Documente Academic
Documente Profesional
Documente Cultură
1. Identification
* The “Recommended use” identified for this product is provided solely to comply with a Federal requirement and is not part of
the seller's published specification. The terms of this Safety Data Sheet (SDS) do not create or infer any warranty, express or
implied, including by incorporation into or reference in the seller's sales agreement.
Company:
BASF CORPORATION
100 Park Avenue
Florham Park, NJ 07932, USA
CHEMTREC: 1-800-424-9300
BASF HOTLINE: 1-800-832-HELP (4357)
2. Hazards Identification
According to Regulation 2012 OSHA Hazard Communication Standard; 29 CFR Part 1910.1200
Label elements
Safety Data Sheet
N,N-Diethylaminoethyl Methacrylate (DEAEMA)
Revision date : 2015/03/18 Page: 2/12
Version: 5.0 (30482702/SDS_GEN_US/EN)
Pictogram:
Signal Word:
Warning
Hazard Statement:
H227 Combustible liquid.
H319 Causes serious eye irritation.
H315 Causes skin irritation.
H332 Harmful if inhaled.
H317 May cause an allergic skin reaction.
H401 Toxic to aquatic life.
H411 Toxic to aquatic life with long lasting effects.
If applicable information is provided in this section on other hazards which do not result in
classification but which may contribute to the overall hazards of the substance or mixture.
See section 12 - Results of PBT and vPvB assessment.
According to Regulation 1994 OSHA Hazard Communication Standard; 29 CFR Part 1910.1200
Safety Data Sheet
N,N-Diethylaminoethyl Methacrylate (DEAEMA)
Revision date : 2015/03/18 Page: 3/12
Version: 5.0 (30482702/SDS_GEN_US/EN)
Emergency overview
WARNING:
COMBUSTIBLE LIQUID.
May cause sensitization by skin contact.
This product can cause skin and eye irritation.
Inhalation may cause respiratory irritation.
HARMFUL IF INHALED.
Use NIOSH approved respirator as needed to mitigate exposure.
Wear NIOSH-certified chemical goggles.
Eye wash fountains must be easily accessible.
Avoid all sources of ignition: heat, sparks, open flame.
Ground conductive equipment properly to prevent electrostatic discharge.
Exothermic polymerization may occur if storage conditions are exceeded or inhibitors become
insufficient.
Wear suitable protective clothing, gloves and eye/face protection.
According to Regulation 1994 OSHA Hazard Communication Standard; 29 CFR Part 1910.1200
4. First-Aid Measures
General advice:
First aid personnel should pay attention to their own safety. If the patient is likely to become
unconscious, place and transport in stable sideways position (recovery position). Immediately
remove contaminated clothing.
If inhaled:
Keep patient calm, remove to fresh air, seek medical attention. Immediately administer a
corticosteroid from a controlled/metered dose inhaler.
If on skin:
Immediately wash thoroughly with plenty of water, apply sterile dressings, consult a skin specialist.
If in eyes:
Immediately wash affected eyes for at least 15 minutes under running water with eyelids held open,
consult an eye specialist.
Safety Data Sheet
N,N-Diethylaminoethyl Methacrylate (DEAEMA)
Revision date : 2015/03/18 Page: 4/12
Version: 5.0 (30482702/SDS_GEN_US/EN)
If swallowed:
Immediately rinse mouth and then drink plenty of water, do not induce vomiting, seek medical
attention. Never induce vomiting or give anything by mouth if the victim is unconscious or having
convulsions.
Symptoms: The most important known symptoms and effects are described in the labelling (see
section 2) and/or in section 11.
Hazards: No hazard is expected under intended use and appropriate handling.
Note to physician
Treatment: Treat according to symptoms (decontamination, vital functions), no
known specific antidote, administer corticosteroid dose aerosol to
prevent pulmonary odema.
5. Fire-Fighting Measures
Extinguishing media
Further information:
Vapours are heavier than air and may accumulate in low areas and travel a considerable distance up
to the source of ignition. Fight fire from maximum distance.
Ensure adequate ventilation. Use personal protective clothing. Breathing protection required. Avoid
all sources of ignition: heat, sparks, open flame.
Environmental precautions
Safety Data Sheet
N,N-Diethylaminoethyl Methacrylate (DEAEMA)
Revision date : 2015/03/18 Page: 5/12
Version: 5.0 (30482702/SDS_GEN_US/EN)
Do not discharge into waterways or sewer systems without proper authorization. Contain
contaminated water/firefighting water.
This product is not regulated by RCRA. This product is not regulated by CERCLA ('Superfund').
