Documente Academic
Documente Profesional
Documente Cultură
TEST AND INSPECTION PER: Manufacturers Standards, Drawings, Procedures, and Specifications As Noted Below.
0020
0010
***R X
In process inspection & test requirement
Impellers Overspeed Test & Dimensional check
Specification Details / Notes:
Required for all impellers at 115% minimum of rated speed held
for at least 1 minute. Dimensions check before and immediately
after test on impellers front and back at tip and hub locations.
0070 X b) Magnetic Particle orFluorescent Dye Penetrant For finished gear teeth.
0030
0010
***R X
Final inspection & test requirements
Compliance Check Against PO Requirements
Specification Details / Notes:
0040
0010
***R
Additional/Supplemental Requirements
Calibration of Hand Tools
Specification Details / Notes:
0020 R X Dimensions of All Polygons I. D. / O. D. To be recorded before final assembly & after final
disassembly.
IR780000 Continued...
INSPECTION & TESTING REQUIREMENTS REVISION: 12/01/2016 CODE NUMBER: PAGE:
SAUDI ARAMCO FORM-175 REPLACES: 06/08/2011 IR780000 2 of 2
(1).VISUAL INSPECTION BY BUYER INSPECTION REPRESENTATIVE
(2) REVIEW AND VERIFICATION OF MATERIAL CERTIFICATES AND INSPECTION RECORDS
(3) SUBMISSION OF MANUFACTURING, INSPECTION AND QUALITY RECORDS
0030 R X Thrust Collar & Impeller to Shaft Fits
0040 R X Impeller and Thrust Collar Bolts Specifications For impeller and thrust collar, per P.O. requirements.
Notes:
(1) Refer detailed instruction sheet SA175 form IR000003 of inspection requirement for ideal use of this form.
End of IR780000