Documente Academic
Documente Profesional
Documente Cultură
Inverter Skid RCC columns, ramp, ISMC, plinth protection , RCC platform & Shed. sq.ft. 3873
RCC colums, bricks, windows, doors, ramp, inside cabling routing, ISMC,
Inverter room sq.ft. 1535
bottom trenches with plinth protection.
Security Cabin 1.5 X 1.5 meter Prefabricated structure Nos. 4
RCC colums with Mild sheet leafs with tubes and colums. Width of 4.5
Main gate Nos. 2
mtrs, with two leafs opening indoor
Wicket gate 1.5 mtr wide single leaf door of Mild Steel. Nos. 2
Watch tower Prefabricated 3.5 mtrs in height at strategic locations in plant. Nos. 5
Gates for Transformer Fencing 1.8 mtr high, 1 mtr wide single leaf door, MS door Nos. 5
Foundations
WMS For mounting of different weather monitoring sensors and datalogger. Nos. 1
LA For mounting of Early Stream Emission type Lightning Arrestor. Nos. 45
For mounting of Street light pole at a distance of 50 mtrs along the
Street light Nos. 126
perimeter.
Inverter Duty Transformers RCC Foundation Nos. 5
Foundation+ shed for RO 3 RO membrane, 1 scalant, filtration unit and RO pump Nos. 1
Cleaning system
100mm dia borewell assumed at a depth of 300 feet, with Motor -pump set,
Bore well Nos. 2
casing, starter, submersible cable etc
Water Reservior for RAW Water Underground RCC tank of 1.5 mtr depth with 1 mtr plinth on top lts 1111200
Water Reservior for RO Water PVC water tank over RCC foundation lts 1111200
Pipe line HDPE with accessories (Pipes and accessories) LS 84.13
Surafce Mounted Pumps Motor +Pump, starter, cable & suitable for outdoor application Nos. 4
Standard RO with 3 membranes, antiscalant and filtration with output for
RO system Nos. 1
750 lts/ hour, note RO is dependent on ground water quality.
Cable Trenches
1.5 KV cables - 500 mm depth X 300 mm Width of trench warning tap and
DC trench for Solar Cable Mtr 2008
backfilling
1.9/3.3kV cables - 1200 mm depth X 900mm width of trench With riddled
Main DC Cable trench Mtr 9405
sand, warning tap and backfilling.
Ladder type cable trays with 2 side 2 layers, for cable from Inverter to
LT AC Cable on Trays (Inverter to Transformer with pedastal and cable trays and covers and trefoil clamps.
Mtr 250
IDT) Assuming 6 runs/Phase/Inverter, each tray of 750mm wide 3000mm long,
2mm thick,with cantilver supports.
33kV cables - 1200 mm depth X 300mm width With riddled sand, brick
HT AC cable trench (IDT to CICO
protction, warning tap and backfilling. Also control & communiation cable Mtr 50
Panel)
shall be laid in this trench.
33kV cables - 1200 mm depth X 600 to 900mm width With riddled sand,
HT AC cable trench (CICO Panel to
brick protection, warning tap and backfillin. Also FO cable shall be laid in Mtr 1900
Main MV Panel switchboard)
this trench.
SCB stand
Mounting bracket SCB column post - C Sections ISMC along with foundation. Nos. 720
HVAC
Heater Considered for SCADA room. Nos. 1
Total BOM
ESE type, protection level - IV with Protection Radius of 107 mtr at height
Lightning Arrestors of 5 mtr from the surface of protection, with GI mast , flash counter, Nos. 45
earthing and down conductors.
12 MVA, 33kV/0.6kV, Dy11y11y11y11, %Z = 8, ONAN, OCTC with +/-
AC electrical Inverter Duty Transformers 10% @ 2.5% steps, CU wound with standard fitting as per CBIP with Nos. 5
NIFPS Provision
NIFP System Nos. 5
Indoor 33kV CICO GIS Panel @ 33 KV, CICO type SF6 Gas Insulated Panel having 630 Amp Fixed type
Nos. 5
Invetrer room VCB, STC - 25KA for 1 sec for VCB, CT and Busbar
SCADA
SCADA Panel PLC, DI, DO, AI ports, Rittal enclosure and other accessories no. 6
Li2YCY 2x2x0.5 sqmm Electrolytic annealed plain copper conductor,
Communication Cables Modbus cable (Unarmoured) mtrs 900
Halogen free insulating material, with Anti UV and Anti Ozone properties.
Cat 6 mtrs 300
FO cable 12F MLMP type Single mode Fiber optic Cable mtrs 4100
Fire Detection &
Fightning
Smoke detectors Conventional multi sensor detector no. 10
Heat Detector no. 2
Manual Call Point no. 2
Hooter cum Strobe no. 2
Fire alarm Panels no. 1
2C x 1.5 sqmm multistranded twisted pair unshielded FRLS copper
Cables mtrs 150
Armoured power cable
CO2 fire extingushers - 9 kgs no. 14
DCP (Dry Chemical Powder) type
no. 14
Fire extinguisher
Foam hand type - 9 litres no. 14
Buckets with sand and stand no. 14
25 MM, 3 mtr long CU bonded rod, 25 kg earth enhancement material in
Earthing Earth rods LS 187
each pit with chamber
1C x 16 sq.mm Cu cable 1 core copper PVC insulated for SCB SPD earthing mtrs 900
1C x 35 sq.mm Cu cable 1 core copper PVC insulated for SCB body earthing mtrs 900
1C x 70 sq.mm Cu cable 1 core copper PVC insulated for inverter earthing mtrs 400
GI strip: 25 x 6 mm mtrs 62769
GI strip: 50 x 6 mm mtrs 750
GI strip: 65 x 10 mm mtrs 500
Misc Cable route markers LS 500
Cable ties 100 Nos. of ties/ packets packers 1230
Lugs LS 1
MC4 connectors (male & female 1500V, 30A rated Current, Protection Class - 2, IP68 Outward lock, Snap In
no. 19680
type) type.
1500V, 30A rated Current, Protection Class - 2, IP68 Outward lock, Snap In
Y connectors for negative side no. 4920
type.
Cable harness with inline fuse for
1500V, 15A inline fuse with 50A rated current, IP68 no. 4920
positive side
Cable accessories heat shrinks, terminations, tables, foams. LS 84
HDPE Pipes- DWC 40 mm ID Double wall Corrugated flexible pipe mtrs 50479.2
Hume pipes for road crossings 300 mm ID with standard length of 3 mtrs, NP 3 mtrs 562
HDPE pipes for Control rooms 150mm ID Pipes for IR and MCR buildings mtrs 100