Documente Academic
Documente Profesional
Documente Cultură
1. Plywood ( 4 ft x 4ft )
2. Square bits ( PVC Material)
3. Mirror Pieces
4. Screws, Bolts and Nuts
5. Screw Plugs Mirror Pieces Square Bit
6. Wooden Bar
7. L-shaped Clamp
8. Aluminium Can (Soft drink Can)
9. Aluminium sheet
10.DC Motor
L-shaped Clamp Buffer Stand
11.M-seal
12.Buffer Stand
13.Paints and Brushes
14.LED Bulb
15.Fevicol
16.Cycle Valve Screws, Nuts and Bolts
List of tools and equipments that we have used:
1. Drilling Machine
2. Centre punch
3. Screwdriver
4. Steel Ruler
5. Thread
6. Small saw
7. Ball Peen Hammer
8. Pliers
9.Metal Snip
Steps required for Fabrication of Model:
1. Making of Screw Joints:
• Cut uniform sized rectangular pieces from aluminium sheet using metal snip.
• Make a through hole at centre point using centre punch and ball peen hammer
• Pass screw through this hole which will in turn go into joints already created.
• Bend the ends of this rectangular piece to hold the mirror.
4. Joining wooden bar to plywood and painting the setup: