Documente Academic
Documente Profesional
Documente Cultură
b) A three storey building frame with 3 m each floor height is under horizontal loading [8M]
as shown in Fig. Analyze the frame for forces in Top storey using cantilever method
.Assume necessary data.
4. a) A cable ABC of uniform cross section is used to span a distance of 80 m. The cable [8M]
is subjected to uniformly distributed load of 30 kN/m run. The right support „B‟ is
5 m below the left support „A‟ and the lowest point on the cable „C‟ is located
below left support „A‟ by 10 m. Solve for the reactions in the cable. Solve for the
maximum and minimum values of tension in the cable.
1 of 2
www.manaresults.co.in
Code No: RT31012 R13 SET - 1
b) Determine reaction components at A and B, tension in the cable and the sag of the [8M]
cable shown in Fig. Neglect the self weight of the cable in the analysis.
5. a) Using moment distribution method analyse the two span continuous beam loaded as [8M]
shown in Figure, if the moment of inertia of AB = I while that of BC = 2I. The ends
A and C are simply- supported. Sketch the B.M. and S.F. diagram.
b) A continuous beam ABCD 20m long is s.s. at its ends and is propped at the same [8M]
level at B and C as shown in the figure. If support B sinks by and 20 mm, Analyse
the beam by Kani‟s method and determine the end moments.Take E = 2.1×105
N/mm2 and I = 85 ×105 mm4.
7. a) Analyse the beam shown in Figure if the downward settlements of supports B and C [8M]
are 200/E and 100/E I respectively ( in kN-m units). Use Flexibility method.
b) Analyse continuous beam shown in figure using the stiffness method. Draw BMD. [8M]
Given AB=BC=10m.
*****
2 of 2
www.manaresults.co.in