Sunteți pe pagina 1din 47

Electrical Harness Overview

Electrical Guide
Models - M2106, M2112, 108SD, 114SD

Body Builder Reference Guide


Revision - B - 12/1/15
Page 1
Electrical Harness Overview

Index
Page 2 Index Page 25 Body Lighting Interface Schematics
Page 3 Electrical Component Overview Page 26 Trailer PDM
Page 4 Electrical Harness Overview Page 27 Trailer Electrical Schematics (Seperate)
Page 5 Electrical Power flow Overview Page 28 Trailer Electrical Schematics (Combination)
Page 6 PNDB Power Net Distribution Box Page 29 Trailer and Floor connections
Page 7 Positive Disconnect Switch Page 30 Tail Lights
Page 8 Main Power Distribution Module (PDM) Page 31 Tail Light Schematics
Page 9 PDM / VBAT Fuse Coverage Page 32 Transmission Interface
Page 10 Bulk Head Module (BHM) Page 33 Engine Interface
Page 11 Bulk Head Module (BHM) Pin Detail Page 34 PTO Installation
Page 12 Chassis Module (CHM) Page 35 PTO Controls
Page 13 Chassis Module (CHM) Pin Detail Page 36 PTO Air Schematics
Page 14 Multiplexing System Backbone Page 37 PTO Electrical Schematics
Page 15 System Tap Points Page 38 Remote Start Stop
Page 16 J1939-250K Gateway Page 39 VDR Prep Information (NFPA)
Page 17 Low Current Smart Switches Page 40 SmartPlex VDR Connections
Page 18 High Current Switches (Battery Hot) Page 41 Snow Plow Lights
Page 19 High Current Switch (BH) Schematics Page 42 SmartPlex Overview
Page 20 High Current Switches (Ignition Interlocked) Page 43 SmartPlex Overview Continued
Page 21 High Current Switch (Ignition Interlocked) Schematics Page 44 SmartPlex Overview Continued
Page 22 High Current Switch Label Options Page 45 SmartPlex Switch Decoder
Page 23 Body Builder Lighting Interface Page 46 SmartPlex Schematic
Page 24 Body Builder PDM Page 47 SmartPlex Schematic

Rev - B

Page 2
Body Lighting
& Smartplex Interfaces Trailer Interfaces
(Module 35M, 353, 296) Electrical Component Overview (Module 296, 297)

Tail Light
Configurations
(Module 294)
Accessory Air
Valve Assembly (AAVA)
(Module 46E )

Dash Switches
(Module 329)

Transmission Interfaces
(Grey Plug)
(Plugs may also
be frame located
(Module 34C)

Chassis Module
(CHM Under Cab)
(Module 335, 32K)

Engine Interface
(Black Plug)
(Plugs may also
be frame located)
(Module 148, 163, 87L)
Power Net Distribution Box
Bulk Head Module (PNDB)
(BHM)
Power Distribution (Module 33P/281/293)
(Module 32A)
(Module 285 PDM) Rev - B

Page 3
Electrical Harness Overview
ABS/AMU HARNESS Module 332
1) Connections to Forward chassis
harness and frame ground studs near
Chassis module
2) Connections to AMU (Mod 877 without ABS)
3) Connections to Wabco ABS ECU
4) Connections to rear combo valves
FORWARD CHASSIS HARNESS Module 288 AFT CHASSIS HARNESS Module 28A
1) Connections to Bulkhead module and Underhood PDM 1) Connections to Chassis Module
2) Connections to headlamps 2) Connections to tail lamps
3) Connections to side marker/turn lamps
4) Connections to Chassis Module

Body Builder and Trailer PDM’s


Modules 353 and 335
1) PDM for higher current trailer wiring
POWERTRAIN HARNESS Module 286, 283 (and TEM lighting)
1) Connections to the Bulkhead 2) PDM for SmartPlex 20A circuits
Module and Underhood PDM 3) PNDB for Body power distribution

OVERHEAD CAB HARNESS Module 287


1) Inline connection to Main cab Harness
(at bottom of A pillar)
2) Connections to Marker Lamps
3) Connections to Dome Lamp

FRONTWALL HARNESS Module 321


1) Connections to Bulkhead Module and Underhood PDM MAIN CAB HARNESS Module320
2) Connection to Starter Mag Switch 1) Connections to bulkhead connector
3) Connection to Wiper Motor 2) Connections to diagnostic connector (behind ignition switch)
4) Connection to the low coolant level sensor and horn (under surge tank) 3) Connections to CPC
5) Connection under cab to Washer pump and level switch 4) Pass-thru connector to engine compartment
6) Pass-thru connector to Main Cab Harness and Powertrain Harness 5) Gauge Cluster
6) HVAC unit and controler
7) Steering wheel horn and windshield wiper
Rev - B

Page 4
Smartplex ECU Engine Connector 32A -Bulkhead Module Outputs
ICU Transmission Connector B5.F - Cigar Lighter Output B1.P - Ignition (ABS)
B3.E - Horn B2.L - Ignition (Trans)
Body Lighting Connector B5.E - SPARE (Utility Light/Spotlight) B1.F - Fuel Water Sensor Power
ECM
Electrical Power Flow Overview B4.M - SPARE (Utility Light/Spotlight) B5.D - Instrument Cluster
B5.G - SPARE (Ignition) B5.B - Dome Lamps Switched
B5.H - Panel Lamps B1.L - Left High Beam
B7.A1 - Panel Lamps (Smart Switch) B1.R - Left Low Beam
Trailer Connector B4.F - SPARE (Left Heated Mirror) B5.C - Clearance Lamps
B4.E - SPARE (Right Heated Mirror) B1.K - Tail/License Plate
TCM Body Lighting Conn B6.A9 - Accessory (HVAC)
/Trailer Relay
B3.F - Wiper High
B6.A10 - Accessory (Radio) B3.H - Wiper Low
Main PNDB Tail Lights
B5.A - Battery (Dome Lamps) B3.G - Washer Pump
B7.A12 - Battery (Smart Switch) B2.M - AC Clutch
Main PDM Engine Connector B6.A8 - Ignition (VCU) B4.B - Starter Relay (Crank)
B2.K - Ignition (Engine)
BHM Transmission Connector
BB PDM
Powertrain
PDM BB PNDB
CHM 32K - Chassis Module Outputs
Trailer PDM C4-D Left Marker Lamp
Battery C4-C Left Park Lamp
Smartplex PDM C3-N Turn Left Front/Side
C3-R Turn Right Front/Side
C3-L Right Low Beam
C4-K Right High Beam
Multiplexed C3-K Right DRL
J1939 500K J1939 C4-F Left DRL
Network 250K Node C3-C Optional Fog/Road Lamps (296/297) Trailer
C3-D Optional Fog/Road Lamps
C5-H AMU Solenoid #0 Trailer Connector
C5-J AMU Solenoid #1
C5-L AMU Solenoid #2
PDM
Gateway Engine C5-M AMU Solenoid #3
C3-A Optional Fuel Water Separator Heater
Connector
C2-F Trailer Marker Relay
C2-H Trailer Turn Left Relay
C2-E Trailer Turn Right Relay BB
ECM C2-A Trailer Power Relay PDM
C2-D Trailer Stop Lamp Relay
Transmission (353) Body
Connector C4-M Right Marker Lamp Lighting Conn
Powertrain C4-L Right Park Lamp
PDM TCM C1-P Turn Right Rear
Main C1-G Turn Left Rear BB
C1-H Backup Alarm
PNDB C1-J Right Backup Lamp
PNDB
C1-A Left Backup Lamp
BHM C1-N Left Stop Lamp
C1-L Right Stop Lamp
Main C3-P Tail/License Plate Lamp
PDM (294) Tail
CHM Lights

ICU

Battery
Smartplex

Rev - B

Page 5
Power Net Distribution Box (PNDB) Mod 33P Fuse Cover
and label
The PNDB is a power distribution module designed for the
SmartPlex system to deliver more consistent and better PNDB Power Net Distribution Box
protected power from the battery to the other components
on the truck.

The PNDB also has protected keep alive circuits that ATC Fuses
maintain power even when the cutoff switch is in the off position. MIDI Fuse
The primary reason for this change is to provide power to the Output
DEF purge system, which drains urea from the delivery
ATC Fuse
system and prevents the system from freezing during cold Output
conditions. Primary
Solenoid
The PNDB located at the front wall is equipped with three for Cut off
MIDI fuses which supply power to the Main Power Switch
Distribution Module. These fuse connections were
relocated from the battery box in 2010 to prevent corrosion INSTALLATION WITH INSTALLATION WITHOUT
and improve the trucks reliability in severe conditions. DISCONNECT SWITCH DISCONNECT SWITCH
Battery
A secondary PNDB is available as an option for the body builder and Primary Solenoid
Input
is located with the trailer and bodybuilder PDM located in the cab Cut Off Switch
behind the drivers seat on day cabs or under the rear bench seat for Connection
crew cab units. Ordered with 33M-001.

CONNECTOR PIN DESCRIPTION


1 AFTER TREATMENT ECU
X2 KEEP ALIVE 2 EMERGENCY POWER 3 12
CIRCUIT 3 RADIO AND CLOCK
4 ALTERNATOR REMOTE SENSE ATC -A
A GROUND ATC -B
B SIGNAL OFF ATC -C D C B A
X1 SOLENOID C LED INDICATOR
CONTROL ATC -D
D SIGNAL ON
E SIGNAL RETURN Battery Input
F GROUND
4 3 2 1 300 AMPS Max

Fuse Description Function Rating Max. Fuse Allowed


D C B A
ATC-A Keep Alive Power After Treatment ECU 30 AMPS 30 AMPS
ATC-B Keep Alive Power Emergency Power 20 AMPS 30 AMPS
ATC Fuse output
ATC-C Keep Alive Power Radio and Clock 5 AMPS 30 AMPS
A B C Solenoid Control keeps power on after
ATC-D Keep Alive Power Alternator Remote Sense 5 AMPS 30 AMPS
disconnect
MIDI-1 (Fuse 1) High AMP Fuse Powertrain PDM 175 AMPS 200 AMPS Mating connector
MIDI-2 (Fuse 2) High AMP Fuse PDM #2 125 AMPS 200 AMPS D E F
23-13153-410
MIDI-3 (Fuse 3) High AMP Fuse PDM #1 125 AMPS 200 AMPS Typical Terminal
23-13211-000 thru -004 Rev - B

Page 6
Positive Load Disconnect Switch Mod 293
Lockout Tab
The disconnect switch system can be ordered as a negative or Positive Load Disconnect Switch
positive disconnect switch. Auxiliary Power
and Main Power
Main Cab PNDB
In cab disconnect switches are offered in a locking or non locking Connector Plug LED
configuration. #23-13153-307

Exterior battery mounted switches are offered in the locking


configuration only. 1
2
3
Cutoff switches are equipped with red LED lights, which are 1
2
Illuminated when power is on. 3
Body Builder PNDB 4
Trucks equipped with the body builder auxiliary power system Connector Plug
#23-13662-401
will have an additional LED light on the switch.
Axillary Body Builder Standard
Note: Both PNDB units will be deactivated when the switch is in Cutoff Switch Cutoff Switch
the off position. X1, Main PNDB
Standard Power LED
X2, Aux PNDB
293-058 POSITIVE LOAD DISCONNECT W/CAB MTD CONTROL SWITCH MTD OB DR SEAT
293-060 POSITIVE LOAD DISCONNECT W/CAB MTD CTRL SW W/LOCKING PROV MTD OB DR DEAT
293-061 POSITIVE LOAD DISCONNECT W/BATTERY BOX CTRL SWITCH W/LOCKING PROVISION
293-063 NEGATIVE LOAD DISCONNECT W/BATTERY BOX DISCONNECT SWITCH
293-068 NEGATIVE BATT S/O SW FOR CUM AT BATT BOX W/LOCKING PROV, PARTIAL PDI INST
293-069 NEG BATT S/O SW FOR CUM IN CAB OB DR ST W/LKG PROV, PARTIAL PDI INST

In Cab Mounted Disconnect Battery Box Disconnect Switch Mounting Battery Box Disconnect Switch Mounting
Switch Mounting with box mounted air tanks without box mounted air tanks
293-058 (brackets will vary depending on application) 293-061, 293-063 Rev - B
293-061

Page 7
Power Distribution Module Fuse Specifications*
Fuse MEGA Output VBAT Fuse Fuse
Connection Primary Function Secondary Function
Location Fuse Fuse Rating Rating
Main Power Distribution Module (PDM) Mod 285 F1 1 Green A Spare { { {
F2 1 Green B Blower Motor 30A { {

F3 2 Green H Engine ECU 20A { 30A


The main Power Distribution Module (PDM) distributes Main Power Distribution Module (PDM) F4 2 Green G Engine ECU 20A Spare 30A

battery power to the various control modules on the F5 1 Black D Ignition Switch 5A { {
F6 1 Black C Spare { AUX HVAC 30A
vehicle. Pin and seal part numbers for harness connection F7 1 Gray F Bulkhead Module VBAT 5 BHM 30A { {

23-13213-120 TERM-FEMALE,(20-16) PAC12077411 F8 2 Green C ICU3-M2 10A { {


The PDM contains mini fuses that protect the power feed 23-13213-121 TERM-FEMALE,(14-12) PAC12129493 F9 2 Green D Trans ECU 30A { 30A†

circuits to these modules. 23-13213-122 TERM-FEMALE,(10) PAC12077413 F10 2


Blue G
Green F
Spare { Door Locks/Utility Lamp 10A
23-12497-000/-002/-019 SEAL,(20-16) F11 2 Blue H Spare { Mirrors 15A
For most trucks there will be spare fuse slots available 23-12497-000/-001/-002 SEAL,(14-12) F12 1 Black H Radio/Diagnostic 20A { {
for customers to add additional wiring to the truck after 23-12497-001 SEAL,(10) F13 1 Grey E Chassis Module VBAT 3 CHM 30A { {
F14 1 Black B Spare { LH Power Window 15A
it is purchased. F15 2 Black A Bulkhead Module VBAT 4 BHM 30A { {
F16 2 Blue A ABS ECU (pneumatic) 15A ABS ECU (hydraulic) 25A
There are four plugs attaching to the module that supply F17 2 Blue C Chassis Module VBAT 2 CHM 30A { {

output connections. F18


F19
2
2
Blue B
Grey G
Bulkhead Module
Chassis Module
VBAT 3 BHM

VBAT 1 CHM
30A
30A
{
{
{
{
F20 1 Black E Bulkhead Module VBAT 2 BHM 30A { {
Common spare fuse sockets are listed below but may PDM Plugs F21 1 Black F Spare { RH Power Window 15A

vary based on the options that have been requested. contain output F22 1 Black G
Grey H
Bulkhead Module VBAT 1 BHM 30A { {

wires F23 1
Blue E
Spare { { {

Common Spare Fuse locations Hydraulic Pump and


F24 Grey D Spare { 25A
F6, F10, F11, F14, F21, F23, F25, F26 1
Motor (hydraulic ABS)
F25 2 Grey C Spare { Optional Switches 30A
Grey A
F26 2 Grey B Spare { { {
Blue D

Engine Harness Forward Chassis


Multiple Wire output Plug (Green) Harness Plug (Blue)
Pin A & B on Grey
Plug and Pin D
on Blue Plug

