Documente Academic
Documente Profesional
Documente Cultură
GENERAL NOTES:
1.The cost of block work shall include supply, testing, placing of approved
blocks, workmanship, mortar, scaffolds, filling mastic for expansion joints
and all other required materials, equipment and tools to complete the work
according to specifications and directions of the Architect or Engineer. The prices should also include B200 protection concrete
round sleeves and pipes of electrical,sanitary and mechanical pipes and ducts where required.
EXTERIOR WALL
FRONT - RIGHT-SIDE - REAR ELEVATION
200mm Concrete masonry wall, bedded and jointed in cement mortar 700 M²
including lintels, reinforcement, anchors, joints complete in all cases.
INTERIOR WALL
Ground Floor Level 240 M²
First Floor Level 196.6 M²
Roof Deck Annex 46 M²
Internal party wall (All floor levels) 141.2 M²
100mm THK. CHB wall @ pipe chase for all floor levels 60 M²
PARTY WALL
Exterior Party wall @ ground floor & roof deck 97 M²
2. Plastering should be done with cement mortar ratio of 1:3, 1:4, 1:6 etc. as per the requirements of the work. It should be in
straight line, leveled, plumbed and the joint must be in right angle.
EXTERIOR WALL
DIV-05 METALS
8.01 DOORS
GENERAL NOTES:
The following items shall be completed according to drawings, specifications and Architect's instructions.
(a) Door frames shall fit into walls and sizes of door openings, after
considering the thickness of plastering and frames.
(b) The shown dimensions on details are the architectural dimensions of
door leaves without the frames.
(c) All hardware for doors shall be Union type or equivalent approved type.
(d) Doors should be fitted with handles (colour & types as directed and
approved by the Architect)
(e)Steel frames should be filled with fine aggregate mortar concrete, for
fixation.
(f) For aluminum works, contractor shall submit shop drawings for the
Architect's approval before supplying & installation.
GENERAL NOTES:
All works must be according to drawings, specification and Architect's
instructions. Rates shall include:
(a) Submitting samples for approval of material, accessories, color and fixation method.
(b) All metal works include the fixation for frames and leaves and all required accessories according to the Architect's instructions.
DIV-09 FINISHES
GENERAL NOTES:
All works must be according to drawings, specification and Architect's instructions. Rates shall include :
(a) Prices of Tiles & Marble works shall include supply of all materials, testing, mortar, 5cm sand under tiles or marble or back the
tiles or marble (wall), skirting, workmanship,opening areas and all materials & tools and anywhere else, needed, all according to
drawings, specifications, conditions and directed instructions by the Architect or his representative.
FF-01
ENTRANCE
400mm x 400mm UNGLAZED non-skid marble tiles 16 M²
FF-02
FOYER, FAMILY HALL & DINING ROOM
400mm x 400mm POLISHED marble tiles 95 M²
Refer to floor finishing plan for tile pattern sheet A-21 to A-23
FF-03
GENTLEMEN'S RECEPTION & ALL BEDROOMS
400mm x 400mm POLISHED ceramic floor tiles with 8mm THK. 179 M²
carpet floor rugs on top (OPTIONAL).
FF-04
GROUND FLOOR KITCHEN & LAUNDRY AREA @ ROOF DECK
400mm x 400mm UNGLAZED non-skid ceramic floor tiles 56 M²
FF-05
TOILET & BATHROOM (ALL FLOOR LEVELS)
200mm x 200mm UNGLAZED non-skid ceramic floor tiles 60 M²
FF-06
TERRACE
400mm x 400mm UNGLAZED non-skid TERRAZO floor tiles 6 M²
FF-07
Waterproofing on concrete roof deck with polyurethane flexible coating 149 M²
PARTY WALL 2-sides (3 coats of paint same as the exterior wall) 196 M²
9.07 MISCELLANEOUS
DIV-10 SPECIALTIES
GENERAL NOTES:
Use only adhesives formulated for stone and recommended by the manufacturer for the application shown on the drawings. Water
cleanable epoxy adhesive: ANSI A118.3 with VOC content of 65 g/L or less when calculated according to 40 CFR 59.
Supply & install Polished pre-cast marble stair tread w/ non-skid strips & bullnose 1 LOT
Stair stringer (optional) 1 LOT
12mm THK. Fiber Cement Board including aluminum C-CHANNEL studs 1 LOT
& fixing attachments @ toilet, tea room & pantry.
GRAND TOTAL: "DIVISION 1" GENERAL REQ'TS. TO "DIVISION 10" SPECIALTIES SAR
ABBREVIATIONS:
LS - Lump Sum
MOS - Months
M² - Square Meter
LM - Linear Meter
PCS - Pieces
SET - Complete Set
GALS - Gallons
LOT - All