Documente Academic
Documente Profesional
Documente Cultură
1. clastic sedimentary rock composed of mud that is a mix of flakes of clay minerals and tiny
fragments (silt-sized particles) of other minerals, especially quartz and calcite is called......
Answer: shale
4. A general term for those gases that are acidic either alone or when associated with water
called?
Answer: Sour Gas
6. In the circulating system, what is between the stand pipe and the swivel ?
Answer: Mud hose / goose neck
7. What is the resistance of a fluid to flow in a dynamic condition due to the intramollecular
pulling force?
Answer: Yield point
ELIMINATION ROUND – TOSS UP B
2. What is Bioremediation ?
Answer : The process of decomposition of organic waste / hazardous inorganic
rendered harmless by using biological activity.
3. What is terminology for ratio of gas density to dry air density with both measured at the
same temperature and pressure?
Answer: gas specific gravity
5. The act of adjusting a model of a reservoir until it closely reproduces the past behavior of
a reservoir. The historical production and pressures are matched as closely as possible.
What is this procedure called?
Answer: History Matching
6. What is the term used to indicate a condition in which the pressure inside the drilling
pipes are higher than the pressure in annulus?
Answer: Burst
5. Volume can be measured with gallons, How many liters are there in a gallon?
Answer: 3.785 liter
7. At what point in the wellbore does the directional drilling activities begin?
Answer: Kick-off point
ELIMINATION ROUND – TOSS UP D
1. Sector boundary between the oil layer with the gas layer in the reservoir is called?
Answer: Gas Oil Contact
3. At one phase fluid flow in the reservoir, to calculate the flow rate of production which
equation van be used?
Answer: Darcy
6. What is the term for time needed for cement suspension to reach a consistency at which
the maximum limit when cement can be pumped?
Answer: Thickening time
7. What is the name of the hole on the drilling rig used to put kelly when tripping in or
tripping out?
Answer: Rat hole
ELIMINATION ROUND – TOSS UP E
2. Mention 3 reason, why the geothermal energy called environmentally friendly energy!
Answer: Very low CO2 emision; after used for electricity producing, fluid is
reinjected to the reservoir; not produce a dangerous waste for environment
5. Where is the gas field in Indonesia that contain the highest H2S?
Answer : Natuna
6. As a drilling engineer, your job is designing the casing string for wells. If you went with
P-110 casing, what parameter does the number 110 indicate?
Answer: Minimum yield strength
7. What is the name of a drilling operation in which only bit that rotates due to the mud flow
through the spiral pipe?
Answer: Positive displacement motor / PDM drilling
ELIMINATION ROUND – TOSS UP F
1. In 2000 BP, now a group of companies that included Amoco, ARCO and Castrol,
unveiled a new global brand with a new mark, a sunburst of green, yellow and white
symbolizing dynamic energy in all its forms. What is BP stands for
Answer : Beyond Petroleum
2. What methods are used in the fluid flow in a horizontal pipe for gas wells ? Mention 2 of
them!
Answer : Weymouth, panhandle, modified panhandle
3. What is the kind of separator that used mainly to remove any free water?
Answer: Free water knockout
5. What is the name of this gas field, this filed is discovered by Pertamina – Mobil Oil in
1971, this field is exist in Northest Sumatera
Answer : Arun
7. Which casing is used to prevent mud chemicals from contaminating the aquifer?
Answer: Surface casing
ELIMINATION ROUND – TOSS UP G
1. In June 2008, there is the world’s largest floating platform that the facility has a topside
deck the size of three football field. The platform name is Thunder Horse. The question is
where does that platform exist
Answer : Gulf of Mexico
Answer: 20-40%
5. What equipment is used when the sand plug in the hole perforations ?
6. What process is used for treating sulfur content of gas in order to satisfy the standard
specification of gas sales?
Answer: Gas sweetening
2. PDVSA as we known as one of the including new seven sister oil company, the question
is PDVSA is the company comes from
Answer : Venezuela
6. What is the main consideration related to engineering feasibility before deploying gas lift
method?
Answer: Gas availability
7. What reservoir production method works under the principle of decreasing fluid density
to decrese pressure losses in tubing?
Answer: Gas lift