Heated containers should be cooled to prevent polymerization. If exposed to fire, keep containers
cool by spraying with water. Emergency cooling must be provided for the eventuality of a fire in the
vicinity. Sealed containers should be protected against heat as this results in pressure build-up.
Avoid influence of heat.
Further information on storage conditions: Prior to storage ensure that the transfer equipment used
and the intended storage containers do not contain other substances/products. Before transfer to
stock the identity of the product must be proved to be without doubt. The entrance to storage rooms
is to be granted only to appropriately trained personnel.
Protect from direct sunlight. Protect contents from the effects of light. Avoid UV-light and other
radiation with high energy. Protect against contamination.
All storage containers should at least be equipped with two high temperature alert devices.
Even if the product is stored and handled as prescribed/indicated it should be used up within the
indicated duration of storage.
Hand protection:
Chemical resistant protective gloves
Eye protection:
Tightly fitting safety goggles (chemical goggles).
Body protection:
light protective clothing
Reactivity
No hazardous reactions if stored and handled as prescribed/indicated.
Corrosion to metals:
No corrosive effect on metal.
Oxidizing properties:
not fire-propagating (other)
Formation of Remarks: Forms no flammable gases in the
flammable gases: presence of water.
Chemical stability
The product is stable if stored and handled as prescribed/indicated.
Conditions to avoid
Avoid heat. Avoid oxygen content above the product of less than 5 %. Do not blanket with nitrogen.
Avoid UV-light and other radiation with high energy. Avoid direct sunlight. Avoid prolonged storage.
Avoid inhibitor loss. Avoid excessive temperatures. Avoid all sources of ignition: heat, sparks, open
flame.
Incompatible materials
polyvinylchloride, radical formers, free radical initiators, peroxides, mercaptans, nitro-compounds,
perborates, azides, ether, ketones, aldehydes, amines, nitrates, nitrites, oxidizing agents, reducing
agents, strong bases, acid anhydrides, acid chlorides, concentrated mineral acids, metal salts
Inert gas
Decomposition products:
Hazardous decomposition products: No hazardous decomposition products if stored and handled as
prescribed/indicated.
Thermal decomposition:
No decomposition if stored and handled as prescribed/indicated.
Safety Data Sheet
N,N-Diethylaminoethyl Methacrylate (DEAEMA)
Revision date : 2015/03/18 Page: 8/12
Version: 5.0 (30482702/SDS_GEN_US/EN)
11. Toxicological information
Routes of entry for solids and liquids are ingestion and inhalation, but may include eye or skin
contact. Routes of entry for gases include inhalation and eye contact. Skin contact may be a route
of entry for liquefied gases.
Acute Toxicity/Effects
Acute toxicity
Assessment of acute toxicity: Of moderate toxicity after short-term inhalation. Of low toxicity after
single ingestion.
Oral
Type of value: LD50
Species: rat
Value: 4,696 mg/kg
Inhalation
Type of value: LC50
Species: rat
Value: approx. 11 mg/l
Exposure time: 4 h
The vapour was tested.
Irritation / corrosion
Assessment of irritating effects: Corrosive! Damages skin and eyes.
Skin
Species: rabbit
Result: Corrosive.
Method: OECD Guideline 404
The European Union (EU) has classified this substance with 'Irritating to skin' (R38).
Eye
Result: Irritating.
Sensitization
Assessment of sensitization: Sensitization after skin contact possible.
Aspiration Hazard
not applicable
Safety Data Sheet
N,N-Diethylaminoethyl Methacrylate (DEAEMA)
Revision date : 2015/03/18 Page: 9/12
Version: 5.0 (30482702/SDS_GEN_US/EN)
Chronic Toxicity/Effects
Genetic toxicity
Assessment of mutagenicity: The substance was not mutagenic in bacteria. The substance was
mutagenic in a mammalian cell culture test system. The substance was not mutagenic in a test with
mammals.
Carcinogenicity
Assessment of carcinogenicity: On the basis of currently available information, a final assessment is
not possible.
Reproductive toxicity
Assessment of reproduction toxicity: The results of animal studies gave no indication of a fertility
impairing effect. The results were determined in a Screening test (OECD 421/422).
Teratogenicity
Assessment of teratogenicity: No indications of a developmental toxic / teratogenic effect were seen
in animal studies. The results were determined in a Screening test (OECD 421/422). On the basis of
currently available information, a final assessment is not possible.
Other Information
The product has not been tested. The statements on toxicology have been derived from the
properties of the individual components.
Symptoms of Exposure
The most important known symptoms and effects are described in the labelling (see section 2)
and/or in section 11.
Toxicity
Aquatic toxicity
Assessment of aquatic toxicity:
Acutely harmful for aquatic organisms.
