1. Phase angle if the inductive reactance is the same as the resistance in an RL
45 degrees circuit: 2. As the size of the plates in a capacitor increases, all other things being equal: Xc decreases negatively 3. As the frequency of ac increases in a coil, the reactance: Gets largely positive 4. True power divided by apparent power Power Factor 5. In vector diagram, the distance from the center of the graph represents: Peak Amplitude Depends on the construction of 6. The characteristic impedance of a transmission line: the line 7. Allows the lowest forward voltage drop in a diode Germanium 8. Avalanche voltage is routinely exceed when a P-N junction acts as a: Voltage regulator 9. An unimportant factor concerning the frequency at which a P-N junction will Reverse Current work effectively is: 10. If the output wave in a circuit has the same shape as the input wave, then: The circuit is linear 11. The capacitance of a varactor varies with: Reverse Voltage 12. A device that commonly oscillates: A Gunn diode 13. Coherent radiation is produced by a: Laser diode 14. A photodiode, when not used as a photovoltaic cell, has: Reverse bias 15. Designed to provide high power at low voltage Full wave, center-tap 16. Part of power supply immediately preceding the regulator is: The Filter 17. Transresistance of an amplifier is the ratio of: Output voltage to Input current 18. A JFET may work better than a bipolar transistor in: A radio receiver 19. Range of input impedance in JFET 1 MΩ to several hundred MΩ The input signal is stronger than 20. A gain of -15 dB in a circuit means that: the output signal 21. A resistor between the base of an NPN bipolar transistor & the positive supply Provide Proper bias voltage is used to: 22. Amplifier classes that generally needs most driving power Class B 23. With class A, the output signal should be: Unclipped 24. A tapped coil is used in a(n): Hartley Oscillator 25. A continuously variable signal is recovered from a signal having discrete states A D/A conveter by: 26. Type of component which is generally not practical for fabrication for IC: Inductor 27. A typical audio recording tape thickness is: 1 mil 28. In a junction FET, the control electrode is usually the: Gate The filament serves as the 29. In a tube with a directly heated cathode: cathode 30. In a tube with a cold cathode: There is no filament 31. Tube with three grids: Pentode 32. A heptode tube has: Five grids The achievable power output 33. In a magnetron, as the frequency is increased : decreases 34. A klystron is noted for its: High achievable output power 35. The largest possible decimal number that can be represented by 6 binary digits 63 is: 36. Voltage that represents a 1 in positive logic: 4V 37. Voltage that represents a 1 in negative logic: 0V 38. If X & Y are both high, X NOT Y: LOW 39. Possible input combinations of a four input logic circuit (WXYZ): 16
Compiled by: NLAM
40. Frequency Synthesizer makes use of: A divider 41. A diode can be used as a frequency multiplier because of its: Nonlinearity 42. Frequency multiplication is possible with a semiconductor diode because diode Non-Linear is: 43. The extent to which an oscillator maintains a constant frequency is called it: Stability A high-power radio-frequency 44. A vacuum tube would most likely be found in: linear amplifier 45. In a radio frequency power amplifier using a vacuum tube, stability can be enhanced by using a circuit in which of the following electrode is at RF ground Control grid potential 46. A device consisting of a receiver and transmitter in the same box is called a: Transceiver 47. Platter is a: Part of a hard drive 48. Thermal shutdown occurs in an IC regulator if: Internal temperature is too high 49. In a power supply, resistors are sometimes connected in series with the diodes Protect the diodes against surge in order to: currents 50. One way to keep interelectrode capacitance to a minimum is to: Keep wire leads short Is slanted with respect to the 51. The axis of geomagnetic field: rotational axis 52. Resistivity of wire can be specified in: Ohm per meter 53. A dc voltage divider network is made using: Resistors 54. A diode that can be used as a variable capacitance is a: Varactor 55. The approximation that distorts digital signals the least is the: Bessel 56. If n = 10, the approximation with the fastest rolloff in the transition region is: Elliptic has Lowpass, high pass, band 57. State-variable filter: pass 58. Id is always 1/4 of Idss as long as Vgs is ____ of Vp : 1/2 59. ac Emitter current is eqaul to the ac base current multiply by: ac Current gain 60. Range of transconductance (gm) values 1000 uS to 5000 uS 61. A law states that the polarity of the induced voltage will oppose the change in Lenz' Law magnetic flux causing the induction 62. The ability of a mechanically stressed ferromagnetic wire to recognize rapid Weigand Effect switching of magnetization when subjected to a dc magnetic field 63. An LF157A is a: BiFET Op Amp 64. The output waveform of a 555 timer is: Rectangular 65. Astable 555 timer has: 0 stable states 66. The open-loop cutoff frequency of a 741C is controlled by Compensating capacitor 67. 741C uses: Discrete resistors 68. An audio amplifier operates in the frequency range of: 20 Hz to 20 kHz 69. Advantage of ac over dc: Easily step up or down 70. 6 2nd order stage & 1 1st order stage is: Order 13 71. In common emitter configuration, the output is _____ out of phase with the 180° input: Input and output are 180° out of 72. Negative voltage gain in Common Emitter indicates that: phase 73. Uses to correct for limited GBW: Predistortion Differential input and differential 74. The typical input stage of an op amp has a: output / Differential input and single-ended output? 75. The output is proportional to the difference between the voltages applied to Differential Amplifier the two inputs: 76. For maximum peak-to-peak output voltage, the Q point should be: At the center of the ac load line
Compiled by: NLAM
77. An E-MOSFET with its gate connected to its drain is an example of: Active load 78. With active-load switching, the upper E-MOSFET is a: Two-terminal device 79. The input signal used with a JFET analog switch should be: small 80. The pulse width out of a one-shot multivibrator increases when the: Timing capacitance increases 81. When Q decreases in a Colpitts oscillator, the frequency of oscillation: decreases 82. The unity-gain frequency equals the product of closed-loop voltage gain and Closed-loop cutoff frequency the 83. A second-order all-pass filter can vary the output phase from: 0-360° 84. Technique used for sinusoidal ac analysis in transistor circuit: Small- to Large-Signal 85. At the lower or upper cutoff frequency, the voltage gain is: 0.707 Amid because the image frequency 86. A low in not practical for single- receiver: would be too close to the incoming signal frequency 87. The all-pass filter is sometimes called a: Delay equalizer 88. The distortion in an Emitter Follower is usually: Very Low diagonal with respect to the tape 89. A video recording tape in image-signal track : edges 90. When Q is greater than 1, a bandpass filter should be built with: MFB stages 91. In an ac amplifier using an op amp with coupling and bypass capacitors, the Minimum output offset voltage is: 92. When slew-rate distortion of a sine wave occurs, the output: Appears triangular Two times either collector 93. The tail current of a diff amp is: current Is usually less than the load 94. The ac emitter resistance of an emitter follower: resistance Almost totally insensitive to 95. The Q point of a VDB circuit is: changes in current gain it is not a cause to worry; it 96. If load impedance is too high: cannot be too high 97. Capacitor values in oscillator circuits depend on: Frequency signal 98. Single output multiple input Universal Logic Module 99. The bandwidth of lowpass filter Capture Range 100. The collector voltage of a VDB circuit is not sensitive to changes in the: Current gain 101. The Q point of TSEB does not depend on the: Current gain