Documente Academic
Documente Profesional
Documente Cultură
fluid.
a. pressure energy
b. kinetic energy
c. either pressure energy or kinetic energy
d. pressure energy, kinetic energy or both
ANSWER: pressure energy, kinetic energy or both
a. Reciprocating pump
b. Rotary displacement pump
c. Centrifugal pump
d. None of the above
ANSWER: Centrifugal pump
a. oils
b. gritty liquids
c. both oils as well as gritty liquids
d. None of the above
ANSWER: oils
a. Gear pump
b. Vane pump
c. Rotary piston pump
d. All of the above
ANSWER: All of the above
a. Reciprocating
b. Rotary displacement
c. Centrifugal
d. Screw
ANSWER: Centrifugal
6) Discharge capacity of the reciprocating pump is __________ that of the centrifugal
pump.
a. higher than
b. lower than
c. same as
d. unpredictable
ANSWER: lower than
7) Which pump is more suitable for an application where very high pressure is required
to be developed at moderate discharge?
a. Reciprocating pump
b. Centrifugal pump
c. Turbine
d. None of the above
ANSWER: Reciprocating pump
8) The process of filling the liquid into the suction pipe and pump casing up to the level
of delivery valve is called as _________.
a. filling
b. pumping
c. priming
d. leveling
ANSWER: priming
9) The volute pumps and vortex volute pumps are __________ pumps with _________
shaft.
a. multistage, horizontal
b. multistage, vertical
c. single stage, horizontal
d. single stage, vertical
ANSWER: single stage, horizontal
10) Which of the following centrifugal pumps has higher specific speed than the others?
a. Axial flow
b. Radial flow
c. Mixed flow
d. All have same specific speed
ANSWER: Axial flow
11. Power required to drive a centrifugal pump is directly proportional to __________ of
its impeller
a. Diameter
b. square of diameter
c. cube of diameter
d. fourth power of diameter
12. The static head of a centrifugal pump is equal to the __________ of suction head and
delivery head.
a. product
b. difference
c. sum
Answer: Sum
18. The _____ of the centrifugal pump transmits energy in the form of velocity to the
water.
a. casing
b. volute
C. impeller
D. rotary gear
Answer: Impeller
19. A small amount of___ should leak out around the packing and prevent excessive heat
buildup.
a. air
b. water
c. grease
d. graphite
Answer: Water
20. If the pump is operated ___ for any length of time, it can damage the shaft.
a. dry
b. wet
c. hot
d. cold
Answer: Dry