Documente Academic
Documente Profesional
Documente Cultură
Shutdown SIS
Previous Screen
i02016329
Installation Procedure
Table 1
Required Tools
C 5P-1737 Bolt 3
NOTICE
Keep all parts clean from contaminants.
Note: The crankshaft front seal and the wear sleeve must be replaced at the same time. Once the crankshaft front seal
and the wear sleeve are separated, these components cannot be used again.
Note: Do not use any type of lubricant during the installation of the crankshaft front seal and the wear sleeve.
https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/techdoc/techdoc_frameset.jsp&calledpage=/sisweb/sisweb/techdoc/te… 1/2
6/8/2019 3406E Generator Set Engine 9NN00001-UP(SEBP3975 - 15) - Documentation
Illustration 1 g01042507
Note: Install the crankshaft front seal with the arrow that shows the direction of crankshaft rotation toward the
front of the engine.
2. Position wear sleeve (2) and crankshaft front seal (1) on Tooling (B). Install Tooling (E) on Tooling (B). Lubricate
the face of the washer on Tooling (D). Install Tooling (D) on Tooling (B) .
End By: Install the vibration damper and the pulley. Refer to Disassembly and Assembly, "Vibration Damper and Pulley
- Remove and Install".
https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/techdoc/techdoc_frameset.jsp&calledpage=/sisweb/sisweb/techdoc/te… 2/2