Documente Academic
Documente Profesional
Documente Cultură
Application . . .
T-275 heat transfer compound is used where high
temperature maintenance or high exposure
temperatures are prevalent. Thermon heat transfer
compounds provide an efficient thermal connection
between the tracer and the process equipment. By
eliminating the air voids that would ordinarily exist,
heat is directed into the pipe wall primarily through
conduction rather than convection and radiation.
A single tracer utilizing Thermon’s heat transfer compound
has the equivalent performance of three to five air
convection (bare) tracers.
T-275 is typically utilized for high temperature applications
with maximum exposure temperatures of 275°C. To
minimize waste and speed installation, use Thermon
Channel Trace™ system featuring TFK galvanized steel
channel. The Channel Trace system provides mechanical and
weather protection prior to installation of thermal
insulation. Refer to the next page of this specification sheet
for details.
Specifications/Ratings . . . Description . . .
Benefits . . .
Increases heat transfer rates significantly over bare
tracing reducing number of tracers and steam traps
Compounds are water-resistant (not waterproof) when Typical InstalledCrossSection
completely cured
Cuts installation time and eliminate waste when using TFK (ChannelTrace system)
channel
No weatherproofing or curing required
Water-soluble for easy cleanup
Free design assistance
Basic Accessories . . .
Stainless Steel Banding...used to secure ALP-1...dielectric paint applied to TFK-4...galvanized steel channel 32 mm x 22
tracer, compound and channel to piping. aluminium pipe prior to compound mm covers heat transfer compound applied to
• T2SSB (12mm wide, 0.5mm thick) for application. 10 mm and 12 mm O.D. tube tracers.
10mm and 12mm O.D. tube tracers. 1950A...crimping tool for T34PB-CR TFK-7...galvanised steel channel 43 mm x 32
• T3SSB (12mm wide, 0.75mm thick) for seals. mm covers heat transfer compound applied to
20mm or 25mm OD tube and DN 20 or T34PB-CR...crimp seals for fastening 20 mm O.D. tube and DN 15 (1/ 2 inch NPS) pipe
25 (3/4 or 1 inch NPS) pipe tracers. tensioned banding. tracers.
C001...banding tool for applying tension TFK-9...galvanised steel channel 64 mm x 44
toT2SSB or T3SSB banding. mm covers heat transfer compound applied to
25 mm O.D. tube and DN 20 or 25 (3/ 4 or 1 inch
THERMON . . . INDUSTRIAL PROCESS HEATING SOLUTIONS TM
NPS) pipe tracers.
www.thermon.com
FACTORY & REGISTERED OFFICE :
THERMON INDIA PVT.LTD.
Gat No. 796+800/1, Dingrajwadi Road, Printed in INDIA Form : HTC275 -0618.
Koregaon Bhima, Taluka -Shirur, Pune - 412 216, MH.,INDIA Information Subject to change Sheet : 2 of 2
Phone: (02137) 287380