Documente Academic
Documente Profesional
Documente Cultură
Autumn Twilight
Fabric 1
1/4 yard
3200-04 3200-05
Fabric 2
1/4 yard
3200-01 3200-07
Fabric 3
1/4 yard
3200-10 3200-06
Fabric 4
1/4 yard
©2017, RJR Fabrics
3200-02 3200-09
Fabric 5
1/4 yard
3200-03 3200-08
Fabric 6
1¼ yards
9617-201 9617-034
Backing
Two colorways.
2¼ yards cut in half lengthwise (20" x 81") or 7/8 yard
Finishes 13" x 78".
Suggested Backing Fabrics
Autumn - 3200-01 or 9617-201
Twilight - 3200-07 or 9617-034
r032019
Amber Waves Table Runner takes the simple 60° triangle to new design heights. This lovely project features fabrics from Jinny
Beyer’s Amber Waves fabric collection and will look at home on any table, traditional to contemporary. Suitable for the
intermediate quilter.
Fabric 1. A - cut 6, B - cut 4 C/Dr & Cr/D Units. Make two C/Dr units using C-2 and two
using C-5. Make two Cr/D units using Cr-2 and two using Cr-5.
Fabric 2. B - cut 8, C & Cr - cut
4 each, D & Dr - cut 4 each Lengthwise Grain Step 3: Make Pyramid & End Units
Referring to the diagrams below and the Color Guides on
Fabric 3. A - cut 6, B - cut 2
pages 3-4, make four Pyramid Units and two End Units. Take
care to orient all the A and B units so the stripes run towards
Fabric 4. B - cut 4, D & Dr - cut 6 each, E & Er - cut 4 each
the point of the pyramid.
Fabric 5. B - cut 8, C & Cr - cut 2 each
Transfer the dots from the templates to the wrong side of the
fabric patches for greater sewing accuracy.
A-3 End Units
Make a total of two using the
Step 2: Make B, E & C/D Units fabrics indicated.
Referring to the diagrams below, and the Color Guide for your Cr
C
colorway on page 3 or 4, make the B, E and C/D units. Before B-1
sewing, match and pin the patches at the dots.
15
sew the five rows together in order.
"
"
13
Repeat to make a second half of the table runner.
D-4 Dr-4
Row A-1
1 B-2 B-2
c) Frame Runner. Sew a 56" Fabric 6 strip
to both long sides of the runner. Trim the
Row B-4 B-4 strips even with the runner.
2 A-1
D-2 Dr-2 Next, sew an End Unit to opposite ends of
the runner, matching the seams. Note that
E Er the points on the Ends Units will extend
Cr -
3
Pyr-3
Row
5 Before Sewing
Pyr-1 The points on the End Units will extend
beyond the sides of the runner. Trim them
Make two of each row.
off after sewing.
With the Pyramid units facing, sew the two halves of the
runner together.
Step 6: Finish the Project
Pyr-1
quilt top (right side up). Baste the layers together, and quilt as
desired.
Step 5: Complete the Table Runner When the quilting is completed, trim the backing and batting
a) Make Border Pieces. Use the 21/8"-wide Fabric 6 strips as even with table runner edges.
follows:
• Sew together two strips to make one measuring 80". Bind the quilt using the reserved Fabric 6 strips.
Repeat to make a second. From each of these pieces, cut
one piece measuring 56" and one piece measuring 13".
• From the remaining 40" strip, cut two pieces each
measuring 15".
Er E
Dr-4 C-2 Cr-2 D-4
B-5 B-5
A-3 A-3
B-1
B-3
A-1
Cr-2
B-1
B-2 B-2
Rev Reg
Dr-4 C-2 Cr-2 D-4
B-5 B-5
B-3
A-1
C-2 Cr-2
B-1
B-2 B-2