Toxicity to fish
LC50 (96 h) > 100 mg/l, Oryzias latipes (OECD Guideline 203)
Aquatic invertebrates
EC50 (48 h) 360 mg/l, Daphnia magna (OECD Guideline 202, part 1)
Aquatic plants
EC50 (96 h) > 10 mg/l, Selenastrum capricornutum (OECD Guideline 201)
Bioaccumulative potential
Safety Data Sheet
N,N-Diethylaminoethyl Methacrylate (DEAEMA)
Revision date : 2015/03/18 Page: 10/12
Version: 5.0 (30482702/SDS_GEN_US/EN)
Bioaccumulation potential
No significant accumulation in organisms is expected as a result of the distribution coefficient of n-
octanol/water (log Pow).
Mobility in soil
Additional information
Container disposal:
WARNING: Empty containers may still contain hazardous residue. Do not cut or weld containers,
even empty containers. Flammable vapors may exist in containers in which residues of this product
remain. Dispose of in accordance with national, state and local regulations.
RCRA:
Not a hazardous waste under RCRA (40 CFR 261).
Sea transport
IMDG
Hazard class: 9
Packing group: III
ID number: UN 3082
Hazard label: 9, EHSM
Marine pollutant: YES
Proper shipping name: ENVIRONMENTALLY HAZARDOUS SUBSTANCE, LIQUID,
N.O.S. (contains 2-DIETHYLAMINOETHYL METHACRYLATE,
STABILIZED)
Air transport
IATA/ICAO
Hazard class: 9
Packing group: III
ID number: UN 3082
Hazard label: 9, EHSM
Safety Data Sheet
N,N-Diethylaminoethyl Methacrylate (DEAEMA)
Revision date : 2015/03/18 Page: 11/12
Version: 5.0 (30482702/SDS_GEN_US/EN)
Proper shipping name: ENVIRONMENTALLY HAZARDOUS SUBSTANCE, LIQUID,
N.O.S. (contains 2-DIETHYLAMINOETHYL METHACRYLATE,
STABILIZED)
Federal Regulations
Registration status:
Chemical TSCA, US released / listed
State regulations
Assessment of the hazard classes according to UN GHS criteria (most recent version):
We support worldwide Responsible Care® initiatives. We value the health and safety of our
employees, customers, suppliers and neighbors, and the protection of the environment. Our
commitment to Responsible Care is integral to conducting our business and operating our facilities in
a safe and environmentally responsible fashion, supporting our customers and suppliers in ensuring
the safe and environmentally sound handling of our products, and minimizing the impact of our
operations on society and the environment during production, storage, transport, use and disposal of
our products.
Safety Data Sheet
N,N-Diethylaminoethyl Methacrylate (DEAEMA)
Revision date : 2015/03/18 Page: 12/12
Version: 5.0 (30482702/SDS_GEN_US/EN)
IMPORTANT: WHILE THE DESCRIPTIONS, DESIGNS, DATA AND INFORMATION CONTAINED
HEREIN ARE PRESENTED IN GOOD FAITH AND BELIEVED TO BE ACCURATE , IT IS
PROVIDED FOR YOUR GUIDANCE ONLY. BECAUSE MANY FACTORS MAY AFFECT
PROCESSING OR APPLICATION/USE, WE RECOMMEND THAT YOU MAKE TESTS TO
DETERMINE THE SUITABILITY OF A PRODUCT FOR YOUR PARTICULAR PURPOSE PRIOR
TO USE. NO WARRANTIES OF ANY KIND, EITHER EXPRESSED OR IMPLIED, INCLUDING
WARRANTIES OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE, ARE
MADE REGARDING PRODUCTS DESCRIBED OR DESIGNS, DATA OR INFORMATION SET
FORTH, OR THAT THE PRODUCTS, DESIGNS, DATA OR INFORMATION MAY BE USED
WITHOUT INFRINGING THE INTELLECTUAL PROPERTY RIGHTS OF OTHERS. IN NO CASE
SHALL THE DESCRIPTIONS, INFORMATION, DATA OR DESIGNS PROVIDED BE CONSIDERED
A PART OF OUR TERMS AND CONDITIONS OF SALE. FURTHER, YOU EXPRESSLY
UNDERSTAND AND AGREE THAT THE DESCRIPTIONS, DESIGNS, DATA, AND INFORMATION
FURNISHED BY OUR COMPANY HEREUNDER ARE GIVEN GRATIS AND WE ASSUME NO
OBLIGATION OR LIABILITY FOR THE DESCRIPTION, DESIGNS, DATA AND INFORMATION
GIVEN OR RESULTS OBTAINED, ALL SUCH BEING GIVEN AND ACCEPTED AT YOUR RISK.
END OF DATA SHEET