Documente Academic
Documente Profesional
Documente Cultură
LAB 1
1.1 Introduction
moles of solute
Molarity ( M ) (Equation 1-1)
liter of solution
Percent by mass is the mass in grmas of solute per 100 grams of solution
grams of solute
Percent solute x 100% (Equation 1-2)
grams of solution
Vinegar is a dilute solution of acitic acid. The molecular formula for acetic acid is CH 3COOH.
Both molarity and percent by mass of aceric acid in a vinegar solution can be determine by
performing a titration. A titration is a process in which small increments of a solution of known
concerntration are added to a specific volume of a solution of unknown concerntration until the
stoichiometry for that reaction is attained. Knowing the quantity of the known solution required
to complete the titration, calculation of the unknown solution ca be done. The purpose of titration
is to determine the equivalance point of the reaction. The equivalance point is reach when the
added quantity of one reactant is the exact amount necessary for stoichiometric reaction with
another reactant.
1.2 Objectives
To :
(a) Determine the morality of a solution and the percent by mass of acetic acid in vinegar by
titration with the standardized sodium hydroxide solution.
1.3 Theory
In the titration process, a burette is used to dispense a small, quantifiable increment of solution of
known concentration (Figure 1.1). A typical burette has the smallest calibration unit of 0.1mL
(Figure 1.2), therefore, volume dispense from the burette should be estimated to the nearest
0.01mL.
Figure 1-1: a) Depicts a typical 50-mL burette. b) Indicates smallest calibration unit, 0.1mL, on a typical 50 mL
burette
In this experiment, the equivalence point occurs when the moles of acid in the solution equals to
the moles of base added in the titration. For example, the stoichiometric amount of 1 mole of the
strong base, sodium hydroxide (NaOH), is necessary to neutralize 1 mole of the weak acid, acetic
acid (CH3CO2H), as indicated in equation 3.
pH scale is a method of expressing the acidity or basicity of a solution. Solutions having a pH <
7 are acidic, pH = 7 are neutral, pH > 7 are basic. For example, a solution having [H 30+]= 2.35 x
10-2 M would have a pH of 1.629 and is acidic. Ph electrode will be used in this experiment. The
titration is initiated by inserting a pH electrode into a beaker containing the acid solution (pH
within 3-5). As sodium hydroxide, NaOH, is incrementally added to the acid solution, some of
the hydrogen ions will be neutralized. As the hydrogen ion concentration decreases, the pH of
the solution will gradually increase. When sufficient NaOH is added to completely neutralize the
acid (most of the H3O+ ions are removed from the solution), the next drop of NaOH added will
cause a sudden sharp increase in pH (figure 2-2). The volume of based required to completely
neutralized the acid is determine at the equivalence point of titration.
Figure 1-2: Acid-base titration curve of weak acid titrated with NaOH.
In this experiment, titration of vinegar sample with a standardized sodium hydroxide solution
will be done. To standardize the sodium hydroxide solution, of a primary standard acid solution
is initially prepared. In general, primary standard solutions are produce by dissolving a weighed
quantity of pure acid or base in a known volume of solution. Primary standard acid or bases have
several common characteristics:
Potassium hydrogen phthalate KHC8H4O4, and oxalic acid, (COOH)2, are common primary
standard acid. Sodium carbonate, Na2CO3, is the most commonly used based. Most acids and
bases (e.g. HCl, CH3COOH, NaOH, and KOH) are most available as primary standard. To
standardize one of these acid or based solutions, titration of the solution with a primary standard
should be done. In this experiment, NaOH solution will be titrated with potassium hydrogen
phthalate (KHP). The equation for this reaction will be:
KHC8H4O4 (aq) + NaOH (aq) KNaC8H4O4 (aq) + H2O (l) (Equation 1-5)
Once the sodium hydroxide solution has beeb standardizes, it will be used to titrate 10.00mL
aliquots of vinegar. The equation for the reaction of vinegar with NaOH is
Knowing the standardized NaOH concentration and using equation 6, we can determine the
molarity and percent by mass of acetic acid in the vinegar solution.
Figure 3 depicts the titration curve of 1.523 grams of KHP dissolved in20.0mL of distilled water
titrated with NaOH. Determine the molarity of the NaOH solution.
Figure 1-3: titration curve of KHP with NaOH. The volume of NaOH used at the equivalence point is 15.3 mL of
NaOH.
1 mol KHC 8 H 4O 4
1.523 g KHC 8 H 4O 4 x 0.007458 mol KHC 8 H 4O 4
204.2 g KHC 8 H 4O 4
From equation 5, calculate the moles of NaOH required neutralizing the moles of KHP.
1 mol NaOH
0.007458 mol KHP x 0.007458 mol NaOH
1 mol KHP
1L
15.30 mL NaOH x 0.01530 L NaOH
1000 mL
Sample calculations for determining the acetic acid concentration in vinegar by titration with
standard base
A 10.00 mL aliquot of vinegar requires 16.95 mL of the 0.4875 M standardized NaOH solution
to reach the equivalence point of the titration. Calculate the molarity and the percent by mass of
CH3COOH in the solution. Assume the density of the vinegar solution is 1.00g/mL.
Calculate the moles of NaOH that reacted.
1L
16.95 mL NaOH x 0.01695 L NaOH
1000 mL
0.4875mol NaOH
0.01695 L NaOH x 0.008263 mol NaOH
1 L NaOH solution
1 mol CH 3COOH
0.008263 mol NaOH x 0.008263 mol NaOH
1 mol NaOH
1L
10 mL CH 3COOH x 0.010 L CH 3COOH solution
1000 mL
1L
10 mL CH 3COOH x 0.010 L CH 3COOH solution
1000 mL
1 g CH 3COOH solution
10 mL CH 3COOH solution x 10.00 g CH 3COOH solution
1 mL CH 3COOH solution
1.4 Procedure
2. Weight a 250 mL beaker and record the mass to the nearest 0.001g. Add 1.5 grams
of KHP to the beaker. Record the mass of the beaker and KHP to the nearest 0.001 g.
calculates the mass of KHP by difference and record the data. Add 30mL of distilled
water to the beaker. Stir the solution until the KHP has dissolved completely.
3. titrate this solution with NaOH and record the pH with 1 ml additions of NaOH
solution.
4. Repeat steps 1 to 3 to perform a second and third trial to standardize the NaOH
solution.
4. Plots the graph of pH versus NaOH. From the plots, determine the volume of
NaOH required neutralizing the KHP solution in each titration.
7. Calculate the average morality of sodium hydroxide solution for titration 1 and 2.
The resulting sodium hydroxide concentration will be used in part B of the
experiment.
1.4.2 Molarity of acetic acid and percent of vinegar
4. Plot the graph of pH vs volume NaOH added. And from the plots determine the
volume of NaOH required to neutralized vinegar in each titration. Record your data.
6. Calculate the percent by mass of acetic acid in vinegar for titration 1 and 2
1.
Titration 1 Titration 1
Volume of
NaOH required
to neutralize
vinegar