Documente Academic
Documente Profesional
Documente Cultură
Answer saved
Marked out of 1.00
Remove flag
Question text
Refer to the exhibit below. Which two statements about the configuration of the switch
interface are correct?
SwitchA(config)#interface fa0/0
SwitchA(config-if)#switchport access vlan 2
Select one:
a. 2 & 4
b. 1 & 5
c. 1 & 2
d. 4 & 5
Clear my choice
Question 2
Answer saved
Marked out of 1.00
Flag question
Question text
Select one:
a. ISL and 802.11g
b. 802.11g and 802.11n
c. 802.11a and 802.11b
d. ISL & IEEE 802.1q
Clear my choice
Question 3
Answer saved
Marked out of 1.00
Flag question
Question text
Refer to the exhibit. The two connected ports on the switch are not turning orange or
green. What would be the most effective steps to troubleshoot this physical layer
problem?
A. Ensure that the Ethernet encapsulations match on the interconnected router and
switch ports.
B. Ensure that cables A and B are straight-through cables.
C. Ensure cable A is plugged into a trunk port.
D. Ensure the switch has power.
E. Reboot all of the devices.
Select one:
a. 1, 2, 4
b. 1, 3, 5
c. 4, 5, 6
d. 2, 4, 6
Clear my choice
Question 4
Answer saved
Marked out of 1.00
Flag question
Question text
Select one:
a. 802.11a and 802.11b
b. ISL and 802.11g
c. 802.11g and 802.11n
d. ISL & IEEE 802.1q
Clear my choice
Question 5
Answer saved
Marked out of 1.00
Flag question
Question text
Select one:
True
False
Question 6
Answer saved
Marked out of 1.00
Flag question
Question text
Select one:
a. 802.1q
b. vlan
c. 802.11a
d. 802.11n
Clear my choice
Question 7
Answer saved
Marked out of 1.00
Flag question
Question text
Which three elements must be used when you configure a router interface for VLAN
trunking?
1. one physical interface for each subinterface
2. one IP network or subnetwork for each subinterface
3. a management domain for each subinterface
4. subinterface encapsulation identifiers that match VLAN tags
5. one subinterface per VLAN
6. subinterface numbering that matches VLAN tags
Select one:
a. 3, 4, 6
b. 1, 2, 4
c. 2, 4, 5
d. 1, 5, 6
Clear my choice
Question 8
Answer saved
Marked out of 1.00
Flag question
Question text
Select one:
True
False
Question 9
Not yet answered
Marked out of 1.00
Flag question
Question text
A switch is configured with all ports assigned to vlan 2 with full duplex FastEthernet to
segment existing departmental traffic. What is the effect of adding switch ports to a new
VLAN on the switch?
Select one:
a. An additional broadcast domain will be created.
b. IP address utilization will be more efficient.
c. More bandwidth will be required than was needed previously.
d. More collision domains will be created.
Clear my choice
Question 10
Not yet answered
Marked out of 1.00
Flag question
Question text
Refer to the exhibit. A router-on-a-stick configuration was implemented for VLANs 15,
30, and 45, according to the show running-config command output. PCs on VLAN 45
that are using the 172.16.45.0 /24 network are having trouble connecting to PCs on
VLAN 30 in the 172.16.30.0 /24 network. Which error is most likely causing this
problem?
Select one:
a. The GigabitEthernet 0/0 interface is missing an IP address.
b. The command no shutdown is missing on GigabitEthernet 0/0.30
c. There is an incorrect IP address configured on GigabitEthernet 0/0.30.*
d. The wrong VLAN has been configured on GigabitEthernet 0/0.45
Clear my choice