Documente Academic
Documente Profesional
Documente Cultură
Step two: open the back cover of the system, find a white 3p spin on the board.
Change it as picture shows.
1. copy files
Will STARTCNC1.EXE, renamed STARTCNC.EXE, stored in a U disk.
2. Power
Different systems, see a different approach.
3. Upgrade
When the prompt appears on the screen to upgrade the system's USB port plug in the U disk, pr
ess 【F1】 key, wait for the update. When the "Upgrade Success!"prompt, the shutdown.
4. install a new text library
5 seconds before turning off the screen on, pause for about 10 seconds (this time without any dis
play on the screen, the system is installed a new text library) manually after shut down.
1. copy files
Will STARTCNC2.EXE, renamed STARTCNC.EXE, stored in a U disk.
2. Power
Different systems, see a different approach.
3. Upgrade
When the prompt appears on the screen to upgrade the system's USB port plug in the U disk, pr
ess 【F1】 key,
5 when the program is very large (do not display all graphic) , It can use the two methods as
follows:
a) In the [parameter] is set to [control], the width of the plate X, and Y height of the actual value is
written;
b) into the editor (go to exit), restart the run, the system will automatically adjust the zoom.