Documente Academic
Documente Profesional
Documente Cultură
Mazak
FX27/FX727 Blanking using Hyper terminal
Purpose:
To clear out the memory on a FX control.
Overview:
The purpose of this procedure is to clear out the control when getting parity errors on the control. This
procedure walks you through step by step on how to use Hyperterminal to clear out the memory of
the FX27/FX727. This procedure uses Windows 7, but other versions of Windows will work.
Hyperterminal is not standard on Windows 7, so it will need to be downloaded if not already on your
computer.
Tools Needed:
RS232 cable
Laptop with Hyperterminal
Instructions:
I. . Clearing out Memory
A. Connecting Laptop to Control.
1. Power off control.
2. Remove the FX701/FX01
3. Flip dip switch 8 to OFF.
10. After you press the configure button, you will get a COM1 properties window.
11. Set the port settings to match the picture below.
12. Once the Settings match make sure to click on the "Apply" button.
13. Click ok on the "COM1 properties" window.
14. Click ok again on the "Connect To" window.
15. This will bring you to a blank Hyperterminal screen.
C. Clearing using Hyperterminal.
1. With Hyperterminal open, power on the control.
2. The following screen will appear.
3. Type in the following command "FC000:0,FFFF,00" (Make sure that all letters are
Capitol letters like the figure shows).
4. If you type this incorrectly you will then have to start over.
5. The screen should then look like the picture below.
10. At this point the control should come up. You will then need to reload parameters back
into control.
Appendix: