0 evaluări0% au considerat acest document util (0 voturi)
102 vizualizări1 pagină
This document provides installation instructions for a TH-180C lock-up solenoid for two different vehicle applications: LLV postal vehicles and Tracker, Sidekick, and other vehicles. For LLV vehicles, the instructions are to remove the old solenoid, install a pressure switch, assemble the new solenoid to the valve body, and connect wires. For other vehicles, the instructions note the wiring may differ, and involve cutting a black wire, installing a ground wire, inserting oil tubes, connecting flag terminals to a pressure switch, and plugging in the main connector.
This document provides installation instructions for a TH-180C lock-up solenoid for two different vehicle applications: LLV postal vehicles and Tracker, Sidekick, and other vehicles. For LLV vehicles, the instructions are to remove the old solenoid, install a pressure switch, assemble the new solenoid to the valve body, and connect wires. For other vehicles, the instructions note the wiring may differ, and involve cutting a black wire, installing a ground wire, inserting oil tubes, connecting flag terminals to a pressure switch, and plugging in the main connector.
This document provides installation instructions for a TH-180C lock-up solenoid for two different vehicle applications: LLV postal vehicles and Tracker, Sidekick, and other vehicles. For LLV vehicles, the instructions are to remove the old solenoid, install a pressure switch, assemble the new solenoid to the valve body, and connect wires. For other vehicles, the instructions note the wiring may differ, and involve cutting a black wire, installing a ground wire, inserting oil tubes, connecting flag terminals to a pressure switch, and plugging in the main connector.
1. Remove old solenoid. 2. (If not equipped) Install a 2 pin normally open pressure switch (35-45 PSI rating) as shown. 3. Assemble solenoid to valve body, and insert the oil tubes. Tighten the solenoid mounting bolts securely. 4. Fasten each flag terminal (Black wires) to either terminal of the pressure switch. Be sure terminals are fully seated. 5. Plug the main connector into the transmission case connector.
Tracker, Sidekick, and Other applications
Note: The wiring sequence shown 1 2B may differ from your Original Equipment configuration. The instructions shown are universal and will work in every vehicle application. 1. Cut off black wire at main connector and discard. Figure 1. 2. Install the Ground wire (Figure 2A, includ- ed in your solenoid kit) under the inner mounting bolt of the solenoid bracket as shown in Figure 2B. 3. Insert the oil tubes into the solenoid snout, 2A and install the outer mounting bolt of the solenoid bracket. Securely tighten the mounting bolts. Figure 3. 4. Fasten each flag terminal (Black wires) to either terminal of the pressure switch. Be sure terminals are fully seated. Figure 4. 3 4 5. Plug the main connector into the transmis- sion case connector. Note: If the vehicle is not equipped with a pressure switch, and you do not wish to install one in the location as shown, the ground lead (Black wire) from the solenoid, may be con- nected directly to the grounding termi- nal tab on the valve body. Form #5105, Rev. RTP, 06-01-07