Documente Academic
Documente Profesional
Documente Cultură
0030 R X Raw Material Test Reports: of Cast or Heat Analysis, Product Per 02-SAMSS-011
analysis and Carbon equivalent
0050 R NDT Technician Qualification Shall be certified to ASNT Level- I or equivalent as per refer
SAEP 1142-Appendix-01
0060 R NDT Inspector Qualification Shall be certified to ASNT Level- II or equivalent as per refer
SAEP 1142-Appendix-01
0070 R Welders Qualification Records Shall be qualified per ASME section IX or equivalent.
Performance records shall show acceptable rejection rate level.
0080 R Welding Inspector Qualification Shall be certified to AWS (CWI) or CSWIP3.1 or equivalent.
0020
0010
***
W R X
In process inspection & test requirement
Forging , Heat treatment & Machining process
Specification Details / Notes:
Per 02-SAMSS-011. Verify these process performed in-house
manufacturer.
0020 W R X Mechanical Testing: Tensile Test, Impact test and Hardness test 02-SAMSS-011.
IR022501 Continued...
INSPECTION & TESTING REQUIREMENTS REVISION: 07/12/2017 CODE NUMBER: PAGE:
SAUDI ARAMCO FORM-175 REPLACES: 06/16/2016 IR022501 2 of 2
(1).VISUAL INSPECTION BY BUYER INSPECTION REPRESENTATIVE
(2) REVIEW AND VERIFICATION OF MATERIAL CERTIFICATES AND INSPECTION RECORDS
(3) SUBMISSION OF MANUFACTURING, INSPECTION AND QUALITY RECORDS
0040 W R X Nondestructive Testing: a) Magnetic Particle Testing and Liquid 02-SAMSS-011. One per PO line item or 10% Per line item
penetrant Testing which is higher.
0042 R X Nondestructive Testing: b) Ultrasonic Testing 02-SAMSS-011. Refer to SAMSS for details and application of
A707, A388, A508 requirements.
0030
0010
***
H X
Final inspection & test requirements
Visual and Dimensional Inspection.
Specification Details / Notes:
02-SAMSS-011, the respective ASTM/Industrial Standard and
approved drawings.
0020 W R X Inspection of Raised Face Gasket Surface 02-SAMSS-011, ANSI B46.l: Surfaces shall have a finish of 3.2
to 6.4 micro-meters Ra
0050 W R X Special Flange Dimensions (when applicable) 02-SAMSS-011: Apply the Standard Drawings as referenced in
SAMSS or the approved #Special Design#.
0070 R X Product Test Certificate and records As per applicable SAMSS and IR
Notes:
(1) Refer detailed instruction sheet SA175 form IR000003 of inspection requirement for ideal use of this form.
(2) Extent of frequency of testing and inspection is per 02-SAMSS-011.
End of IR022501