Documente Academic
Documente Profesional
Documente Cultură
Pro Edit
Support for motion dive The previous V-LINK parameters have been gathered into Pro Edit.
.tokyo Console (V-LINK) You can use these parameters to set control changes on the DV-7PR
or PR-80.
fig.VLink2_60
The V-LINK System screen has been modified to support motion
dive .tokyo Console (MD-P1).
fig.VLink1_60
Note Tx Ch A: A channel
Note Tx Ch B: B channel
Note Tx Ch C: MIDI note Plug-in channel
• When using the MD-P1, you can control the effect of a channel
by matching Ctrl Tx Ch to Note Tx Ch A or Note Tx Ch B.
• Use Note Tx Ch A to change the MIDI channel of the DV-7PR.
* Use Note Tx Ch A if you want to use the dynamic pads to switch clips
as before.
Controller
You can assign V-LINK parameters to the REALTIME CONTROL
knobs, ASSIGNABLE switches, and D Beam controller. Parameters
preceded by an indication of “MD:” are MD-P1 parameters.
Values
OFF, Dissolve Time, Color Cb Ctrl, Color Cr Ctrl, Brightness Ctrl,
VFX1 Ctrl, VFX2 Ctrl, VFX3 Ctrl, VFX4 Ctrl, Fade Ctrl,
MD:ColorEQ Fore, MD:ColorEQ Back, MD:Scratch SW,
MD:Speed Knob, MD:Total Fader, MD:Cross Fader,
MD:BPM Sync SW, MD:Clip Loop SW, MD:Assign Knob,
MD:Fade Time SW, MD:Visual Knob, MD:A/B Switch,
MD:Tap Switch, MD:Total Select, MD:FX Select, MD:Play Pos,
MD:LoopStartPos, MD:Loop End Pos, MD:LayerModeSel
* If you want to use the REALTIME CONTROL knobs to control V-
LINK parameters, turn V-LINK on and set the REALTIME
CONTROL button to “ASSIGNABLE.”
If you want to use the D Beam controller to control V-LINK
parameters, turn V-LINK on and press the D Beam controller
[ASSIGNABLE] button.
2 1PS