B
Single Wire Output
Forward
found on Green G H G
Chassis
Plug in Pin G G F B D AB Harness
H D C C Plug
PDM #1 (Grey)
C A D
(MIDI-3)
F A E H

B B G
Front
C E F
Wall
PDM # 2 A D H E Harness
(MIDI-2) Plug
(Black)

Rev - B

Page 8
VBAT Fuse System

BHM and CHM output pins are powered by multiple VBAT fuses
through the main PDM unit. If one of these fuses is tripped or blown PDM VBAT Fuse Coverage
then all pins in the circuit will be affected.
For this reason seemingly unrelated issues can occur at the same
time if a fuse is overloaded and trips.
Bulkhead Module BHM
The lists below show which pins are controlled with the VBAT fuses. Power Supply Fuses and Associated Outputs for the Bulkhead Module
BHM Power Fuse Supplying BHM BHM
BHM Power Input BHM Outputs Supplied
Chassis Module CHM Input Pin Power Input Output Pin
Power In Power Out
Power Supply Fuses and Associated Outputs for the Chassis Module
Battery (dome lamps) B5.A
CHMPower CHMPower Fuse Supplying CHM CHM
CHM Outputs Supplied Battery (smart switches) B7.A12
Input Input Pin Power Input Output Pin
Ignition (VCU) B6.A8
Power In Power Out
Ignition (engine) B2.K
Right Low Beam C3.L
Ignition (ABS) B1.P
Turn Right Front/Side C3.R
Ignition (trans) B2.L
Turn Right Rear C1.P Fuel Water Sensor Power B1.F
Right Stop Lamp C1.L
VBAT1 B3.D Fuse 22(30A) Dome Lamps Switched B5.B
VBAT1 C4.P Fuse 19(30A) Left Stop Lamp C1.N Left Low Beam B1.R
Right DRL C3.K A/C Clutch B2.M

C3.C/C3.D Smart Switch 1 Indicator B7.B4


Fog/Road Lamps
Smart Switch 2 Indicator B7.B8
Trailer Turn Right C2.E
Smart Switch 3 Indicator B7.A5
Left Park Lamp C4.C
Smart Switch 4 Indicator B7.A9
Right Park Lamp C4.L Smart Switch 5 Indicator B7.B10
Left Marker Lamp C4.D
Right Marker Lamp C4.M Accessory (HVAC) B6.A9
Trailer Marker Relay C2.F Accessory (radio) B6.A10
Wake Up (instrument cluster) B5.D
Right High Beam C4.K VBAT2 B4.G Fuse 20(30A)
VBAT2 C3.J Fuse 17(30A) Left Backup Lamp C1.A
Left High Beam B1.L
Wiper High B3.F
Right Backup Lamp C1.J
Horn B3.E
Backup Alarm C1.H
Wiper Low B3.H
Turn Left Front/Side C3.N Spare 8.0 A HSD (ignition) B5.G
Turn Left Rear C1.G
VBAT3 B1.N Fuse 18(30A)
Panel Lamps B5.H
Left DRL C4.F Panel Lamps (smart switch) B7.A1
Trailer Turn Left C2.H Clearance Lamps B5.C

Fuel Water Separator Heater C3.A Tail Lamps/License Plate B1.K


VBAT4 B4.K Fuse 15(30A) Lamp/Trailer Tail Relay
AAVA Solenoid 0 C5.H Washer Pump B3.G
VBAT3 C4.J Fuse 13(30A) AAVA Solenoid 1 C5.J 12V Output (cigar lighter) B5.F
AAVA Solenoid 2 C5.L Spare 8.5A (utility light/spotlight) B5.E/B4.M
AAVA Solenoid 3 C5.M VBAT5 B1.J Fuse 7(30A) Left Heated Mirror B4.F
Right Heated Mirror B4.E
VBAT4 C3.S Fuse 17(30A) Common Feed w/ VBAT2 C3.J
Rev - B

Page 9
Bulkhead Module (BHM) Mod 32A B3 Front B4 Front
Wall Harness Wall Harness
The BHM is the primary command module for the mulitplex system.
Bulkhead Module (BHM)
The BHM controls the operation of the other modules in the system,
either directly or indirectly using messages sent over the J1939 network. B5 Dash
Harness
The BHM is mounted on the driver side of the front wall and connects
to the interior wiring through an opening in the front wall.
The BHM has four harness connections on the engine side of the front wall B6 Dash
and three harness connections to the cab interior. B2 Engine Harness
The BHM contains all system parameters and the unit controls power flow Harness
and circuit protection to the various components of the mulitplex electrical system.
The BHM can also directly support up to 5 smart switches. The BHM is B7 Dash
programable and can be changed and updated by flashing the unit through B1 Forward Chassis Harness
ServiceLink.
Harness
Power supply for the BHM is supplied using VBAT fuses, which reside in the
main PDM (see page 8).
The BHM is programmable and the feature screen in ServiceLink can be used to
change or add parameters to the BHM.

Key Bulkhead Module Outputs


- Bulkhead Module outputs have defined amperage limits.
- If higher loads are required, bulkhead module outputs should be used as signal
power in conjunction with a relay.

20A B5.F - Cigar Lighter Output B6.A8 - Ignition (VCU)


B3.E - Horn B2.K - Ignition (Engine)
12A 6.7A B1.P - Ignition (ABS)
Combined B2.L - Ignition (Trans)
12A B5.E - SPARE (Utility Light/Spotlight)
B4.M - SPARE (Utility Light/Spotlight) B1.F - Fuel Water Sensor Power
Combined
Pin part numbers for harness connection
12A B5.G - SPARE (Ignition) 6.7A B5.D - Wake Up (Instrument Cluster)
Outside Cab Connections: 6.7A B5.B - Dome Lamps Switched
12A B5.H - Panel Lamps 6.7A B1.L - Left High Beam
23-13212-120 TERM-FEMALE,(18-16) PAC153047191
Combined B7.A1 - Panel Lamps (Smart Switch) 6.7A B1.R - Left Low Beam
23-13212-121 TERM-FEMALE,(14-12) PAC15304720
23-13212-122 TERM-FEMALE,(10) PAC15326004 B4.F - SPARE (Left Heated Mirror)
12A 6.7A B5.C - Clearance Lamps
Combined B4.E - SPARE (Right Heated Mirror) Combined B1.K - Tail/License Plate/Trailer Relay
Inside Cab Connections:
23-13213-102, PAC12129494 TERM-FEMALE,(12-14) 6.7A B6.A9 - Accessory (HVAC) 6.7A B3.F - Wiper High
23-13213-100, PAC12034046 TERM-FEMALE,(16-18) B6.A10 - Accessory (Radio) B3.H - Wiper Low
Combined 6.7A
B5.A - Battery (Dome Lamps) 6.7A B3.G - Washer Pump
6.7A B2.M - AC Clutch
Combined B7.A12 - Battery (Smart Switch) 6.7A
6.7A B4.B - Starter Relay (Crank)

Rev - B
Page 10
Connector B4 Frontwall Harness Pinouts
Signal Name
ABCD B4 Front Connector Pin Signal Type

B3 Front Wall Harness


B4-A AirFilterRestriction/Spare#9 DigitalInput
EFGH B4-B StarterRelay DigitalOutput
Wall Harness B4-C Ground Ground
B4-D SpareDigitalInput2 DigitalInput
Connector B3Frontwall Harness Pinouts Bulkhead Module (BHM) Pin Detail B4-E RightHeatedMirror(sparedigitaloutput) DigitalOutput
Connector Pin Signal Name Signal Type
ABCDEF B4-F LeftHeatedMirror(sparedigitaloutput) DigitalOutput
B3-A J1939- 500K Datalink Datalink
Mod 32A GHJKLM B4-G MainBatteryPower(VBAT2) Power
B3-B J1939+ 500K Datalink Datalink B4-H ModuleWake-UpSignal DigitalInput/Output
B3-C WiperParkedPosition DigitalInput B4-J

|
B3-D MainBatteryPower(VBAT1) Power B4-K MainBatteryPower(VBAT4) Power
B3-E Horn DigitalOutput B4-L WasherFluidLevel(sparedigitalinput8) DigitalInput
B3-F WiperMotorHighSpeed DigitalOutput B4-M UtilityLight/Spotlight(sparedigitaloutput) DigitalOutput
B3-G WasherPump DigitalOutput
B3-H WiperMotorLowSpeed DigitalOutput
B5 Dash
Harness
Connector B2Engine Harness Pinouts Connector B5 Dash Harness Pinouts
Connector Pin Signal Name Signal Type B2 Engine Connector Pin Signal Name Signal Type
B5-A DomeLampsBattery DigitalOutput
B2-A J1587+Datalink (not available after Jan 1, 2016) Datalink
Harness B5-B DomeLampsSwitched DigitalOutput
B2-B J1939+ 500K Datalink Datalink

HGFE
ABCD
B2-C J1587+ Datalink(not available after Jan 1, 2016) Datalink B5-C ClearanceLamps(cab) DigitalOutput

HJKLMNP
ABCDEF G
B2-D J1587- Datalink (not available after Jan 1, 2016) Datalink B5-D InstrumentClusterWake-Up DigitalOutput
B2-E B5-E UtilityLight/Spotlight(sparedigitaloutput) DigitalOutput
|

B2-F B5-F CigarLighter DigitalOutput


|

B2-G BackupSwitch(sparedigitalinput3) DigitalInput B5-G IgnitionPower,Other(sparedigitaloutput) DigitalOutput


B2-H J1587 Datalink (not available after Jan 1, 2016) Datalink B5-H PanelLamps DigitalOutput
B2-J J1939- 500K Datalink Datalink
B2-K EngineECUIgnitionPower DigitalOutput
B2-L TransmissionECUIgnitionPower DigitalOutput
B2-M A/CClutch DigitalOutput B6 Dash
B2-N
Harness
|

B2-P AlternatorCharging DigitalInput


Connector B6 Dash Harness Pinouts
B7 Dash Connector Pin Signal Name Signal Type

Harness B6-A1 IgnitionSwitchAccessoryPosition DigitalInput

A1 A2 A3 A4 A5 A6 A7 A8 A9 A10 A1 1 A12
B1 B2 B3 B4 B5 B6 B7 B8 B9 B10 B11 B12
B6-A2 ModuleWake-UpSignal DigitalInput
Connector B7Dash Harness Pinouts

A1 A2 A3 A4 A5 A6 A7 A8 A9 A10 A1 1 A12
B1 B2 B3 B4 B5 B6 B7 B8 B9 B10 B11 B12
SRPNMLKJ B1 Forward Connector Pin Signal Name Signal Type B6-A3 IgnitionSwitchOn DigitalInput
B6-A4
HGFEDCBA Chassis Harness B7-A1 PanelLamps(smartswitch) DigitalOutput

|
B7-A2 SmartSwitch3ID1 AnalogInput B6-A5 IgnitionSwitchStart DigitalInput
B7-A3 SmartSwitch3ID2 AnalogInput B6-A6 PassengerDoorOpen(sparedigitalinput10) DigitalInput
Connector B1ForwardChassis Harness Pinouts
B7-A4 SmartSwitch3Input AnalogInput B6-A7 DriverDoorOpen DigitalInput
Connector Pin Signal Name Signal Type
B7-A5 SmartSwitch3Indicator DigitalOutput B6-A8 VCUIgnitionPower DigitalOutput
B1-A
|

B7-A6 SmartSwitch4ID1 AnalogInput


B6-A9 HVACPower DigitalOutput
DigitalInput/ B7-A7 SmartSwitch4ID2 AnalogInput
B1-B ModuleWake-UpSignal
Output B6-A10 RadioPower DigitalOutput
B7-A8 SmartSwitch4Input AnalogInput
B1-C SpareDigitalInput4 DigitalInput B6-A11 J1587- Datalink (not available after Jan 1, 2016) Datalink
B7-A9 SmartSwitch4Indicator DigitalOutput
B1-D B6-A12 J1587+ Datalink (not available after Jan 1, 2016) Datalink
|

B7-A10 SmartSwitch5ID1 AnalogInput


B1-E Ground PowerGround B6-B1 HornSwitch DigitalInput
B7-A11 SmartSwitch5ID2 AnalogInput
B1-F Fuel/WaterSensorIgnitionPower DigitalOutput B6-B2 TopofClutchSwitch(sparedigitalinput7) DigitalInput
B7-A12 SmartSwitchBatteryPower DigitalOutput
B1-G Ground SignalGround B6-B3 BottomofClutchSwitch(sparedigitalinput6) DigitalInput
B7-B1 SmartSwitch1ID1 AnalogInput
B1-H J1587+ Datalink (not available after Jan 1, 2016) Datalink B7-B2 SmartSwitch1ID2 AnalogInput B6-B4

|
B1-J BatteryPower(VBAT5) Power B7-B3 SmartSwitch1Input AnalogInput B6-B5 PanelLampsIncrease DigitalInput
B1-K TailLamps/LicensePlateLamp/TrailerTailRelay DigitalOutput B7-B4 SmartSwitch1Indicator DigitalOutput B6-B6 PanelLampsDecrease DigitalInput
B1-L LeftHighBeam DigitalOutput B7-B5 SmartSwitch2ID1 AnalogInput
B6-B7 A/C ClutchRequest DigitalInput
B1-M Fuel/WaterSeparator(sparedigitalinput5) DigitalInput B7-B6 SmartSwitch2ID2 AnalogInput
B6-B8 HazardSwitch DigitalInput
B1-N BatteryPower(VBAT3) Power B7-B7 SmartSwitch2Input AnalogInput
B6-B9 HeadlampSwitchPARKPosition DigitalInput
B1-P ABSIgnitionPower DigitalOutput B7-B8 SmartSwitch2Indicator DigitalOutput
B6-B10 HeadlampSwitchOnPosition DigitalInput
B1-R LeftLowBeam DigitalOutput B7-B9 Ground SignalGround
B7-B10 SmartSwitch5Indicator DigitalOutput B6-B11 HeadlampSwitchOn2Position DigitalInput
B1-S J1587- Datalink (not available after Jan 1, 2016) Datalink
B7-B11 SmartSwitch5Input AnalogInput B6-B12

|
B7-B12
Rev - B
|

Page 11
C2 Trailer
C1 Tail Light Module Harness
Harness

Chassis Module (CHM) - Module 30K


Chassis Module (CHM)
C3 Forward
The Chassis Module (CHM) serves in the multiplex electrical system Chassis
by acting as a dependant to the Bulkhead Module (BHM). Harness
The CHM responds to commands from the BHM and broadcasts
the status of the inputs and outputs that are received, and delivered
by the module.
All vehicles are multiplexed and will always come equipped with a
Chassis Module. C4 Forward
Chassis
Harness
C5 Air
Management Unit

Key Chassis Module Outputs


- Chassis Module outputs have defined amperage limits.
- If higher loads are required, Chassis Module outputs should be used as signal
power in conjunction with a relay.

