Documente Academic
Documente Profesional
Documente Cultură
Question 1 A network administrator is verifying the configuration of a newly installed host by establishing an
Correct FTP connection to a remote server.
Mark 1.00 out of What is the highest layer of the protocol stack that the network administrator is using for this
1.00 operation?
Select one:
a. Presentation
b. Transport
c. Session
d. Data link
e. Application
f. Internet
Question 2 A receiving host computes the checksum on a frame and determines that the frame is damaged.
Correct The frame is then discarded. At which OSI layer did this happen?
e. Data link
/
Question 3 What are three characteristics of the TCP protocol? (Choose three.)
Correct
Select one or more:
Mark 1.00 out of
1.00 a. It uses a single SYN-ACK message to establish a connection
b. It supports significantly higher transmission speeds than UDP.
c. It ensures that all data is transmitted and received by the remote device
d. It uses separate SYN and ACK messages to establish a connection
e. The connection is established before data is transmitted
/
Question 4 Refer to exhibit: Which destination addresses will be used by Host A to send data to Host C?
Correct (Choose two.)
/
Question 5 For what two purposes does the Ethernet protocol use physical addresses? (Choose two.)
Partially correct
Select one or more:
Mark 0.50 out of
1.00 a. to allow communication between different devices on the same network
b. to uniquely identify devices at Layer 2
c. to differentiate a Layer 2 frame from a Layer 3 packet
d. to allow communication with devices on a different network
e. to establish a priority system to determine which device gets to transmit
first
Question 7 What does a Layer 2 switch use to decide where to forward a received frame?
Correct
Select one:
Mark 1.00 out of
1.00 a. destination port address
b. destination IP address
c. source switch port
d. source MAC address
e. destination MAC address
f. source IP address
Select one:
a. one
b. two
c. twelve
d. six
/
Question 9 Refer to the exhibit. A network administrator attempts to ping Host2 from Host1 and receives the
Correct results that are shown.
Select one:
a. The link between Switch1 and Router1 is down
b. Interface Fa0/0 on Router1 is shutdown.
c. TCP/IP is not functioning on Host1
d. The link between Router1 and Router2 is down
e. The link between Host1 and Switch1 is down
f. The default gateway on Host1 is incorrect
/
Question 10 Refer to the exhibit. An administrator pings the default gateway at 10.10.10.1 and sees the
Correct output as shown. At which OSI layer is the problem?
Select one:
a. access layer
b. application layer
c. session layer
d. data link layer
e. network layer
b. VAI
c. OUI
d. BIA
/
Question 12 Refer to the exhibit. Both switches are using a default configuration. Which two
Correct destination addresses will host 4 use to send data to host 1? (Choose two.)
/
Question 13 What are two advantages of Layer 2 Ethernet switches over hubs? (Choose two.)
Correct
Select one or more:
Mark 1.00 out of
1.00 a. increasing the size of broadcast domains
b. allowing simultaneous frame transmissions
c. increasing the maximum length of UTP cabling between devices
d. decreasing the number of collision domains
e. filtering frames based on MAC addresses
Question 15 Which of the following are types of flow control? (Choose three.)
Correct
Select one or more:
Mark 1.00 out of
1.00 a. congestion avoidance
b. windowing
c. buffering
d. load balancing
e. cut-through
/
Question 16 Which of the following services use UDP? (Choose three.)
Correct
Select one or more:
Mark 1.00 out of
1.00 a. Telnet
b. HTTP
c. TFTP
d. SMTP
e. SNMP
f. DNS
Question 17 If host Z needs to send data through router R1 to a storage server, which destination MAC
Correct address does host Z use to transmit packets?
/
Question 20 Refer to the exhibit. Refer to the exhibit. After HostA pings HostB, which entry will be in the ARP
Correct cache of HostA to support this transmission?
Select one:
a.
b.
c.
d.
e.
f.
/
The correct answer is:
Question 21 Refer to the graphic. Host A is communicating with the server. What will be the source MAC
Correct address of the frames received by Host A from the server?
Select one:
a. the MAC address of the server network interface
b. the MAC address of router interface e0
c. the MAC address of host A
d. the MAC address of router interface e1
/
Question 22 Refer to the exhibit. What two results would occur if the hub were to be replaced with a switch
Correct that is configured with one Ethernet VLAN? (Choose two.)
Question 23 For what two purposes does the Ethernet protocol use physical addresses? (Choose two.)
Correct
Select one or more:
Mark 1.00 out of
1.00 a. to allow communication between different devices on the same network
b. to differentiate a Layer 2 frame from a Layer 3 packet
c. to establish a priority system to determine which device gets to transmit
first
d. to allow detection of a remote device when its physical address is
unknown
e. to uniquely identify devices at Layer 2
f. to allow communication with devices on a different network
/
◄ Slide bài giảng