Documente Academic
Documente Profesional
Documente Cultură
Pump
10
Valve on
oil inlet 13
Filter base
8
1 12
Stop filter Close valve Close valve Open air vent screw Open oil drain valve Unscrew top nut Lift off filter cover
on oil inlet on oil outlet and drain waste oil
into container
8 9 10 11 12 13
5
5 7
7 8 6
6
Replace
O-ring
Unscrew spring nut Remove spring Remove used Ensure filter Install new Mount spring guide carefully - make sure
and spring guide filter insert base is clean filter Insert there is no contact between O-ring and thread
14 15 16 17 18
70 Nm /
15 50 ft lbf
3 10 Nm / 4
5 7 ft lbf
Replace
O-ring
Replace Replace
usit ring usit ring
Tighten spring nut Tighten spring nut until spring guide is level Replace O-ring and Replace usit ring for Replace usit ring for
with top edge of filter housing. mount filter cover top nut. Tighten top air vent screw and
Tightening torque minimum 4 Nm / 3 ft lbf nut with torque of tighten with torque of
70 Nm / 50 ft lbf 10 Nm / 7 ft lbf
Manufacturer: C.C.JENSEN A/S • Løvholmen 13 • DK-5700 Svendborg • Phone +45 6321 2014 • Fax +45 6222 4615 • sales@cjc.dk • www.cjc.dk