Documente Academic
Documente Profesional
Documente Cultură
K512a.de
Application
Ceramic linings must be tested and approved for
Substrate Pretreatment
application on ETICS from the manufacturer with
SM300 None respect to their material properties and colour.
Bonding is in accordance with EN 12004
Preparation Do not attempt to mix water to fresh adhesive using the floating and buttering method. Apply
Cover easily-soiled building components that is starting to set. Clean the machines and 2 - 3 mm Flex-Fliesenkleber adhesive onto the
before application in accordance with Code tools with water immediately after use. fixing surface using an 8 mm notched trowel.
of Practice “Abklebe- und Abdeckarbeiten für Application Spread adhesive across the entire rear surface
Maler- und Stuckateurarbeiten” issued by the Only apply as much adhesive as can be worked of the ceramic lining and push into the fresh
Bundesverband Ausbau und Fassade. Protect within the adhesive open time of approx. 30 mortar bed directly. Clean the joints immediately
weather-exposed surfaces from precipitation minutes to push in or apply ceramic tiles into the afterwards.
and direct sunlight. fresh adhesive mortar bed. Machines / equipment
All substrates must be stable, dry, even and free Ceramic linings permissible with the Knauf A mixer with a speed of 600 RPM with a
of grease and dust as well as free of any residual WARM WAND Keramik system are tiles or panels corkscrew or double-disk agitator.
substances that may reduce the adhesion. of the groups AI, BI a, BI b , AII a and BII a acc.
Application temperature / climatic conditions
Mixing to EN 14411. They must be frost-resistant acc.
Do not apply material at air and/or substrate
Application by hand: to EN ISO 10545-12. Furthermore, brick slips
temperatures below +5°C and above +25 °C.
Mix to a lump-free and application ready and clinker strips that meet the requirements for
Protect fresh adhesive from frost and rapid
consistency in a clean bucket with clean and facing bricks or tiles acc. to DIN 105-100 may
drying.
cold water. Mixing water ratio approx. 1 kg for be used.
0.30 litres. A mixer with a speed of 600 RPM The demands on the cladding and the surface Special notes
with a corkscrew or double-disk agitator. After a dimensions, pore radii volumes and sizes as well Apply according to DIN 18157-1, VOB part C
maturing time of approx. 3 minutes, mix again as the water absorption can be taken from the as well as the generally recognized building
thoroughly and apply within 2 hours. WARM WALL system approval Z-33.46-424. engineering rules and valid guidelines.
As soon as a skin starts to form on the flexible
Technical data adhesive applied to the wall, the adhesion
properties of the adhesive are considerably
EN 12004 reduced.
Reaction to fire: A1 EN 13501-1 Safety instructions and disposal
Initial tensile adhesion strength: ≥ 1.0 N/mm² EN 1348 See Safety Data Sheet.
Tensile adhesion strength after heat ageing: ≥ 1.0 N/mm² EN 1348
Tensile adhesion strength after water immersion: ≥ 1.0 N/mm² EN 1348
Tensile adhesion strength after freeze
-thaw cycle: ≥ 1.0 N/mm² EN 1348
Adhesive open time: approx. 30 minutes EN 1346
The stated technical data were evaluated acc. to the respective test standards. Deviations under site
conditions are possible.
The stated constructional and structural design specifications and characteristics of building physics of Knauf systems can
K512a.de/eng/06.14/FB/D
only be ensured with the exclusive use of Knauf system components, or other products expressly recommended by Knauf.