Documente Academic
Documente Profesional
Documente Cultură
READY
#
Contents
Attention 01
Caution 02
Safety Instruction 03
E-Waste Disposal 05
Accessories 06
Wall mount Installation 07
Stand assembly Instructions 08
Multimedia Terminal Connection 11
The Remote Control 16
Remote Control Function 17
Menu Operation 19
Hotel Mode 25
Media Operations 26
ATTENTION:
ATTENTION:
32D SHD User Manual
CAUTION:
The lighting flash with the arrowhead symbol, inside an equilateral triangle is intended
to apprise the user of the presence of uninsulated dangerous voltage within the
products enclosed which may be a sufficient magnitude that may cause a risk of
electric shock to the user.
The exclamation mark Inside an equilateral triangle is intended to alert the user of
the presence of important operating and maintenance (servicing) instructions.
Safety Information
To ensure reliable and safe operation of this equipment, please read all the instructions in
this user guide, especially the safety information below.
Electrical safety
The TV set should only be connected to a main power supply as stated on the label on the
back of the product. To prevent overload, don’t share the same main supply socket for too
many items.
Do not place any connecting wires where they may be stepped on or tripped over.
When removing the plug from the wall socket, make sure to pull the plug and not the wires.
During a thunderstorm or while leaving the TV for long periods, disconnect the aerial ( if
outdoor ) and mains from the power supply.
Do not allow water or moisture to enter the TV or main adaptor. Do not use the tv in wet or
moist areas such as bathrooms, steamy kitchens or near swimming pools.
Pull the plug out immediately, and seek professional help if :
The main plug or cable is damaged.
Liquid is spilt onto the set, or if it is accidentally exposed to water or moisture.
Anything accidentally penetrates the ventilation slots.
The set does not function properly.
Do not remove the safety covers. There are no user serviceable pacts inside.
You may invalidate the warranty. Only qualified personnel can service this apparatus.
Remove exhausted batteries from the remote control handset to avoid battery leakage or
if case you are not using it for a long period.
Physical safety
Do not block ventilation slots in the back cover. You may place the TV near cabinet, but
please ensure that there is at least 5cm (2") clearance all around.
Do not lap or shake the TV screen. You may damage the internal circuits. Take good care
of the remote control, do not drop it.
To clean the TV use a soft dry cloth. DO NOT use solvents or petrol based fluids. For
stubborn stains, you may use a damp soft cloth with diluted detergent.
WARNING
To reduce the risk of fire or electric shack, do not expose this apparatus to rain or moisture.
The apparatus should not be exposed to dripping or splashing liquids and no objects filled
with liquids, such as vases, should be placed on the apparatus.
1. Read this instructions. 8. Do not install TV set near any heat source
2. Keep these instructions. such as radiators, heat registers, stoves or
3. Note all warnings. other apparatus (including amplifiers) that
4. Follow all instructions. produce heat.
12. Use only a cart, stand, tripod, bracket, 13. Unplug this apparatus during lightning
or a table apeded by the manufacturer storms or it is to be unused for a long time.
or which is solid with the apparatus.
15. Never place the TV, remote control or batteries near naked flames any other heat
source, including direct sunlight. To prevent the spread of fire, keep candles or other
flames away from the TV, remote control and batteries at all times.
16. The USB terminal should be loaded with 0.5A under normal operation.
17. The company will provide the customer with the first wall mount free of cost, any
changes or new wall mounts hence forth will be chargeable.
18. The company suggests that the TV should be mounted at eye level to get the best
viewing experience. If the customer wishes to place it at any other angle then the
viewing experience may differ accordingly.
19. Once the LED/LCD TV has been mounted, the responsibility of its maintenance lies
with the customer. The company is in no way liable for any damages that may
occur due to falling/dust gathering/moisture accumulation etc.
20. If the set is cold,there may be a small flicker when the set is switched on. This is
normal and there is nothing wrong with the set.
