Documente Academic
Documente Profesional
Documente Cultură
doc
PAGES: 5 REVISION : A
3D PRINTER
TITLE: D6 Plus Leveling and adjusting Z INITIATE BY: Mikey
offset APPROVED BY:
1.0 Purpose
This document guides you on how to level and adjust the Z offset on Duplicator 6 Plus
2.0 Scope
This document establishes the specifications required for Duplicator 6 Plus and covers the
leveling method of firmware V2.24.hex
NOTE: Make sure you have the latest version of firmware installed on your printer.
3.2 Here is where you should rotate the know and lower or raise the print bed. Rotating knob to
the right direction (Clockwise) will raise the print bed and closer to nozzle.
3.3 Use a paper as thin as A4 paper to ensure the proper distance between the nozzle and print
bed. Again, you can rotate the knob to the right and left and find the best distance between
nozzle and print bed.
You Can again use the paper to ensure the distance between nozzle and print bed in different
corners of the print bed. By adjusting the spring under the print bed you can set the proper gap
between nozzle and print bed.
3.5 This process repeats for other corners of the print bed.