The CHM is under the cab 20A C3-A Optional Fuel Water Separator Heater 6.7A C3-L Right Low Beam
to improve durability and C4-C Left Park Lamp 6.7A C4-K Right High Beam
free up frame space 10A
C4-L Right Park Lamp
6.7A C1-N Left Stop Lamp
C4-D Left Marker Lamp
Combined C4-M Right Marker Lamp 6.7A C1-L Right Stop Lamp
C2-F Trailer Marker Relay
6.7A C3-K Right DRL
C3-N Turn Left Front/Side 6.7A C4-F Left DRL
7.5A C1-G Turn Left Rear
Combined 6.7A C3-C Optional Fog/Road Lamps
C2-H TrailerTurn Left C3-D Optional Fog/Road Lamps
Combined
C3-R Turn Right Front/Side
7.5A C1-P Turn Right Rear
Combined 0.85A C5-H AMU Solenoid #0
C2-E TrailerTurn Right
Pin part number for harness connection C1-A Left Backup Lamp 0.85A C5-J AMU Solenoid #1
23-13212-120 TERM-FEMALE,(18-16) PAC153047191 6.7A C1-J Right Backup Lamp
23-13212-121 TERM-FEMALE,(14-12) PAC15304720 Combined 0.85A C5-L AMU Solenoid #2
C1-H Backup Alarm
23-13212-121 TERM-FEMALE,(10) PAC15326004 0.85A C5-M AMU Solenoid #3

0.2A C2-A Trailer Power Relay

Rev - B

Page 12
A B C D
C2 Trailer E F G H
Module Harness
Trailer Module Harness Pinouts at Connector C2
A B C D E F G C1 Tail Light Chassis Module (CHM) Pin Detail Connector and
Signal Name Signal Type
Full Standard
H J K L M N P Pin Numbers
Harness C2-A Trailer Power Relay Digital Output X |
Mod 32K C2-C Ground Power Ground X |
Taillight Harness Pinouts atConnector C1 C2-D Trailer Stop Lamp Relay Pass-through Pass-through X |
Connector and Signal Type Full Standard C2-E Trailer Right Turn Lamp Digital Output X |
Signal Name
Pin Numbers
C2-F Trailer Marker Lamps Relay Digital Output X |
C1-A LeftBackupLamp DigitalOutput X X
C2-G Trailer Taillight Relay Pass-through Pass-through X |
C1-D LeftTaillightPass-through Pass-through X X
C2-H Trailer Left Turn Lamp Digital Output X |
C1-E RightTaillightPass-through Pass-through X X
C1-F LicensePlateLamp DigitalOutput X X
C1-G LeftRearTurnLamp DigitalOutput X X
C1-H BackupAlarm DigitalOutput X X C3 Forward
C1-J RightBackupLamp DigitalOutput X X Chassis Harness
C1-L RightStopLamp DigitalOutput X X Forward Chassis Harness Pinouts at Connector C3
C1-N LeftStopLamp DigitalOutput X X Connector and
Signal Name Signal Type Full Standard
Pin Numbers
C1-P RightRearTurnLamp DigitalOutput X X

H G F E D C B A
J K L M N P R S
C3-A Fuel/Water Separator Heater Digital Output X |
C3-B J1587-Datalink (not available after Jan 2016) Datalink X X
C3-C Fog/RoadLamps Digital Output X |
C3-D Fog/RoadLamps Digital Output X |
C3-E Low Air Pressure Digital Input (active low) X X
C3-F Park Brake Digital Input (active low) X X
C3-G ServiceBrake DigitalInput(activelow) X X
C3-H Ground PowerGround X X
C3-J MainBatteryPower(VBAT2) Power X X
C3-K RightDRL DigitalOutput X |
C3-L RightLowBeam DigitalOutput X X
C3-M Ignition DigitalInput(activehigh) X X
C3-N LeftFront/SideTurnLamp Digital Output X X
C3-P Taillight/LicensePlateLampsPass-through Pass-through X X
C3-R RightFront/SideTurnLamp DigitalOutput X X
C3-S J1587+Datalink (not available after Jan 2016) Datalink X X
M L K J H G
C4 Forward S R P N M L K J
C5 Air F E D C B A Chassis Harness H G F E D C B A

Management Unit
ForwardChassis Harness Pinouts atConnector C4
Connector C5Air Management Unit (AMU)Harness Pinouts Connector and Full Standard
Signal Name Signal Type
Connector and Full Standard Pin Numbers
Signal Name Signal Type
Pin Numbers C4-A ModuleWake-upSignal DigitalInput/Output X X
C5-A AMUAnalogInput0 DigitalInput(activelow),AnalogInput X | C4-B AddressIdenticationA AnalogInput X X
C5-B AMUAnalogInput1 DigitalInput(activelow),AnalogInput X | C4-C LeftParkLamp DigitalOutput X X
C5-C Ground SignalGround X | C4-D LeftMarkerLamp DigitalOutput X X

C5-F AMUAnalogInput2 DigitalInput(activelow),AnalogInput X | C4-E AddressIdenticationC AnalogInput X X


C4-F LeftDRL DigitalOutput X |
C5-G AMUAnalogInput3 DigitalInput(activelow),AnalogInput X |
C4-G J1939+ 500K Datalink Datalink X X
C5-H AMUSolenoid0 DigitalOutput X |
C4-H Ground(addressidenticationD) SignalGround X X
C5-J AMUSolenoid1 DigitalOutput X |
C4-J MainBatteryPower(VBAT3) Power X |
C5-L AMUSolenoid2 DigitalOutput X |
C4-K RightHighBeam DigitalOutput X X
C5-M AMUSolenoid3 DigitalOutput X | C4-L RightParkLamp DigitalOutput X X
C4-M RightMarkerLamp DigitalOutput X X
C4-N AddressIdenticationB AnalogInput X X
C4-P MainBatteryPower(VBAT1) Power X X
C4-R J1939- 500K Datalink Datalink X X
C4-S Ground PowerGround X X Rev - B

Page 13
Multiplexing System - Mod 160

The term "multiplexing" describes how the SmartPlex


Multiplexing System Backbone
electrical system works.
Multiplexing is defined as the process of sending multiple electronic
messages through the same signal path at the same time - in this case, Control Unit The J1939 Datalink
through the data link.
The system communicates using two primary forms of ABS TRANS ICU GTWY ENG
communication called data links: J1939-500K datalink (High speed)
and the J1939-250K datalink (low speed).
120 Ohm 120 Ohm
J1939-500K Terminating Terminating
Resistor Resistor
(White w/ yellow stripe J1939+ ; White w/ green stripe J1939- ; In a twisted pair )
• A high speed vehicle communications network, which permits devices to broadcast
requests as well as receive information from all other devices on the network.
Backbone Node
• Each message includes an identifier much like a CB channel setting that defines the
message priority, who sent it, and what data is contained within it. CHM BHM DIAG Branch
• A terminating resistor is installed at each end of the network to dampen feedback Circuit
signals.

J1939-250K (Yellow J1939+ ; Green J1939- ; In a twisted pair )


• This databus information is available through the use of a standard gateway (mod 835).
System Terminology
• This is the recommended interface databus for all aftermarket/TEM devices.
J1939 Backbone - The main J1939 datalink wiring that lies between the
two terminating resistors. It does not include the branch nodes to each ECU or to the
diagnostic connector.
* Minimum length between any 2 nodes = 10 cm
* Maximum branch length = 3 meter
* Maximum total network length = 40 meters
Node Branch Circuit - The section of J1939 datalink between the
backbone and each control unit that has J1939, and between the backbone
J1939-250K and the diagnostic connector.

Diagnostic Connector - a 9-pin diagnostic connector is used for troubleshooting


the electrical system. It can be found under the dash on the driver side, outboard of the
steering column.
M2 J1939-500K Nodes M2 J1939-250K Node Control Unit - connects to the J1939 datalink via a branch circuit (Node).
Option Node Status Option Node Status Option Node Status
Engine Standard Trans Optional Body Builder Standard NODE - A node is the connection point for a device or control unit.
Cluster Standard Allison Shifter Optional Telematics Optional See “System Tap Points” for more information on adding nodes to the backbone.
ABS Standard Qualcom Optional
BHM Standard Gateway - A gateway is a conversion device that translates information from
J1939-500K into J1939-250K signals.
CHM Standard
Gateway Standard
Rev - B

Page 14
Cab resistor
Resistor Receptor EOL resistor
Dash Tap Points Part FTL# 23-13303-902 located in
Deutsch # DTM04 - 2P - EP10 gateway module

Ignition Power, Ground and Dash Illumination


Tapping into dash illumination and ignition power and ground can be
System Tap Points
accomplished by using the center tap point connections located in the
center back wall of the dash.
The J1939-250K Datalink
Note:
* Ignition power source will be powered during engine cranking
* Ignition power source will not be powered when key is in accessory
position.
120 Ohm
Terminating
J1939-250K Connections Resistor
Driver CTR Pass Gateway
Module
Tying into the J1939-250K backbone is accomplished by tapping into the
system at any of the three dash splice packs (LH, RH, and Center of dash).
The cab terminating resistor is located in the dash on the driver side. It
should be close to the splice pack interface node. The second resistor is Backbone
integrated with the gateway.
J1939-250K Multiplexing System connections
J1939-250K connection
The correct datalink resistence measured at any device, or at the is used for TEM interfacing
diagnostic plug should be 60 ohms with the battery disconnected. or adding additional devices
such as telematics modules. Dash Tap point
IMPORTANT: 3 locations: Passenger side dash.
- It is essential that the terminating resistor remain connected Center of dash.
Driver side dash.
to the end of the J1939-250K backbone to dampen feedback signals.
Numerous J1939 problems can be attributed to terminating resistors
missing or being disconnected.
- If connections under dash become disconnected. Connections should Illumination
never be reconnected back together directly IE ABS with ABS as this creates an Circuit 29A
independent circuit in the system that is not connected to the backbone. Max load: 5amps

J1939-250K Connections for Body Builders


To connect easily to J1939-250K in the dash order the
following parts:
(2) Terminals FTL# 23-13213-142
(supplier: PAC12110843)

Component Module Locations Ignition


Circuit 81C
Component Module Number Max load: 5amps
General J1939 harness drawings, schematics, and installation drawings 160
Engine harness, installation drawings and wiring diagrams 283 and 286 Pin part number for harness connection
TERM-FEMALE,(18-16) PAC12110844 Ground
Transmission harness, installation drawings and wiring diagrams 34A, 34B and 343 Circuit GND
TERM-FEMALE,(14-12) PAC12110842
ABS harness and installation drawings 330, 332, and 333 Max load: 10amps

Gateway harness and installation drawings 860 and 835


General dash wiring (IGN/ILLUM)
Dash Tap Points
320 Rev - B

Page 15
J1939-250K Gateway Communications
J1939-250K Gateway
Standard: 835-003 - J1939 500KBPS to J1939 250KBPS gateway
Mod 160, 835
23-13151-012 GATEWAY
MUX_CTRL_D_ECU_CGW_2A MUX_CTRL_D_ECU_CGW_1A
• On OBD2016 and forward engines, manufacturers will no longer provide J1708/J1587 J1939 + #1603 (Y) 21 CAN_H J1939
data bus and the system will be supported using one single communication system J1939 - #1603 (DKG) 16 CAN_L J1939
data bus – J1939 .
508E # 2008 (BR-LTBL) 23 DIAGNOSTIC CAN_H
Third Party Connections 508G # 2008 (BR-W) 18 DIAGNOSTIC CAN_L
12
• Third party systems can be connected at any of the three factory provided splice packs (160-038). 23-13151-011
There is also the option to order the vehicle with just an old style 9-pin in the center of the dash MUX_CTRL_DASH_0_MDL_CGW_1A
via data code 160-039. GND # 1204 (BK) 0.8 7 GROUND

81C # 1102 (PK) 0.8 1 IGNITION PWR

J1939 Gateway 12
location

J1939-500K Messages to
J1939-250K Third Party
equipment

The J1939 Datalink

Three J1939-250K splice


pack for TEM interface. 120 Ohm Gateway
Terminating Module
Optional 250K 9pin in center. Resistor
Driver CTR Pass 60 Ohm
Terminating
Resistor
9 Pin
Diagnostics Plug
500K only

Backbone

Rev - B
Page 16
Low Current Smart Switches
Smart switches are low current switches that use signals to
communicate with the BHM to tell what function they effect and
what state they are in (on or off etc.). Low Current Smart Switches
There are two primary types of Smart Switch
1. A two position switch supplies an on or off signal to the BHM.
2. A three position switch allows for an up/down/off signal to the BHM.
Smart switches identify themselves by two voltage signals to the bulkhead module.
(Used in applications where more than one input is required.)
Each switch has a unique combination of resistors that control the voltage signal Low Current Easily identified by the
to the BHM allowing it to identify the switch.
Smart Switch Black backing on the
Each channel can talk independently to the Bulkhead module at the same time. switch
In order for a smart switch to work on the vehicle the BHM must be programmed
to hear it, this is done through the features screen using ServiceLink. 860-004 SMART SWITCH EXPANSION MODULE (SEM)
Accessing the features screen can be accomplished on-site at the body builder if
A Switch Expansion Module (SEM) is available for the vehicle when more than five smart
they are set up with ServiceLink.
switches are installed on the vehicle. Each adds up to 6 smart switches (beyond the standard
Three common faults can occur with Smart Switches 5 supported directly by BHM).
1. Extra Smart Switch fault - indicates that a smart switch has been installed that the vehicle is The function of the SEM is to; read all of the smart switch Id’s and positions; transmit the
not programmed to utilize. smart switch IDs and position data on the J1939 datalink; turn on the smart switch indicator
2. Duplicate Smart Switch fault - indicates that there are two or more identical smart switches lights when commanded to do so by the Bulkhead Module (BHM).
connected to either the BHM or SEM smart switch ports. To fix this error the duplicate smart
switches must be removed from the system.

10
3. Missing Smart Switch fault - indicates that a smart switch has been programmed but is not

1
2

3
installed. 10 1 2 3 4 12

4
12
9 5 6 8 11

Smart Switch Pinout for a Two Position Switch Pins


Pin Circuit Number Circuit Description
2 474B Switch Position Input
7 474C Switch Function ID 1 Input
8 474D Switch Function ID 2 Input
9 GND Ground
10 14E Indicator (+)
11 29A Backlighting (+)
12 474A Indicator ({)

Smart Switch Pinout for a Three Position Switch Pins


Pin Circuit Number Circuit Description
2 474B Switch Position Input
7 474C Switch Function ID 1 Input
8 474D Switch Function ID 2 Input
9 GND Ground
11 29A Backlighting (+)

Switch Expansion Module Low Current Smart Switch Socket


Rev - B

Page 17
High current Switch (Battery Hot) High Current Switches (Battery Hot)
- Optional battery hot power switches are factory-installed, switch controlled
power provisions that can be ordered for a SmartPlex vehicle.
Blunt cut power wires
- Optional switches can be ordered in various switch configurations as shown
from opt high current
below.
power switches located
- All optional high current switches mount on the dash, provide fuse protected in frame BOC.
battery power, and route to a customer access point ending in blunt cut wires.
- Optional switches are commonly used to provide battery-powered lighting, such High current switches can be easily identified
as dome, spot, or beacon lights. Other applications include using the optional by the white backing on the switch.
switch as a triggering mechanism to enable other features, such as hydraulic
lift operations or access panel locks.

