Documente Academic
Documente Profesional
Documente Cultură
Anmol Dulku
TIJ1O0C
INTRODUCTION
The purpose of this experiment was to prove the OHM’s law and test it on a breadboard.
Another purpose was to learn how a breadboard works and how to make a proper
circuit and how to work it. Another purpose was so we learn how different resistors
affect the brightness of the LED.
MATERIALS
1. Breadboard
2. 6 pieces of wire(could need more if you mess up)
3. 3 LED lights
4. 3 resistors (one 100oms, one 1000oms, and one 5000oms)
TOOLS
1. Wire stripper
2. Nose plier
PROCEDURE
1
Results
2
RESULTS
The results are just as planned and the whole experiment went through good and it all
worked out. The results were that the circuit with the 100oms resistor was the brightest,
the circuit with 1000oms was fairly bright and the resistor with 10,000 oms was not
really bright and you can not see the light too good. So in the end, if there is less
resistance there is more light because if there is less resistance there are more electrons
going through the light/LED.
DISCUSSION
Answer: Yes, it all went as planned because all I wanted to experiment was that if the resistor has higher resistance
the light will be really dim and if it has a really low resistance it will be really bright.
Question #2: Why did different resistors affect the brightness on the light/LED?
Answer: The resistors affect the brightness of the light/LED because if there is more resistance there will be fewer
electrons flowing through the light/LED and if there is less resistance more electrons will go through the light/LED
and make the light/LED brighter.
Question #3: Did you come across any problems while making this circuit work? How did you fix them?
Answer: Yes, I did come across some problems, for example, I had one circuit that was perfect but the light was not
working even though it was done all right, the problem was that the light/LED was burned out. So to solve that
problem I simply just put a new light/LED in and it was up and running good. Another problem that I had was having
was putting in the wires into the breadboard, the wires were not touching the bottom of the breadboard. So to solve
this problem I just simply just stripped the wire a little more so it touches the bottom and it worked just as planned.
3
Question #4: What have I learned?
Answer: I learned a lot of things for example that if there is more resistance the light/LED will be less bright and if
there is less resistence the light/LED will be brighter. I have also learned how to make a proper circuit on a
breadboard and how the electrons move through the breadboard. I have also learned how to calculate the voltage,
amperage and resistance from the triangle. I have also learned more about real-life while Mr.Shaw was talking, for
example, how much voltage and amperage each house gets and how much voltage or amps we use in our house.
CONCLUSION
So, in conclusion, this whole “Proving OHM’s Law” experiment want really smoothly and
it was successful for the most part. I think that I have learned a lot from this experiment
and it was a lot of fun doing this whole experiment. So the result, in the end, is that the
higher the resistance the lower the brightness of the light/LED.
4