Documente Academic
Documente Profesional
Documente Cultură
I- MULTIPLE CHOICE
DIRECTION: Write the letter of the correct answers.
1. Which tool is used to strip and cut wires? a. Anti-static mat b. Philips head
screwdriver
c. Hex driver d. Wire cutter
2. Which tool is used to retrieve parts from location that are too small for your hand to
fit? a. Part Retriever b. Cable ties c. Lint-free Cloth d. Flat head screwdriver
3. Which tool is used to clean different computer components without scratching or
leaving debris?
a. Part Retriever b. Cable ties c. Lint-free Cloth d. Flat head screwdriver
4. Which tool is used to bundle cables neatly inside and outside of a computer?
6. Which tool is used to loosen or tighten screws that have a star-like depression on the
top, a feature that is mainly found on laptop?
7. Temporary storage for data and programs that are being accessed by the CPU.
8. A storage device that uses lasers to read data on the optical media.
9. Early drive controller interface that connects computers and hard disk drives which an
interface that uses a 40-pin connector.
11. Designed to alleviate this bottleneck by making the data used most often by the CPU
instantly available.
13. Indicates that a particular step is connected to another page or part of the flowchart
a. box b. oval c. triangle d. circle
Direction: Read carefully each statement below. Place T on the line if the
statement is TRUE. Place F if the statement is FALSE.
______16 A Flowchart will help you understand your process and uncover ways
to improve it only if you use it to analyze what is happening.
______17. Bottlenecks. These points in the process where it slows down may be
caused by redundant or unnecessary steps, rework, lack of capacity, or other
factors.
______19. A deployment flowchart shows the actual process flow and identifies
the people or groups involved at each step.
______20. There are three main types of flowcharts namely , linear, deployment,
and opportunity.
_____ _21. Health and safety procedure is the responsibility of all persons in the
computer and technology industries.
______ 22. Spotting the hazards means working out how likely it is that a hazard
will harm someone and how serious the harm could be.
______ 23. If you need to temporarily run a cable across the floor, place a
Danger sign similar to those "wet floor" signs used by cleaning services.
______ 24. An LCD monitor has a high-voltage anode inside it, which can carry
a charge of up to 25,000 volts, and it can still be holding a high charge days after
the power is removed.
______ 25. Inkjet printer cartridges or laser printer toner cartridges are
hazardous to users.
______ 26. The right lighting can reduce eyestrain, neck strain, and headaches.
______ 27. When you type, hold your fingers, wrists, and lower arms in a straight
line from your keyboard.
______28. The computer desk should be deep enough to support your arms
when you work at the computer.
______29. When using a computer, keep your feet flat on the floor and your
knees slightly lower than your thighs.
lV. ENUMERATION
Give three steps used to manage health and safety at work (41-43)
Give at least two 5s practices (44-45)
Good practices of proper storage of tools (46)
Benefits of using flowchart (47)
Common hazard encountered by computer technicians and users (48)
V. COMPUTATION
Direction: Convert the decimal numbers shown below to binary. Perform checking to
verify answers.
49.) 97
Prepared by:
Michelle V. Hao
T.L.E Teacher