cell/ 1 Box )shown in section 14.
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
HM236WU3-100
1 2 3 4 5 6 7
X X X X X X X X X X X X X X X X X
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
14.0 Packing
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
14.2 Packing
g Note
HM236WU3-100 20
0000000000000 20XX.X.XX
5940
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
15.0 APPENDIX
ژٻ ڧڃ
ڐٻ ژ
ٻڄڄ ۈ ھ ڋ ڐ
Figure
g 2. White Luminance and Uniformity
y Measurement Locations ((9 p
points))
108
1) 1 1) 2 1) 3
540
1) 4 1) 5 1) 6
972
1) 7 1) 8 1) 9
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
g
Figure 3. Response
p Time Testing
g
TR TF
100%
Optical
90%
Response
10%
0%
Time
Fi
Figure 4.
4 Cross
C Modulation
M d l ti Test
T t Description
D i ti
(D/4, W/4)
L31 YB(7D/8,W/2)
(3D/4, 3W/4)
(D, W) (D, W)
YA (7D/8,W/2)
L0
YB - YA
Cross Talk (%) =
Cross-Talk Ý 100
YA
Th llocation
The ti measured
d will
ill b
be exactly
tl th
the same iin b
both
th patterns
tt
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com