Documente Academic
Documente Profesional
Documente Cultură
M o tio n
LAB REPORT
Thannalin Patthanapan
Pornnatcha Petchdee
Kongpop Moon-UT
Jessica Rujipatanakul
Supanut Sriburachai GROUP 3
EVENT SPONSORS
G.11 2019
MS. SUSANA
ALLULOD
PROJECTILE MOTION
introduction
attempted to be kept constant velocity of the metal ball when shot from
Pen/Pencil
Metal Ball
Carbon Tape
Vernier
Launcher Measuring Tape
SET UP
PROCEDURE
Part A: Determine initial velocity of a projectile
1. Check the leveling and set launcher at horizon (0° angle). Use
no
2. Insert a metal ball into the launcher then pump in the air using
button then press "Launch" to fire the ball. !!Make sure no one
ball hit the table by putting a masking tape on the said spot.
no No no
of firing rod) no
noo
4. Reload and Launch the ball for 3 t8mes, measure the distance
from the middle launcher to landing spot. (When the ball hit
the masking tape, it will leave a black spot) !!Label each spot
no no
below.
1. Fire the projectile at the angles of 20°, 30°, 45°, 60°and 70°
Part 1
Part 2
Calculation
k
ANALYSIS AND
RESULTS:
PROJECTILE MOTION A+
Conclusion
Recommendation
Referrences
Work Log