Air compressor works between two pressure limits max and min, the
max pressure is set so that when reached the compressor stop
loading that is it may stop or turn in idle and the min pressure is the one below which the compressor functions in loading mode, and the loading time will calculated from the moment the compressor starts loading (it depends on the pressure in the tank) and the moment the max pressure is obtained in the tank.
There is a pressure sensing instrument (i.e. pressure transmitter or
pressure switch) located at the discharge (usually at outlet of after cooler) of compressor which senses and give signal to MCU for Pressure values for Loading time.
To calculate the total running hours of air compressor, NEMO
internal opt coupler is used.
The filters are to be replaced for the pre specified durations.