Optional Power Switches:


Module 329 Options (Battery Hot):
Additional un-wired dash switches can be ordered for optional switches 5 through 8
329-007 ILLUMINATED ROCKER SWITCH WITH WIRE TO BACK OF CAB AND MARKER
LIGHT CIRCUIT TO JUNCTION BLOCK ON FRAME BACK OF CAB These switches will come mounted on the dash to the right of the steering column.
329-010 (2) EXTRA SWITCHES IN DASH WITH INDICATOR LAMP AND WIRE TO CHASSIS
AT BACK OF CAB/SLEEPER Each switch is equipped with two LED lights; one LED provides switch illumination
329-012 (4) EXTRA SWITCHES IN DASH WITH INDICATOR LAMP AND WIRE TO CHASSIS and on position indication. Constant fused power up to 10A is supplied to each
AT BACK OF CAB/SLEEPER switch from the Power Distribution Module (PDM).
329-015 (1) ILLUMINATED ROCKER SWITCH WITH WIRE TO CHASSIS AT BACK OF CAB
329-017 (3) EXTRA SWITCHES IN DASH WITH INDICATOR LAMP AND WIRE TO CHASSIS Extra dash switches are not connected and require a customer supplied mating plug and
AT BACK OF CAB/SLEEPER pins to connect the switches to additional wiring. (See plug part numbers on this page)
329-055 (4) EXTRA SWITCHES IN DASH WITH INDICATOR LAMP AND WIRE TO CHASSIS
BACK OF CAB/SLEEPER AND ONE EXTRA SWITCH IN DASH WITH NO WIRING Connecting a Switch Using a Chassis Junction Block:
329-077 (8) EXTRA SWITCHES IN DASH; (4) WITH INDICATOR LAMPS AND WIRES TO CHASSIS
AT BACK OF CAB, (4) WIRED BY BODY BUILDER Ref service bulletin, Power Switches and Connections # SB-54.39 from your dealer.
329-082 (7) EXTRA SWITCHES IN DASH; (4) WITH INDICATOR LAMPS AND WIRES TO CHASSIS Switches will be pre-wired to a Junction block attached to the frame rail
AT BACK OF CAB, (3) WIRED BY BODY BUILDER
near the Chassis Module (CHM). The red wire in the junction block receives power
329-083 (6) EXTRA SWITCHES IN DASH; (4) WITH INDICATOR LAMPS AND WIRES TO CHASSIS
AT BACK OF CAB, (2) WIRED BY BODY BUILDER
from the output circuit of the optional switch.
329-1AA ONE ON/OFF/ON ROCKER SWITCH IN THE DASH WITHOUT INDICATOR LIGHT, IMPORTANT: The power distribution module (PDM) fuse supplying power to the optional switch is
WIRE ROUTED TO CHASSIS AT BACK OF CAB NO LABEL
rated for 10 amps and this load should not be exceeded by the combined current load of the circuit.
329-1AB TWO ON/OFF/ON ROCKER SWITCH IN THE DASH WITHOUT INDICATOR LIGHT,
WIRE ROUTED TO CHASSIS AT BACK OF CAB NO LABELS Ordered using
Option 329-007

Optional-switch Current Capacity


No.of PDM Fuse F25 Switch Output PDM Fuse F26 Switch Output
Switches Rating Switch Protected Current Capacity Rating Switch Protected Current Capacity
1 10A Switch 1 10A | | |
2 0A
2 Shared by switch 1 and 2 10A | | |
3 20A Shared by switch 1 and 2 10A 10A Used by switch 3 10A
4 20A Shared by switch 1 and 2 10A 20A Shared by switch 3 and 4 10A

Junction Block Rev - B


Page 18
High Current Switch (BH) Schematics

Four-switch Conguration Wiring Diagram One-switch Conguration Wiring Diagram With Junction Block and market light feed
L 29A BR 10 ILLUM
Hot at all times Hot at all times Illumination output
(Battery B+) (Battery B+)
Illumination OFF
PDM Hot at Fuse Splice Pack SP1
Fuse Fuse Located
F25 F26 Under all times F25 T 399
20A
C 399 T 2B
20A the hood (Battery B+)
10A
C

A
PDM located ON

Illumination
Illumination 399A T 3
under the hood
T

399B T
Output Splice Pack SP1
399

29A BR L
C GND BK 8 ON IND

Switch Dash Ground Dash-mounted


Battery Splice Pack SP9 Optional Switch

399B

399B
A T 399A Access T
10 BR 29A

10 BR 29A

10 BR 29A

10 BR 29A
399

399

Optional B 46F BR M
Marker lights output
Switch C BR 46B Marker BR C4
2B T

2B T

2B T

2B T
Marker D
Lights Light Chassis Module
E Access
CUST1
Customer Access
Junction Block
ON OFF ON OFF OFF OFF ON Ring Terminal Connections

One-switch Conguration Wiring Diagram Without Junction Block


IND ON ILLUM IND ON ILLUM ILLUM ON IND ILLUM ON IND
L 29A BR 10 ILLUM
Illumination output
Dash- Dash- Dash- Dash-
3

T 3

3
8

8
Mounted Mounted Mounted Mounted Illumination
Optional Hot at OFF
GND BK

GND BK

GND BK

GND BK
T

Optional Optional Fuse Splice Pack SP1


399E T

Optional
Switch 1 Switch 2 Switch 3 Switch 4 399G T all times F25 C T 399 399 T 2B
399C
399A

(Battery B+)
10A
PDM located ON
399A T 3
under the hood
C GND BK

OPT SW 1 OPT SW 2 OPT SW 3 OPT SW 4 Optional switch


10A MAX 10A MAX 10A MAX 10A MAX Output C GND BK 8 ON IND
T 399A
14 GA circuit

OPT SW 1
10A MAX
Heat-shrink Dash Ground
Protected Dash-mounted
Splice Pack SP9 Optional Switch
Optional switch outputs Dash Ground
ON

14 GA circuits Splice Pack SP9


Heat shrink protected

Rev - B

Page 19
High Current Switches
High current Switch
Optional ignition interlocked or battery powered switches are switch
controlled power provisions that are factory installed.
Optional switches can be ordered in a (6)-, (8)-, or (10)-switch configurations.
High current switches can be easily identified
All optional high current switches mount on the dash, provide fuse protected
by the white backing on the switch.
and ignition interlocked power, and route to a customer access point ending
in an in cab junction box.
The junction box will be located under the passenger seat for fix base seat
configurations.
The junction box will be shipped loose for customer install for all non-fixed
passenger seats.
Optional switches are commonly used to provide battery-powered lighting, as
dome, spot, or beacon lights. Other applications include using the optional
switch as a triggering mechanism to enable other features, such as hydraulic
lift operations or access panel locks.

Module 329 Options (Ignition Interlocked)


329-090 (10) IGNITION CONTROLLED EXTRA SWITCHES WITH INDICATOR LIGHTS WIRED TO POWER DISTRIBUTION
BOX WITH RELAYS PROVIDING 20 AMPS PER CIRCUIT TO JUNCTION BLOCK AND ONE CIRCUIT AT 30 AMPS
329-091 (6) IGNITION CONTROLLED EXTRA SWITCHES WITH INDICATOR LIGHTS WIRED TO POWER DISTRIBUTION
BOX WITH RELAYS PROVIDING 20 AMPS PER CIRCUIT TO JUNCTION BLOCK AND ONE CIRCUIT AT 30 AMPS
329-092 (8) IGNITION CONTROLLED EXTRA SWITCHES WITH INDICATOR LIGHTS WIRED TO POWER DISTRIBUTION
BOX WITH RELAYS PROVIDING 20 AMPS PER CIRCUIT TO JUNCTION BLOCK AND ONE CIRCUIT AT 30 AMPS
Additional dash switches
see page 22 for optional
switch labeling

Optional-Switch Current Capacity


No.of Auxiliary PNDB Power Feed
Switches Rating Switch Protection
6 All 20A All Switches independently fused
8 All 20A All Switches independently fused
Secondary PNDB Power
10 All 20A All Switches independently fused Net Distribution Box
Optional SW 1 is fused at 30A in all configurations

Note: For Non fixed passenger seat solutions the PNDB


will be shipped loose in cab for customer install Rev - B

Page 20
Optional Switch (mod 329)
Fuse and Relay PDM

Battery Power

High Current Schematic (Ignition Interlocked)


Optional Switch 1

Optional Switch 2

Optional Switch 3

Optional Switch 4

Optional Switch 5
Ignition
Power
Optional Switch 6

Optional Switch 7

Optional Switch 8

Optional Switch 9

Optional Switch 10

Ground

Optional Switch Junction Box

Rev - B

Page 21
Chassis Switches Heater
Switches
A06-30769-081 On
A06-30769-002 On
Pre labeled High Current Switch Options:
High Current Switch Label Options (Mom)
Off Off
Backup Alarm None
Mirror Heat None
Mod 329 optional switch packages can be customized with the following A06-30769-110 On A06-30769-021 On
predefined labels by adding a line note to the sales order. Off Off
Trailer Latch None Fuel Heater None
Step 1 A06-30769-109 On A06-30769-018 On
Select the 329-XXX option to drive the number of extra switches you require Chassis
Off Off
Lamps and Lights Tailgate Latch None Bunk Heater None
Step 2
Have the dealer salesmen add the part numbers for the spare switches from A06-30769-158 On A06-30769-025 On A06-30769-064 On
the choices on this page that you would like pre installed. None Off None
PLOW 2
Plow 2 Lamp Off Trailer Aux None Exhaust Brake Off
The addition of the line note will drive a demand and the Option and Blank A06-30769-157 On A06-30769-077
On
Switches None
(Mom) Drivetrain
factory will install the corresponding switch displays in lieu Off
of standard OPT switches in the truck.
T GATE
LATCH Tail Gate Latch Off Trailer Auxiliary None Switches
On
A06-30769-076 On
(Mom) A06-30769-155 A06-30769-116 On
Option Off None
Roof Light
Note: Off
None CAB
Cab Strobe Off Switches Center Bal None
Switches will come pre-wired as per the current optional A06-30769-014 On
STRB

switch data codes and will not be pre-wired to the locations Off A06-30769-092 On A06-30769-075 On A06-30769-115 On
defined by the switch label. Optional None Off Off Off
Fog Lamp None Alternate Flasher None Pump None
A06-30769-117 On
Off A06-30769-091 On A06-30769-024 On A06-30769-062 On
Blank None Off Off None
Plow Lamp None Advertizing Light None Axle Shift Off
A06-30769-114 On A06-30769-029 On A06-30769-082 On
Optional Switch Connector Off Off Off
Connector Circuit Salt Light None Beacon Light None Axle Lift None
Signal Name Signal Type Circuit Number
Pin Color On
A06-30769-108 On A06-30769-013 A06-30769-101 On
Terminal Pin 23-13213-400 (20-18) (Mom)
8 6 5B 5A 4 7 FTL Switch Socket PN Terminal Pin 23-13213-401 (16-14) Off Off None
Socket 06-42557-000 Sander Lamp Dome Light Shift Tower Off
Terminal Pin 23-13213-402 (12-10) None None

Vndr Switch Socket PN


Terminal Pin PAC12015869 (20-18)
A06-30769-111 On A06-30769-034 On A06-30769-098 On
Terminal Pin PAC12015870 (16-14)
10 3 2B 2A 1 9 Socket PAC15393805 Terminal Pin PAC12015830 (12-10) Off Off Off
Spot Lamp None Dome Light None Trans Retarder None
1 | | | |
A06-30769-023 On A06-30769-113 On A06-30769-096 On
399 for optional switches 1 and 2. 399B for optional
2B FusedBatteryPower Input T
switches 3 and 4. Off Off Off
Spot Lamp None Rear Strobe None PTO None
399A for optional switch 1. 399C for optional switch 2.
3 OptionalSwitchOutput Output T
399E for optional switch 3. 399G for optional switch 4. A06-30769-006 On A06-30769-112 On A06-30769-031 On
4 | | | | Off Off Off
Rear Fog Lamp Front Strobe Engine Brake
5B | | | |
None None None
6 | | | | A06-30769-003 On A06-30769-107 On A06-30769-089 On
Off Off Off
7 | | | | Utility Lamp Sander Beacon HDWY Control
None None None
8 Ground Ground BK GND On
A06-30769-004 On A06-30769-005 On A06-30769-149
9 | | | | (Mom)
Off Off Off
Road Lamp Foot well Light ENGINE
Engine Start
10 IlluminationFeed Input BR 29A None None START None

Rev - B

Page 22
Body Builder Lighting Interfaces
Vehicle Interface Lighting

353-065 VEHICLE INTERFACE WRG CONN W/ BLUNT CUTS, AT BACK OF CAB


353-066 VEHICLE INTERFACE WRG CONN W/ BLUNT CUTS, AT END OF FRAME
353-067 VEHICLE INTERFACE WRG CONN W/ PDM AND BLUNT CUTS, AT BACK OF CAB
353-068 VEHICLE INTERFACE WRG CONN W/ PDM AND BLUNT CUTS, AT END OF FRAME
353-038 MARKER LAMP CONNECTION FOR BODY BUILDERS LOCATED BACK OF CAB

Lighting Interface Harness Mod 353

1 8 Mating connector supplied with Chassis


Apex connector part num FCI54201415
FTL Part # 23-13153-010
TERM-MALE,APEX2.8
7 14 FTL Part # 23-13211-010 FCI54001801, -011 FCI54001401
-012 FCI54001001, -013 FCI54001818, -014 FCI54001441
Connector Signal Name Signal Type Circuit Circuit Marker Lamp Only Low Current High Current
Pin Color Number (353-038) (353-022 or 353-023) (353-026 or 353-027)
+12V via PDM Fuse 7
1 Tail Lamp BR 23 - 2A 20 A
With Relay 1 Active
+12V via PDM Fuse 12
2 Back Up Lamp DKBL 120B - 7.5 A 20 A Body Builder Interface Connector
With Relay 2 Active
+12V via PDM Fuse 1 (See page 24 for schematics)
3 Right Turn Lamp DKG 38R - 7.5 A 20 A
With Relay 3 Active

4 Right Stop Lamp


+12V via PDM Fuse 6
R-W 36P - 6.7 A 20 A
Note: Connector should have an orange ribbon tape
With Relay 4 Active within 2” for easy identification
+12V via PDM Fuse 2
5 Left Stop Lamp R-W 36N - 6.7 A 20 A
With Relay 5 Active
+12V via PDM Fuse 5
6 Left Turn Lamp Y 38L - 7.5 A 20 A
With Relay 6 Active
+12V via PDM Fuse 3
7 Marker Lamp BR 46B 20 A 20 A 20 A
With Relay 7 Active
+12V via PDM Fuse 4
8 Ignition Power PK 52F - - 20 A
With Relay 8 Active
9 Battery Power +12V via PDM Fuse 11 R 14U - - 20 A
10 Battery Power +12V via PDM Fuse 8 R 14U - - 20 A
11 Ground Ground BK GND - - GND
12 Ground Ground BK GND - - GND
13 Ground Ground BK GND - - GND
14 Ground Ground BK GND - - GND

Rev - B

Page 23
Trailer and Body Builder Lighting Module
For all 2010 and later configurations specified with the trailer and body
Body Builder PDM
builder options, Freightliner provides an in-cab lighting module that provides
high current capacity circuits that are protected from the elements and east to
access for maintenance and assembly people/

Trailer PDM - mod 335


TRLR_FLR_O_PDM_1A

Body Builder Power


Net Distribution Box
Floor Mount Configuration BB-PNDB
Back wall Configuration REF MOD 33P
for Extend Cab Units
for Day Cab Units

Body Builder PDM


VEH_INTFC_FLR_PDM_1A
F1
FBB_1 F2
F3 Body Builder PDM - mod 353
F7
VEH_INTFC_FLR_PDM_1A
F8
R8 R6 R4 R2
F9

