Documente Academic
Documente Profesional
Documente Cultură
$SXEOLFDWLRQRIWKH7HFKQLFDO6XSSRUW7HDP
7RXUQDPHQW'ULYH +RUVKDP3$7HO+(/3)D[
®
Part Number 60/90 Volt Selection in Starline 2000 RF Amplifiers
474742-001-99
Product This Tech Tip provides information regarding the function and application of the 60/90V
Starline 2000 power supply selector in the Starline 2000 series of RF amplifiers.
RF Amplifiers
Release Discussion
1
The Starline 2000 RF amplifiers — BLE Line Extender, BT Amplifier, Mini-Bridger,
and Mini-Bridger Express — are equipped with 60/90V power supplies. The Mini-Bridger is
equipped with either an MPPS or MPPS-II 60/90V power supply. The Mini-Bridger Express
is equipped with the MPPS-II 60/90V power supply. These power supplies provide a
regulated 24 Vdc output over an ac input voltage range from 38 Vac through 90 Vac rms.
These power supplies provide the additional feature of a two position (LO and HI) selector
that sets the startup voltage of the power supply. The startup voltage is 38 Vac for the LO
position and 55 Vac for the HI position. All units are shipped with the selector set in the LO
position. The LO position is used with 60 Vac systems where 38 Vac startup voltage is
required. For systems operating at 90 Vac, the selector can be in the LO or HI position. Note
that changing the selector does not change the upper voltage limit but affects only the
startup voltage. The voltage selector should be switched only if the power supply approaches
its maximum load rating.
There is no damage to the amplifier if the jumper is not changed. However, changing the
jumper ensures that the dc supply does not turn on until the proper input voltage level is
reached — either 38 Vac or 55 Vac. This prevents excessive loading of the system power
supply during turn-on after a system shutdown.
The following power supply illustrations identify the location of the voltage selectors for each
of the amplifiers addressed in this Tech Tip:
1
60/90 Volt Selection in Starline 2000 RF Amplifiers
Figure 1
BLE*/* Broadband Line Extender power supply
L2
L1
C26 C2
P2-3
C7 C6 C5 C3
D6
D5
C24
C1
C22
D8
W1
C12
R25 C11 C10 J1
LO
P2-2 HI
L8
C25
D7
U4
P1 1 E1
E2
R16
D1
T1
P2-1 U3 U1
X1 X2
Q1 L3 U2
SURGE PROTECTOR C17
Figure 2
BT*/* Broadband Telecommunications Amplifier power supply
J4
J2
J3
2
60/90 Volt Selection in Starline 2000 RF Amplifiers
Figure 3
MPPS Mini-Bridger power supply
Voltage Surge
selector protector
HI
J2 LO
1
1
R21
Figure 4
MPPS-II Mini-Bridger and Mini-Bridger Express power supply
Voltage Surge
selector protector
J1
HI
LO
3
60/90 Volt Selection in Starline 2000 RF Amplifiers
Motorola, the stylized M logo, and Starline are registered trademarks of Motorola, Inc. ® Reg. U.S. Pat. & Tm. Off.
All other product or service names are the property of their respective owners.