21. Some dot defects of bright or dark colors may appear on the screen. However, this
will not have any impact or effect on TV performance.
Note :
- If the TV is cold, there maybe a small flicker when you turn it on.
- Avoid touching the LCD screen or holding your finger (s) against it.
E-WASTE DISPOSAL
Environmental compliances:
As per the rules laid down by the Government for environmental concern & safety, your
product has been made to comply and conform to the respective regulation as listed below.
This product falls under the E-WASTE (MANAGEMENT) RULES, 2016 of Ministry of Environment,
Forests & Climate Change.
RoHS declaration:
This Product is in conformity with the requirements of Rule 16 of the E-WASTE (MANAGEMENT)
RULES, 2016. The content of hazardous substances with the exemption of the applications listed
in SCHEDULE ll of the E-waste (Management) Rules, 2016 is as follows:
2) Don’ts :
a. Never dump E-waste in Garbage bins or Municipal solid waste stream.
b. Do not dispose your product as unsorted municipal waste.
c. Do not throw or dispose used, damaged and leaking batteries & products into house hold
waste.
EPR DETAILS
Website: https://www.flipkart.com/pages/ewaste-compliance-tnc
Toll free number: 1800-2121-434
32D SHD User Manual
ACCESSORIES
Please make sure the following items are included with your LED TV.
If any items are missing, please contact your dealer.
St.By SOURCE
FREEZE CH.LIST
PREV. FB FF NEXT
S.MODE P.MODE
S P
ENTER
MENU EXIT
MUTE
+ +
VOL ZOOM CH
1 2
-
3
+ +
Wall Mount
4 5 6
7 8 9
DISPLAY RECALL
Stand 4 Stand
Support screws
NOTE :-
1. Use only the matching screws provided by the manufacturer in the accessories
bag in order to install the TV Unit stand and also in order avoid damaging the TV unit.
2. You may reverse the steps to remove the base stand from the TV.
200mm
Screw Size
M6*22mm
100mm
Screw Size
M6*18mm
of the
10cm (4 inches)
m
10cm 10c
10cm
32D SHD User Manual
TV signal output
32D SHD User Manual
12 32D SHD User Manual
USB 2 IN USB 1 IN
AV OUT (MINI)
AV 2 IN (MINI)
RF IN (ANT)
HDMI 2
HDMI 1
AV 1 IN
PC AUDIO IN
VIDEO
AUDIO IN-L
AUDIO IN-R
PC IN
HEADPHONE OUT
(EARPHONE OUT)
AV 1 IN
TV terminal Multimedia terminal
R R .........
.................................... ..................
........................... R R
Audio Audio
L W ...........................
.................. ....................................
......... W L
Video Y .........
.................................... ..................
........................... Y Video
AV 2 IN (MINI)
Multimedia terminal
TV terminal
R
.............. ...........................
..................
...........................
.................. R R
AV 2 IN Audio
W
.............. ............................................. ...........................
..................
W L
Note:-
AV Cable are often color-coded to connectors. Connect ® red to red, W white to white, Y yellow to yellow.
13 32D SHD User Manual
Computer
TV terminal Multimedia terminal
PC
PC
Audio IN
PC
Audio
AV OUT Audio
W
.............. ............................................. ...........................
.................. W L
....................................
Y
..............
...........................
......... ..................
Y
Display Device
HDMI
HDMI
HDMI HDMI
Earphone
TV terminal
Earphone Out
USB 1/USB 2
TV terminal
USB IN
32D SHD User Manual
VHF TV ANTENNA
UHF TV ANTENNA
To TV ANTENNA JACK
75 OHM COAXLIAL CABLE
300 OHM 75 OHM ADAPTOR
75 OHM DIN
Connect the 75 OHM coaxial cable from the antenna to the antenna
socket on the rear panel, as shown above.