F10
Cab Floor Connector Pinout
F11

F12 R7 R5 R3 R1 UCAB_H_FLR_2A
Under-Cab Harness connecting to Cab Floor Harness
Pin Wire size Usage Description Circuit #
F4 A 16-18 Marker Lamp Relay R4_87 46A
FBB_2 F5
B 16-18 Left Turn Relay R6_87 38L
F6
C 16-18 Stop Lamp Relay R5_87 36B
Fuse Fuse Relay Relay
D 16-18 Right Turn Relay R7_87 38R
Location Rating Function Location Rating Function
E 16-18 Tail Lamp Relay R3_87 23
F1 20A Right Turn Lamp R1 Micro Tail Lamp
F 16-18 Trailer Power R2_87 45
F2 20A Left Stop Lamp R2 Micro Backup Lamp
G 16-18 20 amp battery Fuses 14U
F3 20A Marker Lamp R3 Micro Right Turn Lamp
H 16-18 20 amp battery Fuses 14U
F4 20A Ignition Power R4 Micro Right Stop Lamp
F5 20A Left Turn Lamp R5 Micro Left Stop Lamp J 16-18 Left Tail Lamp 23
F6 20A Right Stop Lamp R6 Micro Left Turn Lamp K 16-18 Backup Lamp 120B
F7 20A Tail Lamp R7 Micro Marker Lamp L 16-18 Right Turn Lamp 38R
F8 20A Battery Power R8 Micro Ignition Power M 16-18 Right Stop Lamp 36P
F9 --- Blocked N 16-18 Left Stop Lamp 36N
F10 --- Spare P 16-18 Left Turn Lamp 38L
F11 20A Battery Power R 16-18 Marker Lamp 46B
F12 20A Backup Lamp S 16-18 Ignition Power 52F

Rev - B
Page 24
High Current Interface
1 8 Mating connector supplied with Chassis
Apex Connector part Num FCI54201415
FTL Part # 23-13153-010 Body Builder PDM Left Tail
FTL Terminal Part # 23-13211-010, -011, - 012
Lamp
7 14 Ground Relay #1

Ground

Back Up
Lamp
Relay #2

Interface
Connector
Right Turn
Lamp
Relay #3
Ground

Right Stop
Chassis Lamp
Module Relay #4

Left Stop
In Line Lamp
Connector Relay #5
To Tail Ground
Harness

353-026 and 353-027 Schematic Left Turn


Lamp
Relay #6

Marker
Lamp
Low Current Interface Relay #7
Ground
In Line
Connector
To Tail
Harness Ignition
Power
Chassis Relay #8
Module Interface
Connector
Battery Power
Fuses

Ignition Power
353-022 and 353-023 Schematic
Rev - B

Page 25
Trailer and Body Builder Lighting Module
For all 2010 and later configurations specified with the trailer and body
builder options, Freightliner provides an in-cab trailer control module that Trailer PDM
provides high current capacity circuits that are protected from
the elements and easy to access for maintenance and assembly
people.
Reference modules: 287, 87M, 296, 308

Trailer Floor PDM


TRLR_FLR_O_PDM_1A

Auxiliary Power
Back wall Configuration Net Distribution Box
Floor Mount Configuration for Day Cab Units BB-PNDB
REF MOD 33P
for Extend Cab Units
Trailer Floor PDM
(TRLR_FLR_O_PDM_1A)
F7_2
FBB_1 F8_2
F9_2
F1_1

F2_1
R7 R6 R4 R2
F3_1

F4_1

F5_1 Cab Floor Connector Pinout UCAB_H_FLR_3A


Under-Cab Harness connecting to Cab Floor Harness
F6_1 R5 R3 R1 Pin Wire size Usage Description Circuit #
A 16-18 Left Tail Lamp R1_1 23A
B 12-14 ---
F10_2
FBB_2 F11_2 C 16-18 Back up Lamp R2_1 120C
D 12-14 PLC Filter Mod 296 376E
E 12-14 PLC Filter Mod 296 376F2
F12_2
F 16-18 Left Stop Lamp R5_1 36U
Fuse Fuse Relay Relay G 12-14 ---
Location Rating Function Location Rating Function H 16-18 Tail Lamp Relay R3_86 23A
J 16-18 Trailer Power Relay R2_85 52C
F1 30A Supplemental Trailer R1 Mini Supplemental Trailer
K 16-18 Trailer Marker Relay R7_1 46T
F2 20A Tail Lamp R2 Mini Trailer Power
L 16-18 Trailer Right Turn R3_1 38RT
F3 20A Stop Lamp R3 Mini Tail Lamp
M 16-18 Trailer Left Turn R6_1 38LT
F4 20A Right Turn Lamp R4 Mini Marker Lamp N 16-18 Stop Lamp R5_86 36
F5 20A Left Turn Lamp R5 Mini Stop Lamp P 16-18 Right Stop Lamp R4_1 36V
F6 20A Marker Lamp R6 Micro Left Turn Lamp R 16-18 Aux PNDB Disconnect Off Signal 425J
F7 --- Spare R7 Micro Right Turn Lamp S 16-18 Aux PNDB Disconnect LED Indicator 425H
F8 --- Spare T 16-18 Aux PNDB Disconnect Return Signal 425K
F9 --- Blocked U 16-18 ---
F10 --- Spare V 16-18 ---
W 16-18 ---
F11 --- Spare
X 16-18 ---
F12 30A Trailer Power
Rev - B

Page 26
Mod 296/297 Separate Stop/Turn
297-001 SAE J560 7-WAY PRIMARY TRAILER CABLE RECEPTACLE
MOUNTED END OF FRAME
297-005 SAE J560 7-WAY PRIMARY TRAILER CABLE RECEPTACLE
MOUNTED ON CHASSIS BACK OF CAB/SLEEPER
297-008 SAE J560 7-WAY PRIMARY TRAILER CABLE RECEPTACLE
Trailer Electrical System (Seperate)
BRACKET MOUNTED LH DECK BACK OF CAB
296-010 PRIMARY CONNECTOR/RECEPTACLE WIRED FOR SEPERATE
STOP/TURN, CENTER PIN POWERED THROUGH IGNITION
296-013 PRIMARY CONNECTOR/RECEPTACLE WIRED FOR SEPERATE
STOP/TURN, CENTER PIN WIRED TO BACKUP LIGHT CIRCUIT
296-026 PRIMARY CONNECTOR/RECEPTACLE WIRED FOR SEPERATE
STOP/TURN, CENTER PIN POWERED THROUGH IGNITION
WITH STOP SIGNAL PRE-WIRE PACKAGE

1
6 2
7
5 3 Trailer
4 Receptacle

ELECTRIC TRAILER BRAKE PRE-WIRE INCLUDED WITH 296-026

ELECTRIC TRAILER PRE-WIRE BLUNT CUTS UNDER


STEERING COLUMN AND END OF FRAME
Rev - B
Page 27
Mod 296/297 Combination Stop/Turn
296-025 PRIMARY CONNECTOR/RECEPTACLE WIRED
FOR COMBINATION STOP/TURN, CENTER PIN POWERED
THROUGH IGNITION
296-027 PRIMARY CONNECTOR/RECEPTACLE WIRED FOR COMBO Trailer Electrical System (Combination)
STOP/TURN, CENTER PIN POWERED THROUGH IGNITION
WITH STOP SIGNAL PRE-WIRE PACKAGE
297-001 SAE J560 7-WAY PRIMARY TRAILER CABLE RECEPTACLE
MOUNTED END OF FRAME
297-005 SAE J560 7-WAY PRIMARY TRAILER CABLE RECEPTACLE
MOUNTED ON CHASSIS BACK OF CAB/SLEEPER
297-008 SAE J560 7-WAY PRIMARY TRAILER CABLE RECEPTACLE Power from
BRACKET MOUNTED LH DECK BACK OF CAB

1
6 2
7
5 3 Trailer
4 Receptacle

ELECTRIC TRAILER BRAKE PRE-WIRE INCLUDED WITH 296-027

ELECTRIC TRAILER PRE-WIRE BLUNT CUTS UNDER


STEERING COLUMN AND END OF FRAME Rev - B
Page 28
Body Builder Floor Plug Interface
Trailer and Bodybuilder Floor Connections
Connections to the trailer and body builder unit are
achieved using a 76 Pin plug located on the cab floor
rear of the driver seat.
Refer to the diagram and chart on this page to determine
what pins are used for connections and what pins are
available for additional body builder connections. UCAB_H_FLR_1A
Pin Wire size Usage Description Circuit # Pin Pin size mm Usage Description Load Limit
1 12-14 -- 39 16-18 --
2 12-14 -- 40 16-18 --
3 12-14 -- 41 16-18 --
4 12-14 -- 42 16-18 --
12 1
26 13 5 12-14 -- 43 16-18 --
6 12-14 -- 44 16-18 --
38 27
CONNECTOR Plug Number 7 12-14 -- 45 16-18 --
DTNA PART: 23-13153-063 8 12-14 -- 46 16-18 --
SUPPLIER PART: AFLR 63694 001 9 12-14 -- 47 16-18 Engine Control Dash 483Z
50 10 12-14 -- 48 16-18 Remote VSG Select 439U
39 TERMINAL Part Number 11 12-14 -- 49 16-18 Cruise Control On/Off Enable 492U
64
51 DTNA Part: 12 12-14 -- 50 16-18 Cruise Control Set/Coast 483A
76 65 Male 1.6, 20-14 AWG --
13 12-14 51 12-14 --
23-13211-410, 411, 530
14 16-18 -- 52 16-18 Cruise Control Resume/Control 483B
Male 2.8, 14-8 AWG 15 16-18 Starter, Engine 15 53 16-18 Limiter 8 439V1
23-13211-430, 431, 432 16 16-18 Ground GND 54 16-18 Limiter 1 439V2
17 16-18 -- 55 16-18 Tachometer 483E
18 16-18 -- 56 16-18 Throttle Inhibit 492Z
19 16-18 -- 57 16-18 Remote Accelerator Select 483N
20 16-18 -- 58 16-18 Variable Speed Governor 483C
21 16-18 -- 59 16-18 +5V Sensor Supply 483D
22 16-18 Disconnect Off Signal 425H 60 16-18 Engine Control Dash 492Y
23 16-18 Disconnect LED Indicator 425K 61 16-18 Dash Power and Ignition 439A
24 16-18 Disconnect Return Signal 425J 62 16-18 CAV 15 -NC- (Reserved) CAV15
25 16-18 Disconnect GND GNDE 63 16-18 CAV 16 -NC- (Reserved) CAV16
26 12-14 -- 64 12-14 --
27 16-18 -- 65 12-14 --
28 16-18 -- 66 12-14 --
29 16-18 -- 67 12-14 --
30 16-18 -- 68 12-14 --
31 16-18 -- 69 12-14 --
32 16-18 -- 70 12-14 --
33 16-18 -- 71 12-14 --
34 16-18 -- 72 12-14 --
35 16-18 -- 73 12-14 --
36 16-18 -- 74 12-14 --
37 16-18 -- 75 12-14 --
38 16-18 -- 76 12-14 --

Rev - B
Page 29
Tail Lights and EOF Connections
Tail Lights
Body builders utilizing factory lights and needing additional lighting
interfacing should use the 353 data codes for body builder interfaces.
Body builders wishing to supply their own taillights can order
the “Wiring Only” option shown below.
Many connectors come with mating connectors included and
require only the terminals to be supplied by the body builder.

Data Description LED Incan-descent Wiring Only Additional Combo Separate Grommet Flange Lamp Configuration Truck Configurations
Harness Length Stop/Turn Stop/Turn Mounted Mounted
Code
(ft)

294-001 INTEGRAL STOP/TAIL/BACKUP LIGHTS - X - - X - - - Straight Truck Configurations

294-002 TRUCK-LITE 40 STOP/TAIL WITH SEPARATE BACKUP LIGHTS GROMMET MOUNTED - X - - X - X -

294-017 INTEGRAL STOP/TAIL/BACKUP LIGHTS WITH 7 FEET ADDITIONAL WIRE AT CHASSIS END OF FRAME - X - 7 X - - -

294-021 TRUCK-LITE 3 CHAMBER MODULES WITH 45 SERIES SEALED BEAM LAMPS - X - - - X - -

WIRING ONLY WITH SEPARATE STOP AND TURN LIGHT CIRCUITS TO END OF FRAME FOR CUSTOMER FURNISHED
294-027 - - X - - X - -
LAMPS

294-037 INTEGRAL STOP/TAIL/BACKUP LIGHTS WITH 36 INCHES ADDITIONAL WIRE AT CHASSIS END OF FRAME - X - 3 X - - -

294-042 FREIGHTLINER LED FLANGE MOUNTED STOP/TAIL/TURN LIGHTS WITH SEPARATE INCANDESCENT BACKUP LIGHTS X - - - X - - X

OMIT STOP/TAIL/BACKUP LIGHTS AND PROVIDE WIRING WITH SEPARATE STOP/TURN WIRES TO 4 FEET BEYOND END
294-046 - - X 4 - X - -
OF FRAME

294-050 FREIGHTLINER LED STOP/TAIL/TURN/BACKUP/LICENSE LIGHTS BY TRUCK-LITE X - - - X - - X

294-081 GROTE#53302 10-DIODE LED STOP/TAIL/TURN LIGHTS MOUNTED ON REAR CROSSMEMBER X - - - X - - X

OMIT STOP/TAIL/BACKUP LIGHTS AND PROVIDE WIRING FOR COMBINED STOP/TURN LIGHTS TO FOUR FEET BEYOND
294-090
END OF FRAME
- - X 4 X - - -

FREIGHTLINER LED FLANGE MOUNTED STOP/TAIL/TURN LIGHTS WITH SEPARATE BACKUP LIGHTS AND ADDITIONAL 7
294-091 X - - 7 X - - X
FEET WIRING END OF FRAME

OMIT STOP/TAIL/BACKUP LIGHTS AND PROVIDE WIRING WITH SEPARATE STOP/TAIL WIRES TO 7 FEET BEYOND END OF
294-094
FRAME
- - X 7 - X - -

WIRING HARNESS ONLY TO END OF FRAME FOR STOP/TAIL/TURN WITH BRAKE LIGHT ACTIVATION WITH PARK BRAKE
294-095
APPLIED WITH IGNITION
- - X - X - - -

