0 evaluări0% au considerat acest document util (0 voturi)
6 vizualizări1 pagină
This document summarizes leak testing standards from four organizations for various types of valves:
1) API-598 and MSS-SP61 apply to gate, globe, check, ball, and butterfly valves and define allowable leakage rates for tests done in the fully open and fully closed positions.
2) ANSI-FCI70.2 establishes six leakage classes for control valves based on percentage of rated capacity and defines associated test procedures.
3) ISO requires seat closure tests on control valves be performed at a pressure of at least 1.1 times the valve's 1000°F rating rounded to the next higher 5 psi or 0.5 bar increment.
This document summarizes leak testing standards from four organizations for various types of valves:
1) API-598 and MSS-SP61 apply to gate, globe, check, ball, and butterfly valves and define allowable leakage rates for tests done in the fully open and fully closed positions.
2) ANSI-FCI70.2 establishes six leakage classes for control valves based on percentage of rated capacity and defines associated test procedures.
3) ISO requires seat closure tests on control valves be performed at a pressure of at least 1.1 times the valve's 1000°F rating rounded to the next higher 5 psi or 0.5 bar increment.
This document summarizes leak testing standards from four organizations for various types of valves:
1) API-598 and MSS-SP61 apply to gate, globe, check, ball, and butterfly valves and define allowable leakage rates for tests done in the fully open and fully closed positions.
2) ANSI-FCI70.2 establishes six leakage classes for control valves based on percentage of rated capacity and defines associated test procedures.
3) ISO requires seat closure tests on control valves be performed at a pressure of at least 1.1 times the valve's 1000°F rating rounded to the next higher 5 psi or 0.5 bar increment.
N. 1 Gate, globe, check, "Full open" and Control Valve Seat Leakage, APPLICABILITY ball, plug butterfly "full closed" type establishes a series of six seat valves of service. It is not Leakage classes for control valves and intended for denes the test procedures. Use with control valves. 2 Allowed 1. 0.18 cubic inch (3 Seat closure tests Sr. CLASS LEAKAGE Test leakage cubic centimeters) the following N. pressure Per minute per inch leakage rates:10 of nominal pipe cc/hr per inch of 1 I size. nominal pipe 0.5% of 3-4 bar or max 2 II 2. 1.5 standard diameter. rated operating capacity deta p cubic feet (0.042 (water/gas whichever cubic 10-50 0 C) lower Meter) of gas per 3 III .1% of As above hour per inch of rated capacity nominal pipe size. 4 IV .01% of As above rated capacity 5 V 0.0005 ml At max service per minute pressure drop of water per across the inch of plug. port diameter per psi differential With air /nitrogen 6 VI 3.5 bar max rated rated del p
3 Test pressure Seat closure test
must be performed at a Fluid (liquid or gas) pressure no less than 1.1 times the 1000°F (380°C) rating rounded to the next 5 psi (0.5 bar). 4 Test duration 5