Documente Academic
Documente Profesional
Documente Cultură
INSTRUCTIONS TO CANDIDATES :
1. SECTION-A is COMPULSORY consisting of TEN questions carrying T WO marks
17649 17649
each. 17649 17649 17649 17649 17649 17649 17649
2. SECTION-B contains FIVE questions carrying FIVE marks each and students
have to attempt any FOUR questions.
3. SECTION-C contains T HREE questions carrying T EN marks each and students
17649 17649 have to17649
attempt any 17649 17649
T WO questions. 17649 17649 17649 17649
o m
17649 17649 17649 17649
.r c
1. Write briefly :
a) Define Thermal conductivity. What is the effect of temperature on it?
m
17649 17649 17649 17649 17649 17649 17649 17649 17649
sphere?
p e
b) What is meant by critical thickness of insulation? How it is calculated in case of
o
a .r c
17649 17649 17649 17649 17649 17649 17649 17649 17649
c) Define Kirchoff’s law of radiation.
r p
d) Why thin fins are preferred over thick fins?
e
17649 17649 17649
b 17649 17649
a
17649
p
e) Draw temperature profile of a counter-flow heat exchanger.
17649 17649 17649
rp
17649 17649 f) What is reciprocity
17649 theorem?
17649 17649 17649 17649 17649 17649
17649 1|M
17649 -71186 17649 17649 17649 17649 17649 (S2)-1637
17649 17649
SECTION–B
17649 17649 17649 17649 17649 17649 17649 17649 17649
2. Derive two dimensional momentum equations for the hydrodynamic boundary layer on a
flat plate.
17649 17649 17649 17649 17649 17649 17649 17649 17649
3. Set up expression for three dimensional equation of temperature distribution during
steady state heat conduction in a solid cylinder with internal heat generation.
17649 17649 17649 17649
4. Derive relation of emissive power for17649 17649
non-black concentric 17649
cylinders 17649
of infinite length. 17649
5. Heat transfer coefficient depends upon the parameters such as fluid viscosity, thermal
17649 17649 conductivity,
17649 specific17649
heat, length/diameter
17649 and (gt).
17649 By using
17649dimensional analysis
17649 17649
establish the correlation.
o m
17649 17649 17649 17649
.r c
7. If a fin is thin and long and tip loss is negligible, show that the heat transfer from the fin
hP 17649
m
17649 17649
is given17649 17649
by Qfin = hPkA 17649
c (t0 – t f ) tanh .l . 17649 17649 17649
e
kAC
p o
a .r c
17649 8.
17649 For a hemispherical
17649 furnace, the flat
17649 17649floor is at 17649
700 K and has an emissivity
17649 of 0.5.
17649 17649
The hemispherical roof is at 1000 K and has emissivity of 0.25. Find the net radiative
r p
heat transfer from roof to floor and vice-versa.
e
17649 9.
17649 Write short
b
17649 notes on : 17649 17649
a
17649
p
a) Heat exchanger effectiveness and number of transfer units (NTU)
17649 17649 17649
rp
17649 17649 17649 17649 17649 17649 17649 17649 17649
b) Intensity of radiation and solid angle.
17649 17649
c) Different theories of nucleation.
17649 17649 17649 b 17649 17649 17649 17649
17649 2|M
17649 -71186 17649 17649 17649 17649 17649 (S2)-1637
17649 17649