Tractor Configurations

Rev - B
Page 30
Rear Light Connector (separate stop/turn signal)
G A
Mating connector supplied with Chassis
Packard Connector PAC 12110751
G F E D C BA D E
D E Terminal supplied by Body Builder
P N M L K J H C A F
C A F Packard Terminal PAC 15304719
P H Tail Lights Schematics B G B G Freightliner Seal Part# 23-12497-282
Pinouts at CHMConnector C1
Connector Signal Circuit Circuit
Connector
Pin
Signal Name Signal Type
Circuit
Color
Circuit
Number
Current
Capacity
Modules: 301, 311, 35H, 877, 30J Pin
Signal Name Type Color Number
C1-A LeftBackupLight(combinationstop/turnsignal) DigitalOutput DKBL 120B 7.45A* A BackupLight Output DKBL 120B
C1-A LeftBackupLight(separatestop/turnsignal) DigitalOutput DKBL 120B 7.45A* Output BR 23
RearLighting Connection (separate stop/turn signal) B TaillightsandLicenseLight
C1-B | | T OPTA | Output
C RightTurnSignalLight DKG 38R
C1-C | | T OPTB |
1939+ D RightStopLight Output R-W 39R
C1-D LeftTaillightPass-through Pass-through BR 23 1.0A† 1939+ G Y 1939+ Y B 1939+
Data E Ground Ground BK GND
C1-E RightTaillightPass-through Pass-through BR 23A 1.0A† Lines
1939- R DKG 1939- 1939- DKG J 1939-
C1-F LicensePlateLight DigitalOutput BR 23C 1.0A† B2 F LeftTurnSignalLight Output Y 38L
C1-G LeftRearTurnSignalLight(separatestop/turnsignal) DigitalOutput Y 38L 7.45A‡ G LeftStopLight Output R-W 39L
P BR 23 23 BR K Tail/license
C1-H BackupAlarm DigitalOutput DKBL 120B 7.45A* C3 B1 Lights
C1-J RightBackupLight DigitalOutput DKBL 120B 7.45A* Bulkhead Module Mating connector supplied by Body Builder
Packard Connector 12186400
C1-K | | T OPTC | Backup A DKBL 120B A
E D C BA
Terminal supplied by Body Builder
C1-L RightStopLight(combinationstop/turnsignal) DigitalOutput R-W 39R 7.45A Tail/license D BR 23 B Packard Terminal 12129497
C1-L RightStopLight(separatestop/turnsignal) DigitalOutput R-W 39R 7.45A Lights E A Freightliner Part# 23-13213-131
C1-M | | T OPTD | P DKG 38R C
Right turn Rear Light Connector (combination stop/turn signal)
C1-N LeftStop/TurnSignalLight(combinationstop/turnsignal) DigitalOutput Y 39L 7.45A
L R-W 39R D
C1-N LeftStopLight(separatestop/turnsignal) DigitalOutput R-W 39L 7.45A Right stop Connector Signal Circuit Circuit
Taillight GND Pin Signal Name Type Color Number
C1-P RightRearTurnSignalLight(separatestop/turnsignal) DigitalOutput DKG 38R 7.45A§ E BK
* Pins C1-A, C1-H, and C1-J are fed from the same CHM circuit board trace. The max combined current cap for all three pins is 7.45A. Ground A BackupLight Output DKBL 120B
† Pins C1-D, C1-E, and C1-F are fed from the same CHM circuit board trace. The max combined current cap for all three pins is 1A. Left turn G Y 38L F
TaillightsandLicenseLight Output BR 23
‡ Pins C1-G, C2-H, and C3-N are fed by the same CHM circuit board trace. The max combined current cap for all three pins is 7.45A. B
§ Pins C1-P, C2-E, and C3-R are fed by the same CHM circuit board trace. The max combined current cap for all three pins is 7.45A.
Left stop N R-W 39L G C LeftStop/TurnSignalLight Output R-W 39L
C1 Aft Harness Tail Harness
Lighting Outputs For Integrated RearLights Chassis Module D RightStop/TurnSignalLight Output R-W 39R
(Combination stop/turn signal) E Ground Ground BK GND

Lighting Outputs For Individual RearLights


(Combination stop/turn signal)
39R LTG C R-W R 3 Stop/Turn
1 W
Tail/license K BR 23 DKBL DKBL A
K BR 23 23 BR B BR BK 2 Park With dual backup lights Right Backup Light
Tail/license lights Lights B1
B1
120B DKBL A DKBL R 2 1 W DKBL A
DKBL
Backup
GND BK E BK
With DKBL R 2 1 W
Bulkhead Module Bulkhead Module Center
Right Taillight Assembly Backup light Backup Light

R-W R 3
GND BK E BK All Plugs viewed from Front 1 W BK
120B DKBL A DKBL BR BK 2
23 BR B BR
P BR 23 39R LTG C R-W P BR 23 Right Stop/Turn/Park Light
C3 Tail Harness C3

Right L R-W 39R D R-W


BK 2 1 W
Stop/turn
A DKBL 120B A DKBL R 2 1 W
Backup License Light
Backup
Backup A DKBL 120B A DKBL120B
Tail/license D BR 23 B BR BK 2 1 W
Lights License Right L R-W 39R D R-W 39R
BK 2 Park Stop/turn Left Stop/Turn/Park Light
1 W Tail/license D BR 23 B BR 23 BK 2
Left stop/turn N R-W 39L C R-W R 3 Stop/Turn Lights 1 W
C1 Left stop/turn N R-W 39L C R-W 39L R-W R 3
Chassis Module GND BK E BK Left Taillight Assembly C1
Taillight Aft Harness Chassis Module GND BK E BK GND
Ground Taillight Aft Harness Tail Harness
Ground

Rev - B
Page 31
Transmission Interface Connector
Transmission Interface Connector
Depending on the transmission that is installed in the vehicle,
the transmission interface harness provides the VIW Transmission Interface Connector Pinout Assignments on M2 Vehicles
connection for the current generation of 1000/2000 Pin Freightliner
Allison Allison Transmission Function †

Transmissio n®
series or 3000/4000 series electronic controls. No. Circuit No.
Circuit No. 1000/2000 Series 3000/4000 Series
1 232E 163 Ignition Signal Ignition Signal
The transmission interface harness provides most of the 2 497C7 (O‡) 150 PTO Enable PTO Enable
optional I/O circuits and speedometer signal,in a Secondary Mode Indicator
3 497C8 (O) 113 – Range Indicator
conveniently located connector. Engine Overspeed Indicator
4 497Y 103 Digital Ground Digital Ground
Connectors can be ordered in three locations using the 5 497K (O) 125 Vehicle Speed Sensor Vehicle Speed Sensor
options shown below. 6 497C4 (O) 105 Output Speed Indicator A Output Speed Indicator A
Neutral Indicator for PTO Neutral Indicator for PTO
7 497C3 (O) 145
Two-Speed Axle Enable Two-Speed Axle Enable
There should be a green ribbon tape at the connector for easy Direction Change Enable
§
locating and identification. 8 497D3 (I ) 143 PTO Enable PTO Enable
Reverse Enable
Transmission Engine Overspeed Indicator
This reference guide does not illustrate electrical device interface (Grey Plug) 9 497C1 (O) 130 – PTO Enable
design to the transmission interface connector. Refer to Allison Secondary Mode Indicator
Transmission documentation for feature and function specifications and Auxiliary Hold
Secondary Mode Input
illustration of specific electrical device interface design of each circuit. Two-Speed Axle Enable
Automatic Neutral-Dual Input With Park Brake
Data Book Codes for the Transmission Interface Harness 10 497D5 (I) 142 Secondary Mode Input Auto Neutral-Dual Input With Service Brake
Status
Data Book Code Description Auxiliary Function Range Inhibit (special)
34C-001 Transmission Interface Harness at the Frontwall Auto Neutral-Dual Input With Service Brake
Status
34C-002 Transmission Interface Harness at Back of Cab Auxiliary Function Range Inhibit (standard)
34C-003 Transmission Interface at End of Frame Automatic Neutral-Dual Input With Park Brake
Shift Selector Transition
Auxiliary Function Range
11 497D6 (I) 101 Two-Speed Axle Enable
Inhibit (standard)
Transmission Interface (Gray Plug) Shift Selector Transition/Secondary Shift
Schedule
Auxiliary Function Range Inhibit (special)
1 8 FTL Male Part Number Automatic Neutral-Single Input
Connector 23-13153-057 Direction Change Enable
Terminal Pin 23-13211-031 Reverse Enable
1 2 3 4 5 6 7 8 12 497D10 (I) 117 –
Automatic Neutral-Dual Input With Park Brake
9 10 11 12 13 14 15 16 Vndr Male Part Number Auto Neutral-Dual Input With Service Brake
Connector 54241601 Status
Terminal Pin 54001626
9 16 Sump Sump
13 497C6 (O) 164 Retarder Temperature Retarder Temperature Indicator
Indicator
8 1 FTL Female Part Number
4th Lockup Pump Mode
14 497D1 (I) 123 3rd Lockup Pump Mode Kickdown
Connector 23-13153-056
Direction Change Enable
8 7 6 5 4 3 2 1 Terminal Pin 23-13211-021
4th Lockup Pump Mode
16 15 14 13 12 11 10 9 3rd Lockup Pump Mode
Vndr Female Part Number 15 497D4 (I) 122 Refuse Packer Step Switch
Transfer Case Low
Connector 54241631 Reduced Engine Load at Stop
Terminal Pin 54001625
16 9 16 – – – –
† When more than one function is listed, see the Allison Transmission Vocational Model Guide for the applicable function.
§‡ Output

Rev - B

Page 32
Data Book Codes for Engine Remote
Interface Harnesses (ERIH)
Data Book Code Description
148-070 ERIH With Fixed Single Speed
Engine Interface Connector 148-071 ERIH With Increment/Decrement
Freightliner provides an engine interface harness when an Engine Interface Connector 148-072 ERIH With Multiple Set Speeds
148-073 ERIH for Remote Throttle
rpm control system is ordered for optional body builder 148-074 ERIH Not Configured
features and PTO (power takeoff) applications. 163-001 ERIH at Back of Cab
The optional features provided by this harness include: 163-002 ERIH at End of Frame
163-003 ERIH at End of Frame w/6-ft Harness
- Fast idle
163-004 ERIH s in Engine Compartment
- Increment/decrement 163-012 ERIH Inside the Cab Under the Dash Blunt Cut
- Multiple fixed speeds 163-006 ERIH Inside the Cab Under the Dash
- Variable RPM title 87L-001 ERIH With Park Brake Interlock
87L-003 ERIH With Park Brake and Neutral Interlocks
Module 148 determines the type of remote engine throttle. 87L-005 ERIH Without Interlocks
Module 163 determines the location of the interface connector.
Module 87L determines the interlock requirements. Engine Interface (Black Plug)
There should be a tan ribbon tape at the connector for easy 1 8 FTL Male Part Number
locating and identification. Connector 23-13153-031
Terminal Pin 23-13211-031
1 2 3 4 5 6 7 8
9 10 11 12 13 14 15 16 Vndr Male Part Number
Engine Connector 54241600
Terminal Pin 54001626
(Black Plug) 9 16

8 1 FTL Female Part Number


Connector 23-13153-030
8 7 6 5 4 3 2 1 Terminal Pin 23-13211-021
DD13 Interface Cummins Interface 16 15 14 13 12 11 10 9 Vndr Female Part Number
Connector 54241630
Terminal Pin 54001625
CPC Pin Pin Harness Usage Description Circuit # ECM Pin 16 9
Pin Harness Usage Description Circuit #
Conn/Pin 1 Eng Control Dash Engine RPM Chass 400G 62
1 Eng Control Dash Dash Engine Control 483Z 4/2 2 Engine Control Remote PTO 439U 94
2 Engine Control Remote VSG Select 439U 2/9 3 Engine Control CC/PTO On/Off Switch w/RPM 492U 90
3 Engine Control Cruise Control On/Off Enable 492U 1/14 4 Engine Control CC/PTO Set w/RPM 483A 12
4 Engine Control Cruise Control Set/Coast 483A 1/12 5 Engine Control CC/PTO Resume w/RPM 483B 19
5 Engine Control Cruise Control Resume/Accel 483B 1/16 6 Engine Control Max Operating Speed/Gov 483R 66
6 Engine Control Limiter 0 439V1 1/11 7 Spare --- – –
7 Engine Control Limiter 1 439V2 2/11 8 Engine Control Tachometer 483E 30
8 Engine Control Tachometer 483E 1/9 9 Spare --- – –
9 Engine Control Throttle Inhibit 492Z 1/17 10 Engine Control Remote Throttle On/Off 483N 67
10 Engine Control Remote Accelerator Select 483N 2/8 11 Engine Control Remote Throttle Signal w/RPM 483C 63
11 Engine Control Variable Speed Governor 483C 3/4 12 Engine Control Remote Throttle Power 483D 8
12 Engine Control +5V Sensor Supply 483D 3/3 13 Engine Control Eeng #1 Snsr Com Ground w/RPM 492Y 32
13 Eng Control Dash Dash Engine Control 492Y 4/2 14 Spare --- – –
14 Power Ignition Dash Power 439A 2/3 15 Spare --- – –
15 Spare --- – – 16 Spare --- – –
16 Spare --- – –
Rev - B

Page 33
PTO Installation Compatibility PTO Installation Compatibility
All SmartPlex PTO controls employ a multiplexed dash mounted Smart Switch,
PTO Control wiring, and air piping, which is driven by several different factors Customer Installed PTO Compatibility Chart
on the M2 and SD Platforms.
Electric over Electric Over
Factors include but are not limited to: Air Shift PTO Hydraulic Shift
- Transmission type Control PTO Control
- Transmission programming package
- PTO make and model, and interlock type Mod 362

w/PTO provisions

w/PTO provisions
Allison Automatic

Allison Automatic
PTO Option Description

Transmissions

Transmissions

Transmissions
All Manual
PTO controls are pre-wired specifically to match the transmission and PTO combination. Options
For this reason data code combinations for Modules 372 and 362 are critical.
Module 372 specifies the Number and Type of PTO Controls
- Single or Dual controls
- Interlock Scheme (Park Brake Interlock, Neutral Interlock, Park Brake
& Neutral Interlock) 362-801 MUNCIE RS4 SERIES REAR MOUNT PTO, CUSTOMER INSTALLED X X

Module 362 specifies which PTO will be installed. This can be specified two ways 362-1T7 CHELSEA 221 SERIES, CUSTOMER INSTALLED PTO X X
- A factory installed PTO can be chosen (Contact your CAE representative for a quote) 362-1BU CHELSEA 230/231/236 SERIES, CUSTOMER INSTALLED PTO X X
- For "Customer Installed" data codes select from the options in the chart
362-1M2 CHELSEA 236 SERIES, CUSTOMER INSTALLED PTO X X
If a 372 code other than 372-998 or 372-051 is specified, a corresponding 362 data code 362-802 CHELSEA 442 SERIES, CUSTOMER INSTALLED PTO X X
must be specified to ensure the correct wiring, PTO connector style, and air piping
connections are in place. 362-1T6 CHELSEA 489 SERIES, CUSTOMER INSTALLED PTO X X

The charts on this page are designed to help guide you through the compatibility process. 362-1PB CHELSEA 541 SERIES REAR MOUNT, CUSTOMER INSTALLED PTO X X
362-1T8 CHELSEA 812 SERIES, CUSTOMER INSTALLED PTO X X
PTO Wiring can be found in module 885.
362-805 MUNCIE 82 SERIES, CUSTOMER INSTALLED PTO X X
362-803 MUNCIE SERIES CS6 WITH ELEC/AIR CONTROLS, CUSTOMER INSTALLED PTO X X
362-800 MUNCIE SERIES CS8, CUSTOMER INSTALLED PTO X X
362-040 MUNCIE SERIES TG6 & TG8, CUSTOMER INSTALLED PTO X X
362-1U0 MUNCIE SERIES TG6, CUSTOMER INSTALLED PTO X X
362-1U1 MUNCIE SERIES TG8, CUSTOMER INSTALLED PTO X X
362-1BV CHELSEA 270 SERIES, CUSTOMER INSTALLED PTO X
362-1DV CHELSEA 277 SERIES WITH REMOTE SOLENOID, CUSTOMER INSTALLED PTO X
362-035 CHELSEA 277 SERIES, CUSTOMER INSTALLED PTO X
362-145 CHELSEA PTO - CHL340SFAHX G5XD X
362-158 CUSTOMER INSTALLED MUNCIE CS10 SERIES PTO X
362-807 CUSTOMER INSTALLED MUNCIE 41 SERIES PTO X
362-157 MUNCIE SERIES CS20, CUSTOMER INSTALLED PTO X
362-804 MUNCIE SERIES CS6 WITH ELEC/HYD CONT, CUSTOMER INSTALLED PTO X