32D SHD User Manual
right
5 4 3 2 1
32D SHD User Manual
St.By SOURCE
FREEZE CH.LIST
PREV. FB FF NEXT
S.MODE P.MODE
30 30 S P
5m
St.By SOURCE
FREEZE CH.LIST
ENTER
PREV. FB FF NEXT
S.MODE P.MODE
S P
ENTER
MENU EXIT
MUTE
+ +
VOL ZOOM CH
1 2
-
3
MENU EXIT
4 5 6
7 8 9
DISPLAY RECALL
MUTE
+ +
Remote control operation range: Point the remote
VOL ZOOM CH
- -
1 2 3
4 5 6
7 8 9
DISPLAY RECALL
0
32D SHD User Manual
32D SHD User Manual
32D SHD User Manual
Auto Tuning
ATV Manual Tuning
Programme Edit
CHANNEL
TV:
TV:5Programme(s)
5 Programme
44%... 433.75MHZ(TV)
44%...433.75MHZ (TV)
Menu
Menu
– Current CH 1 +
Sound System BG
49.7MHZ
AFC
Search
Menu
32D SHD User Manual
Programme Edit
1
2
3
4
5 ||#
6
7
8
9
10
Clock ____
Off Time Off
12
1
10 2 On Time Off
TIME 9
8
3
4 Sleep Timer Off
7 6 5
Horizontal Pos. 50
50
SCREEN Clock 50
Phase 49
Move Menu
USB 2.0
The USB storage devices should be inserted into the terminal. Select the
27 32D SHD User Manual
Select
[ENTER]: Confirm
The file will be transferred to the same folder as that of the source USB.
If a video file is selected from the source, it will move to the next USB in
the video folder. If an image file is selected from the s ource, it will move
to the next USB in the image folder. If the music file is selected from the
source, it will move to the next USB in the music folder.
Media Operation
Button Menu Function
Play or pause
Play previous
28 32D SHD User Manual
Play next
Play slower
29 32D SHD User Manual
Technical Specifications
Product Model 32DSHD
File system : FS, FAT32, FAT16, NTFS (NTFS compressed file is not supported).
Note: -
Simple Troubleshooting
Symptom Dealing Method
No Power Check the power connection. Pull the plug out, wait for
60 seconds, then reconnect the power and turn on the
set
No Sound Increase the volume, check if the set is in the mute state
or not. Check the voice setting condition. Check the voice
mode setting condition
Remote not Check the batteries. If necessary, replace the batteries or
responding clean the remote-control sensor window. The distance
between the set and the remote control should be less
than 6 m
The screen The parameter is too big. Please use safety mode when
flashes in re starting the PC and set the parameter of the monitor
VGA Mode as per the instructions
16. In the event of repairs of any part (s) of the product, the
Warranty will thereafter continue and remain in force only for
the unexpired period of the Warranty. Moreover, the time taken
for repair and in transit whether under the Warranty or
otherwise shall not be excluded from the Warranty period.
17. None of the employees, sellers, dealers or ASCs of the Company
have the authority to vary these terms and conditions.
18. Customer agrees that the courts at Bangalore shall have the
exclusive jurisdiction to settle any dispute that may arise in
relation to this Warranty or these terms and conditions.
19. COMPANY SHALL NOT BE LIABLE FOR ANY INDIRECT, SPECIAL,
PUNITIVE, EXEMPLARY, SPECULATIVE OR CONSEQUENTIAL
DAMAGES, INCLUDING, BUT NOT LIMITED TO, ANY LOSS OF USE,
BUSINESS INTERRUPTION, AND LOSS OF INCOME OR PROFITS,
IRRESPECTIVE OF WHETHER IT HAD AN ADVANCE NOTICE OF
THE POSSIBILITY OF ANY SUCH DAMAGES.
20. For any further information / assistance please contact our
customer Redressal cell at:
Flipkart India Private Limited,
Vaishnavi Summit, No 6/B,
7th Main, 80 Feet Road, 3rd Block,
Koramangala, Bangalore -560034, INDIA.
Contact No.: 080-46609211
Email: marq@flipkart.com