Documente Academic
Documente Profesional
Documente Cultură
Amine-cured epoxy
DESCRIPTION Steel
A deep penetrating epoxy primer. For use with Prepare to SSPC-SP6. Surface profile 50-75
MasterProtect Protective Coating systems. micron.
Primer for use prior to application of
MasterProtect 1812 and MasterProtect 1825. TYPICAL PROPERTIES*
LIMITATIONS
Do not use in water immersion over 60°C APPLICATION
Epoxies loose gloss, discolour and will chalk MasterProtect P 659 may be applied by airless
in direct sunlight exposure. spray, brush or roller. Please refer to our latest
Method Statement for detailed application
SURFACE AND SUBSTRATE instructions.
PREPARATION
General PACKAGING
Surfaces must be clean and dry. Use suitable MasterProtect P 659 is supplied in 23.25kg
methods to remove dirt, dust, oil an all other (17.5 litre) units.
forms of contamination that could interfere with
the adhesion of the primer. STORAGE
Up to 12 months when stored under cover, out
Concrete of direct sunlight and protected from extremes
Concrete must be cured for 28 days. of temperature.
Mechanically surface profiling is the method of
surface preparation. Mechanically profile the
WATCHPOINT
surface to CSP3 as described by the
International Concrete Repair Institute. Voids No additions or omissions are required and on
and pinholes must be repaired. no account should attempts be made to split
packs.
MasterProtect® P 659
NOTE
Field service, where provided, does not
constitute supervisory responsibility. For
additional information contact your local BASF
representative.
BASF_CC-UAE/Sl_P659_11_09/v6/05_17
The technical information and application advice given in this BASF publication are based on the present state of
STATEMENT OF our best scientific and practical knowledge. As the information herein is of a general nature, no assumption can be
RESPONSIBILITY made as to a product's suitability for a particular use or application and no warranty as to its accuracy, reliability or
completeness either expressed or implied is given other than those required by law. The user is responsible for
checking the suitability of products for their intended use.
Field service where provided does not constitute supervisory responsibility. Suggestions made by BASF either
NOTE orally or in writing may be followed, modified or rejected by the owner, engineer or contractor since they, and not
BASF, are responsible for carrying out procedures appropriate to a specific application.
BASF Construction Chemicals UAE LLC Disclaimer: the LRQA mark relates
P.O. Box 37127, Dubai, UAE to certified management system and
Tel: +971 4 8090800 Fax: +971 4 8851002 not to the product mentioned on this
www.master-builders-solutions.basf.ae datasheet