Factory installed PTO's are avaliable and can alo be selected (Contact CAE representative for quotes and avaliability)

Rev - B

Page 34
PTO Controls PTO Controls
All SmartPlex PTO controls employ a Multiplexed dash mounted Smart Switch.
PTO Control wiring and air piping is driven by several different factors on the Factory Installed PTO Control Compatibility Chart
M2 and SD Platforms.
Electric over Air Electric Over
PTO Safety
Factors include but are not limited to: Installation
Shift PTO Hyd Shift Controls
Interlocks
Availability
Control PTO Control
- Transmission type, Transmission programming package,
- PTO make and model, PTO Interlock type Mod 372

Unpublished - Avail via


Manual Transmissions

Transmissions w/PTO

Transmissions w/PTO

Data Book / Spec Pro


AGS2 Transmissions

Park Brake Interlock


Dual Dash Switches
Single Dash Switch
PTO

Customer Installed
Option Description

Allison Automatic

Allison Automatic

Neutral Interlock
Factory Installed
Control

Price Quote
provisions

provisions

Published
PTO controls are pre-wired specifically to match the transmission and PTO
combination. Options
For this reason data code combinations for Modules 372 and 362 are critical.
Module 372 specifies the Number and Type of PTO Controls
- Single or Dual controls 372-035 (1) DASH MTD PTO SWITCH W/IND LAMP X X X X X X
- Interlock Scheme (Park Brake Interlock, Neutral Interlock, Park Brake & 372-063 (1) DASH MTD PTO SWITCH W/IND LAMP FOR CUST INST PTO X X X X X X
Neutral Interlock)
372-036 (1) DASH MTD PTO SWITCH W/IND LAMP - PK BRK INTERLOCK X X X X X X X
Module 362 specifies which PTO will be installed. This can be specified two ways
- A factory installed PTO can be chosen (Contact CAE representative for quote) 372-065 (1) DASH MTD PTO SWITCH W/IND LAMP - PK BRK INTERLOCK FOR CUST INST PTO X X X X X X X
- For "Customer Installed" data codes select from the options in Chart Below X X X X X X
372-037 (1) DASH MTD PTO SWITCH W/IND LAMP - NEUT INTERLOCK
If a 372 code other than 372-998 or 372-051 is specified, a corresponding 362 372-067 (1) DASH MTD PTO SWITCH W/IND LAMP - NEUT INTERLOCK FOR CUST INST PTO X X X X X X
data code must be specified to ensure the correct wiring, PTO connector style.
and air piping connections are in place. 372-043 (1) DASH MTD PTO SWITCH W/IND LAMP - PK BRK & NEUT INTERLOCK X X X X X X X
(1) DASH MTD PTO SWITCH W/IND LAMP - PK BRK & NEUT INTERLOCK FOR CUST X X X X X X X
The charts on this page are designed to guide you through the compatibility 372-073
INST PTO
process. (1) DASH MTD PTO SWITCH W/IND LAMP WITH PDI MODIFICATION TO INCREASE X X X X X
26-20720-004 372-058
ENGINE RPM TO HIGH IDLE WHEN PTO IS ENGAGED
(1) DASH MTD PTO SWITCH W/IND LAMP WITH PDI MODIFICATION TO INCREASE X X X X X
372-068
ENGINE RPM TO HIGH IDLE WHEN PTO IS ENGAGED FOR CUST INST PTO
372-044 (1) DASH MTD PTO SWITCH W/IND LAMP FOR AGS2 TRANS - STATIONARY MODE X X X X
(1) DASH MTD PTO SWITCH W/IND LAMP FOR AGS2 TRANS - STATIONARY MODE FOR X X X X
372-066
CUST INST PTO
372-045 (1) DASH MTD PTO SWITCH W/IND LAMP FOR AGS2 TRANS - MOBILE MODE X X X X
(1) DASH MTD PTO SWITCH W/IND LAMP FOR AGS2 TRANS - MOBILE MODE FOR X X X X
372-064
CUST INST PTO
372-051 CUSTOMER FURNISHED AND INSTALLED PTO CONTROLS ** X X X X X X

372-060 (2) DASH MTD PTO SWITCHES W/IND LAMPS X X X X X X

372-069 (2) DASH MTD PTO SWITCHES W/IND LAMPS FOR CUST INST PTO X X X X X X

372-054 (2) DASH MTD PTO SWITCHES W/IND LAMPS - PK BRK INTERLOCKS X X X X X X X
(2) DASH MTD PTO SWITCHES W/IND LAMPS - PK BRK INTERLOCKS FOR CUST INST X X X X X X X
372-072
PTO
372-062 (2) DASH MTD PTO SWITCHES W/IND LAMPS - NEUT INTERLOCKS X X X X X X
(2) DASH MTD PTO SWITCHES W/IND LAMPS - NEUT INTERLOCKS FOR CUST INST X X X X X X
372-071
PTO
372-061 (2) DASH MTD PTO SWITCHES W/IND LAMPS - PK BRK & NEUT INTERLOCKS X X X X X X X
(2) DASH MTD PTO SWITCHES W/IND LAMPS - PK BRK & NEUT INTERLOCKS FOR X X X X X X X
372-070
CUST INST PTO
372-998 NO PTO CONTROLS *** X X X X X

(X) Designates avalaiability of PTO control/ PTO control type and transmission

** If customer is supplying their own controls and does not require factory installed parts 372-051 should be specified to notify the plant to route clearance for pto Install

372-998 should be specified only when a PTO will not be needed or added in the future. (no routing provision will be done)
***

Rev - B
Page 35
PTO Air Control Schematics PTO Air Control Schematics
Schematics are for reference only, see the following modules for
vehicle specific configurations.
- Wiring - module 885 PTO Switch Control Schematic
- Airing - module 372 Module: 885
- Factory PTO - Module 362 Bulk Head Module (BHM)

Smart switch
#1 in dash

PTO Electrical Schematic


Module: 885
PTO Air Schematics
Module: 372

Single factory supplied PTO Control


Dual factory supplied PTO Control
Dual factory supplied PTO Control w/Regulator
Dual Customer supplied PTO Control

Wire Braid line on Chassis Only

Blue or Green #4 Line Blue or Green #4 Line

Black #4 Line Black #4 Line

PTO Engagement
Cylinder Inlet Outlet
65 PSI PPV
Yellow #4 Line
Dash Regulator Module: 46D

Yellow #4 Line

Rev - B
Page 36
PTO Electric Control Schematics PTO Electric Control Schematics
Schematics are for reference only, see the following modules for
vehicle specific configurations.
- Wiring - module 885 Switch Control Schematic
- Airing - module 372 Mod - 885
Bulk Head Module (BHM)
- Factory PTO - Module 362

Smart switch
#1 in dash

PTO Control Schematic


PTO Control Schematic
Allison 1000/2000 series
Allison 3000/4000 series
Mod - 885
Mod - 885
PTO pressure switch
PTO pressure switch or capped for
or capped for customer supplied
customer supplied connection
connection

PTO solenoid or
PTO solenoid or capped for
capped for customer supplied
customer supplied connection
connection

Bulk Head Module (BHM)


Bulk Head Module (BHM)

PTO Relay #5
PTO Relay #5 PDM
PDM

Rev - B
Page 37
Remote Start/Stop Controls
157-007 MANUAL REMOTE ENGINE START/STOP WITH PTO
The remote start stop feature is available but requires a few RE-ENGAGE
interlocks for the safety of the operators. Remote Start Stop Controls Ÿ Available only with Allison or Eaton Fuller RT/O/X, FM, FR/FRO, RTLO, UltraShift
- Transmission neutral interlock or UltraShift Plus transmissions.
Ÿ Available only in combination with DC 99C-013 2013 ONBOARD
- Hood switch DIAGNOSTICS/2010 EPA/CARB/GHG14
- PTO switch in the dash Ÿ Requires one of the following:
• DC 372-043 (1) DASH MOUNTED PTO SWITCH WITH INDICATOR LAMP -
Schematics are for reference only, see the following modules for PARK BRAKE AND NEUTRAL INTERLOCK
vehicle specific configurations. • DC 372-073 (1) DASH MOUNTED PTO SWITCH WITH INDICATOR LAMP -
- Wiring - module 157 PARK BRAKE AND NEUTRAL INTERLOCK FOR CUSTOMER INSTALLED
PTO
Ÿ Requires DC 018-002 AIR BRAKE PACKAGE

Rev - B
Page 38
VDR Prep Information Body Builder connections
BB 1A / BB 2A
The VDR Prep Harness comes standard with all SmartPlex vehicles
that require NFPA 1901 compliant seat options
756-1E7 / 756-1F2 and or 760-1E8 / 760-1E9 / 760-1F0 VDR Prep Information
760-1E7 / 760-1F1 / 760-1BX / 760-014 / 760-997
Reference Module 74F for wiring details and schematics

DRIVER SEATBELT BUCKLE 1 204B #2104 (T-W)


12 1 DRIVER SEAT OCCUPY
FRONT PASS SEATBELT BUCKLE
12
2
432E #2010 (T-W)
204C #2104 (T-W)
FRONT PASS SEAT OCCUPY 11 432F #2010 (T-W)
RR DRIVER SEATBELT BUCKLE 3 204D #2104 (T-W)
RR DRIVER SEAT OCCUPY 10 432G #2010 (T-W)
RR CENTER SEATBELT BUCKLE 4 204E #2104 (T-W)
RR CENTER SEAT OCCUPY 9 432H #2010 (T-W)
PP PASS SEATBELT BUCKLE 5 204F #2104 (T-W)
RR PASS SEAT OCCUPY 8 432J #2010 (T-W)
OPT PASS SEATBELT BUCKLE 6 204G #2104 (T-W)
7 6 OPT PASS SEAT OCCUPY 7 432K #2010 (T-W) Dash/Seat harness
Seat/Seatbelt
connection point
Sensor Harness
DRCDG_DASH_0_JMPR_BB_2A
FTL Connector # 12”
23-13148-074
Equivalent part #
DUFDTM06-12SB
BB 2A

Mating Connector
DUFDTM04-12PB
12”
BB 1A

FTL Connector #
23-13148-400
Equivalent part #
DUFDT04-4P
Mating Connector
DUFDT06-4S DRCDG_DASH_0_JMPR_BB_1A
BB 1A BB 2A
2 1
J1939+ 250K - HI 1 J1939+ # 1603 (Y)
J1939- 250K - LO 2 J1939- # 1603 (DKG)
The VDR prep harness supplies a centrally located
GROUND 3 GND # 1206 (BK) EDR black box connection under center of dash and
POWER (+12V) BAT 4 442 # 2009 (DKG) includes all the connections needed for connection to
3 4 the primary J1939 250K compliant VDR / EDR Units (see next page).
Rev - B
Page 39
VDR Connections VDR Connections to SmartPlex

813-1C0 NFPA VEHICLE DATA


RECORDER AND SEATBELT DISPLAY

813-1C1 - NFPA VEHICLE DATA


RECORDER AND SEATBELT
DISPLAY WITH DETROIT VIRTUAL
SEAT/BELT J2
TECHNICIAN REMOTE ENGINE SIGNAL I/O
CAN BUS STATUS

DIAGNOSTICS POWER

SEAT/BELT J1
SEAT MONITOR FRC DATALINK

813-1C2 - NFPA VEHICLE DATA


Http://www.weldoninc.com RECORDER & SEATBELT DISPLAY
W/DETROIT VIRTUAL TECH
Weldon Vehicle Data Recorder to FTL Harness VISIBILITY PKG: REMOTE ENGINE Http://www.fireresearch.com
Connector "B DTM06-12SB" to FTL Connector DRCDG_DASH_0_vdr_2A
I INPUT TYPE BB2A Pin INPUT TYPE
DIAG W/WEB ACCESS, ENGINE &
1 Seat Belt 1 Status Gnd/Batt 1 DRIVER SEATBELT BUCKLE Gnd IFTA/IRP REPORTS & LOCATION FRC Vehicle Data Recorder to FTL Harness
2 Seat Belt 2 Status Gnd/Batt 2 FRONT PASS SEATBELT BUCKLE Gnd DATA Connector "Seat/Belt J1 DT06-12S" to FTL Connector DRCDG_DASH_0_JMPR_BB_2A
3 Seat Belt 3 Status Gnd/Batt 3 RR DRIVER SEATBELT BUCKLE Gnd I INPUT TYPE BB2A Pin INPUT TYPE
4 Seat Belt 4 Status Gnd/Batt 4 RR CENTER SEATBELT BUCKLE Gnd 12 Seat Belt 1 Status Gnd/Batt 1 DRIVER SEATBELT BUCKLE Gnd
5 Seat Belt 5 Status Gnd/Batt 5 PP PASS SEATBELT BUCKLE Gnd 11 Seat Belt 2 Status Gnd/Batt 2 FRONT PASS SEATBELT BUCKLE Gnd
6 Seat Belt 6 Status Gnd/Batt 6 OPT PASS SEATBELT BUCKLE Gnd 10 Gnd/Batt 3 Gnd
Seat Belt 3 Status RR DRIVER SEATBELT BUCKLE
7 Occupancy 6 status Gnd/Batt 7 OPT PASS SEAT OCCUPY Gnd
9 Seat Belt 4 Status Gnd/Batt 4 RR CENTER SEATBELT BUCKLE Gnd
8 Occupancy 5 status Gnd/Batt 8 RR PASS SEAT OCCUPY Gnd
8 Seat Belt 5 Status Gnd/Batt 5 PP PASS SEATBELT BUCKLE Gnd
9 Occupancy 4 status Gnd/Batt 9 RR CENTER PASS SEAT OCCUPY Gnd
Gnd
7 Seat Belt 6 Status Gnd/Batt 6 OPT PASS SEATBELT BUCKLE Gnd
10 Occupancy 3 status Gnd/Batt 10 RR DRIVER PASS SEAT OCCUPY
11 Occupancy 2 status Gnd/Batt 11 FRONT PASS SEAT OCCUPY Gnd 6 Occupancy 6 status Gnd/Batt 7 OPT PASS SEAT OCCUPY Gnd
12 Occupancy 1 status Gnd/Batt 12 DRIVER SEAT OCCUPY Gnd 5 Occupancy 5 status Gnd/Batt 8 RR PASS SEAT OCCUPY Gnd
4 Occupancy 4 status Gnd/Batt 9 RR CENTER PASS SEAT OCCUPY Gnd
Connector "A DTM06-12SA" to FTL Connector DRCDG_DASH_0_VDR_1A 3 Occupancy 3 status Gnd/Batt 10 RR DRIVER PASS SEAT OCCUPY Gnd
I INPUT TYPE BB2A Pin INPUT TYPE 2 Occupancy 2 status Gnd/Batt 11 FRONT PASS SEAT OCCUPY Gnd
1 Park Brake Status Gnd/Batt N/R Supplied by J1939 Hi/Lo 1 Occupancy 1 status Gnd/Batt 12 DRIVER SEAT OCCUPY Gnd
2 Service Brake Gnd/Batt N/R Supplied by J1939 Hi/Lo
3 E-master Status Gnd/Batt N/R Body Builder Supplied (optional) Gnd/Batt Connector "POWER/DATABUS DT06-8SA" to FTL Connector DRCDG_DASH_0_JMPR_BB_1A
4 CAN 2 – Lo Lo N/R Body Builder Supplied (optional) Lo INPUT TYPE BB2A Pin INPUT TYPE
5 CAN 1 – Lo Lo 2 J1939 - _ LO (250K) Lo 1 Supply + (Battery) Batt 4 Vbatt Vbatt
6 V-MUX – B Lo VDR Body Builder Supplied Lo Supply - (GND)
2 Gnd 3 Ground Gnd
7 V-MUX – A Hi VDR Body Builder Supplied Hi
3 Ignition IGN (12V) N/R Body Builder Supplied IGN (+12V)
8 CAN 1 – Hi Hi 1 J1939 + _ HI (250K) Hi
4 Parking Brake Signal Gnd/Batt N/R Supplied by J1939 Hi/Lo
9 CAN 2 – Hi Hi N/R Body Builder Supplied (optional) Hi
5 Master Optical Warning Gnd/Batt N/R Body Builder Supplied (optional)
10 System Power Vbatt 4 POWER (+12V) BAT Vbatt
11 Red Indicator Gnd (Out) N/R Body Builder Supplied (optional) Gnd (Out) 6 J1939 (shield) Gnd N/R Not Required
12 System Ground GND 3 GROUND GND 7 J1939 (-) Lo 2 J1939 - _ LO (250K) Lo
8 J1939 (+) Hi 1 J1939 + _ HI (250K) Hi
For M2 Models Service brake and ABS signals are broadcasting via J1939.
The Weldon V-Mux VDR can accept M2 information via J1939 (250K) connection
therefore no additional hard wiring is required with this harness. Rev - B

