Documente Academic
Documente Profesional
Documente Cultură
FLAME STOP I
FLAME RETARDANT FOR FABRICS, PAPER AND WOOD
PRODUCT DESCRIPTION:
FLAME STOP I is liquid interior flame retardant. It is neither harmful nor toxic and it can be applied on most fibres, including synthetic and
metallic fibres. It works also on cardboard and paper. If it is well applied, it will not leave white residues and will not peel off. In most circum-
stances, the product will not change the aspect of the fabric, will not bleach or shrink it. It is odourless and easy to apply. The fibres that are
more difficult to treat with a flame retardant are acrylic, acetate, plastic and nylon. It is recommended for all fibres to be pre-tested.
TECHNICAL DATA:
• Water-like appearance and consistence. 18,9 L (5 US gallons) bucket weight: 21,7 kg (48 lb).
• Storage: do not freeze. Store in a place where the temperature could vary from 7 to 43 °C (45 to 110 °F). Storage period: up to 3 years if
not open.
• FLAME STOP I is water-soluble. Dry-cleaning is recommended.
• Do not add water, nor modify the chemical composition. Always make sure the container is closed.
APPLICABLE STANDARDS:
FOR FABRICS: FLAME STOP I has been tested to the following standards: CAN/ULC-S109-03 for flame-resistant fabrics and films, NFPA 701,
ASTM E-84, NFPA 255, UL 723: U.S. Testing# LA 62192, CA Reg. #C-14401; Registered with the CSFM for use on interior decorative materials
only.
Class B rating on wood.
APPLICATION DIRECTIVES:
The users must determine the suitability of this product for its intended use.
FOR FABRICS: FLAME STOP I is ready to use and must be applied with caution. Applicator must wear paint goggles, respirator, and gloves.
FLAME STOP I will cover 18,5 to 37 m² (200 to 400 ft²) depending upon the fibre content of the item being treated. Using a Hudson type
orchard sprayer, apply at 40-60 PSI using a fan spray tip, spray entire area and cover completely to fabrics free of coatings and dirt. Testing
results will determine chemical amount and cure time. The state of CA requires application by a CA Certified Applicator to obtain docu-
mented certification. Allow to dry for 48 hours.
FOR WOOD: Before using, user should determine the suitability of this product for its intended use. The product is ready to use. Applicator
must wear paint goggles, respirator, and gloves. All wood must be free from coatings such as paint, sealant or dirt. Coverage is 23 m² (250
ft²) per 3,8 L (1 US gallon). Using a Hudson type orchard sprayer, apply at 40 60 PSI using a fan spray tip, spray entire area and cover
completely. The state of California requires application by a CA Certified Applicator to obtain documented certification. Allow to dry for 48
hours.
CLEAN-UP:
Flush sprayer and/or equipment with water and wash hands with soap and water.
CAUTION:
Keep out of reach of children. Do not ingest. Call physician if swallowed. Clean with soap and water all contacted areas. Flush eyes with
ophthalmic eye wash or with cool water for at least 15 minutes. If irritation persists, seek advice of a physician.