Documente Academic
Documente Profesional
Documente Cultură
Technologies
DNC COMUNICATION
for
Machine Models
(290/300/500/1020 series)
06/25/97
Eric Ostini
Charmilles Technologies
DNC Communications
Cables .................................................................................................. Page 3
2 --------------------------- 2
3 --------------------------- 3
7 --------------------------- 7
2 --------------------------- 3
3 --------------------------- 2
7 --------------------------- 7
2 --------------------------- 2
3 --------------------------- 3
5 --------------------------- 7
2 --------------------------- 3
3 --------------------------- 2
5 --------------------------- 7
Charmilles Technologies
DNC Communications
Machine Setup
Explanation of Settings:
• Channel = This is the port(DB25) on the machine.
• Baud = The rate of speed at which the machine and the PC
communicate.
• Protocol = This is the language the machine uses according the the
following table.
Charmilles Technologies
DNC Communication
Machine Setup continues
Time out 1 = This is the maximum time between the reception of 2
consecutive characters. Time is measured in (ms) and is adjustable in a
range from 0 to 60,000.
Time out 2 = Maximum time the machine will wait after a pause in the
connection. Time is measured in (ms).
1) Leave these dip switches in this position in order to change the Baud
rate in <EXE><Service><Communication>
the black is the dip switches
Charmilles Technologies
DNC Communication
Machine setup continues
2) Switches for whether the cable is a RS232 or a RS422
The black are the dip switches:
Charmilles Technologies
DNC Communication
Communication with the Machine in MS-Dos
Setting up the PC to send a program
NOTE: if the cable is connected to com2 than replace com1 above with
com2.
2) You will see your PC repeat what you typed but with
commas between 4800 n 8 1 and put a negative symbol
next to the 1.
NOTE: do not hit enter until the machine is ready to receive the program.
You can get the machine ready to receive a program two different
ways:
NOTE: When you hit enter the machine will be ready to receive the program.
Charmilles Technologies
DNC Communication
Communication with the Machine in Windows 95
Setting up the PC to Send and Receive
The software Hyerterminal in Windows 95 will allow you to send and receive programs
to and from the machine.