Page 40
Snow Plow Lamp (304-038, 304-039)
Snow Plow Lamps
Factory installed provision for snow plow light control that provides
an in dash control switch and wiring for customer installed plow lights.
When the snow plow lamp switch in the cab is activated, the truck
headlights are turned off and the headlight controls will operate the
customer installed headlights. Low beams will be off with high beam request.
Note: Power to snow plow module typically provided through fuses F3 and F4
located in the Power Distribution Module.
Data code 304-038 provides a single connector and switch for
plow mounted headlights.
Data code 304-039 provides dual connectors and switch for hood
mounted headlights.
The plow light connector should have a blue ribbon tape at the
connectors for easy location and identifications.

304-039 Snow Plow Headlight Dual Connector (LH Side) 304-039 Snow Plow Headlight Dual Connector (RH Side) 304-038 Snow Plow Headlight Single Connector
A F Mating connector supplied with Chassis A F Mating connector supplied with Chassis Mating connector supplied with Chassis
Packard Connector PAC 12052848 Packard Connector PAC 12052848 Packard Connector PAC 12110751
D E
Terminal supplied by Body Builder Terminal supplied by Body Builder D E Terminal supplied by Body Builder
Packard Terminal PAC 12048074 Packard Terminal PAC 12048074 C A F C A F Packard Terminal PAC 15304719
C Packard Seal Part# PAC 12059168 C D
Packard Seal Part# PAC 12059168 B G B G Freightliner Seal Part# 23-12497-282
D

Connector Signal Circuit Circuit Connector Signal Circuit Circuit Connector Signal Circuit Circuit
Signal Name Amperage Signal Name Amperage Signal Name Amperage
Pin Type Color Number Pin Type Color Number Pin Type Color Number
A High Beam Output LTG 462K 30 A High Beam Output LTG 463H 30 A High Beam Output LTG 462K 30
B Ground Ground BK 462C - B Ground Ground LTG 463C - B Ground Ground BK GND -
C Low Beam Output LTG 462J 25 C Low Beam Output LTG 463L 25 C Low Beam Output LTG 462J 25
D Marker Lamp Output BR 102C 10 D Marker Lamp Output BR 102C 10 D Marker Lamp Output BR 102C 10
E Ground Ground BK GND - E Ground Ground BK GND - E Right Turn Signal Output DKG 38RP 2.85
F Left Turn Signal Output Y 38LP - F Right Turn Signal Output DKG 38RP - F Left Turn Signal Output Y 38LP 2.85
G - - - - -

Single connector can be found on LH frame rail near radiator


Dual connectors located near front crossmember Rev - B

Page 41
SmartPlex Electrical System
SmartPlex Electrical System (35M module)

When ordered, the 35M SmartPlex module is a factory installed option


that provides Truck Equipment Manufacturers (TEMs) ease of
integration with Freightliner’s multiplexed electrical system. TEM’s can
easily take advantage of information provided on the J1939 bus to
create safety and interdependent interlocks with a simple program
parameter versus having to cut into chassis wiring to install relays.
This shortens installation time for TEM’s and eliminates additional
electrical connections that can be problematic in the field.

Included in 35M is a SmartPlex Hub Module and all the wiring necessary
to make available twelve 20 amp outputs, ten 7 amp outputs and six Note: Switches and indicator lamps are not
ground inputs. The twelve 20A outputs are provided in the 12 pin connector functional as received from the factory and
and the 7 amp outputs and ground inputs are provided in the 16 pin require programming. Each switch and
connector. The connectors are located inside the cab behind the driver indicator lamp will have a unique parameter
seat. The 20 amp outputs are fused and relayed in a relay module behind providing the desired function. For example
the driver seat. The 7 amp outputs are run directly through the SmartPlex if you wanted switch #1 to turn on 20 amp
Hub Module and are FET transistor protected in the module. output #1 only when the park brake was set
you would program a specific parameter to
accomplish this. Authorized dealers as well
as trained equipment manufacturers with a
body builder log in can program a vehicle.
Equipment manufacturers can contact their
dealer or the body builder support desk at
855-253-0426 for training.
Extended Cab wired with SmartPlex

2 position 3 position

There are 9 variations of the 35M SmartPlex module that can be Switches and indicator lamps are ordered separately from the 35M
ordered. The variations determine the quantity of the available module. Switches are ordered by style and quantity. Indicator lamps
switch locations provided in the vehicle overhead in multiples of are available for order in red, amber, or green. Some pre-labeled
6 from 6 to 24. indicator lamps are also available for order. Switch lense inserts are
provided based on the vocational use of the truck ordered. Custom
lenses can be requested through Vencor Inc., (www.vencorinc.com). TEM interface connectors
Rev - B
Page 42
Smart Switches ! 12 Shown
Parameter
Bulkhead Defined
Module Decision
(BHM) Inputs ! Park
Brake, RPM,
Hardwire
etc.
Connections SmartPlex Electrical System
Switch Hub
Module
(SHM)
J1939
500K
Databus

Chassis
Smartplex
PDM
Module The web-based SmartPlex parameter
(CHM)
Battery Power search tool allows TEMs and dealers to
from Aux PNDB
do specific criteria based searches to
1A 2A find reference parameters. If a
Customer
Interface
Customer
Interface
parameter does not currently exist
Connector 1A Connector 2A using the search tool, a custom request
Ten 6.7 Amp Twelve 20 Amp can be submitted. Once this new
Output Circuits Output Circuits
and Six parameter is created it can be used
Hardwire Input again in the future.
Circuits
08/08/2012 f545916

,SmartplexSystemDiagram

Smartplex is a configurable system that allows a common set of


electronic components to manage different options in various
vehicle configurations. Smartplex allows the customer to select
the switches needed for the vehicle, then configure the output
circuits for specific functions. Smartplex allows up to 24 switches The SmartPlex system is programmed by
and indicators in the overhead console, and 6 hardwired input using Freightliner ‘s web based service tool
circuits, to control twelve 20-amp output circuits and ten 6.7-amp called ServiceLink. An internet connection is
output circuits. Any combination of smart switches and hardwire required and connection to the vehicle is
made using a laptop and a commercially
input circuits can be configured to operate the output circuits that available USB Link diagnostic connector.
are wired to customer interface connector 1A, and customer New Parameters are first saved to
interface connector 2A. The configuration is programmable with Freightliner’s mainframe computer before
ServiceLink using parameters that can be accessed using the loading them to the vehicle which provides
"Parameter Search Tool". the security of archiving the latest set of
parameters .
Again, a parameter programmed to the
An authorized Freightliner dealer can provide programming or a bulkhead module is required to make a
truck equipment manufacturer with a body builder login id will have switch functional.
access to the “SmartPlex Parameter Search Tool” and
“ServiceLink” to perform programming. You can contact the Body
Builder Support desk at 855-253-0426 to receive instruction on
requesting a login id as well as request additional training.

Rev - B

Page 43
Customer Interface Connector 2A
•12 HSD 12V 20Amp Outputs
SmartPlex Switch and Indicators
Each switch and indicator has its own unique part number.

Parameters are designed for specific switches and indicators.


SmartPlex Electrical System
Ÿ Note how the programming parameter aligns to the switch part number.
Ÿ For example all on/off latching switches have a part number that is A06- 20A Output #7 20A Output #1
86377-100. If the truck was ordered with 2 on/off latching switches, the 20A Output #2
20A Output #8
first 2 part numbers in this group would be provided so you would receive 26-20100 - SmartPlex™ Parameter – ON/OFF Latching Switches
A06-86377-100 and A06-86377-101. 20A Output #9 20A Output #3
26-20200 - SmartPlex™ Parameter – ON/OFF Momentary Switches
Ÿ An example of a parameter for the first on/off latching switch A06-86377- 26-20300 - SmartPlex™ Parameter – ON/OFF/ON Latching Switches 20A Output #4
20A Output #10
100 would be 26-20100-002. Which would provide the function of 26-20400 - SmartPlex™ Parameter – ON/OFF/ON Momentary
energizing 6.7amp output number 1 on customer interface connector 2A. 20A Output #11 20A Output #5
26-20500 - SmartPlex™ Parameter – Indicators
20A Output #12 20A Output #6
As you can see in the table below, any parameter beginning with the base
number 26-20100-XXX will be to operate on/off latching switch #1 A06-86377-
100 and as you change the last 3 numbers of the parameter, the function
changes.

You can have only one parameter for a given switch or indicator. Because the
switches and indicators are unique, you can not have an identical part
number plugged into the SmartPlex system at the same time or an error will
occur. You can however move a switch or indicator from one position to
another without having to reprogram anything.
Customer Interface Connector 1A
•6 Digital Ground Inputs
•10 HSD 12V 7Amp Outputs

7A Output #9 7A Output #1
7A Output #10 7A Output #2
Ground Input #1 7A Output #3
Ground Input #2 7A Output #4
Ground Input #3 7A Output #5
Ground Input #4 7A Output #6
Ground Input #5 7A Output #7
Ground Input #6 7A Output #8

Rev - B
Page 44
SmartPlex Indicator Lamp Data Code Decoder
SmartPlex Electrical System
Indicator Part Numbers

A06-86377-500

A06-86377-501

A06-86377-502

A06-86377-503

A06-86377-504

A06-86377-505

A06-86377-506

A06-86377-507

A06-86377-600

A06-86377-601

A06-86377-602

A06-86377-603

A06-86377-604

A06-86377-605

A06-86377-606

A06-86377-607

A06-86377-608
Indicator Part Numbers
SmartPlex Switch Data Code Decoder
Switch Part Numbers
Indicator ID Numbers 306 307 308 309 310 311 312 313 314 315 316 321 322 323 324 325 326

A06-86377-100

A06-86377-101

A06-86377-102

A06-86377-103

A06-86377-104

A06-86377-105

A06-86377-106

A06-86377-107

A06-86377-108

A06-86377-109

A06-86377-200

A06-86377-201

A06-86377-202

A06-86377-203

A06-86377-204

A06-86377-300

A06-86377-301

A06-86377-302

A06-86377-303

A06-86377-304

A06-86377-400

A06-86377-401

A06-86377-402

A06-86377-403

A06-86377-404
IND LT-RED, BOOM OUT OF STOW

IND LT-RED, OUTRIGGER DEPLOYED

IND LT-RED, BODY UP

IND LT-RED, GATE OPEN

IND LT-RED, OFF

IND LT-GREEN, BATTERY ON

IND LT-GREEN, ON

IND LT-AMBER, CAUTION

IND LT-RED

IND LT-RED

IND LT-RED

IND LT-AMBER

IND LT-AMBER

IND LT-AMBER

IND LT-GREEN

IND LT-GREEN

IND LT-GREEN
Switch Part Numbers
Data
Code

Smart Switch ID Numbers 273 274 275 276 277 278 279 280 281 282 283 284 289 290 291 292 293 294 295 296 297 298 299 300 305

Data Code Description Data

SW-RCKR,2 POS MOM, W INDIC

SW-RCKR,2 POS MOM, W INDIC

SW-RCKR,2 POS MOM, W INDIC

SW-RCKR,2 POS MOM, W INDIC

SW-RCKR,2 POS MOM, W INDIC


SW-RCKR, 2 POS LAT, W INDIC

SW-RCKR, 2 POS LAT, W INDIC

SW-RCKR, 2 POS LAT, W INDIC

SW-RCKR, 2 POS LAT, W INDIC

SW-RCKR, 2 POS LAT, W INDIC

SW-RCKR, 2 POS LAT, W INDIC

SW-RCKR, 2 POS LAT, W INDIC

SW-RCKR, 2 POS LAT, W INDIC

SW-RCKR, 2 POS LAT, W INDIC

SW-RCKR, 2 POS LAT, W INDIC


Code

SW-RCKR, 3 POS MOM

SW-RCKR, 3 POS MOM

SW-RCKR, 3 POS MOM

SW-RCKR, 3 POS MOM

SW-RCKR, 3 POS MOM


SW-RCKR, 3 POS LAT

SW-RCKR, 3 POS LAT

SW-RCKR, 3 POS LAT

SW-RCKR, 3 POS LAT

SW-RCKR, 3 POS LAT


Data Code Description

44V-998 No SmartPlex Indicator Lamps


44V-001 SmartPlex Indicator Lamp - Boom Out of Stow x
44V-002 SmartPlex Indicator Lamps - Boom Out of Stow & Outrigger Deployed x x
44V-003 SmartPlex Indicator Lamps - Body Up & Gate Open x x
44V-004 SmartPlex Indicator Lamp - Battery On x 44R-998 No On/Off Latching SmartPlex Switches
44V-005 SmartPlex Indicator Lamps - On & Off x x 44R-001 1 On/Off Latching SmartPlex Switch x
44V-006 SmartPlex Indicator Lamp - On x 44R-002 2 On/Off Latching SmartPlex Switches x x
44V-007 SmartPlex Indicator Lamp - Off x 44R-003 3 On/Off Latching SmartPlex Switches x x x
44V-008 SmartPlex Indicator Lamp - Caution x 44R-004 4 On/Off Latching SmartPlex Switches x x x x
44W-998 No SmartPlex Indicator Lamps 44R-005 5 On/Off Latching SmartPlex Switches x x x x x
44W-001 SmartPlex Indicator Lamps (0-Red, 0-Amber, 1-Green) x 44R-006 6 On/Off Latching SmartPlex Switches x x x x x x
44W-002 SmartPlex Indicator Lamps (0-Red, 0-Amber, 2-Green) x x 44R-007 7 On/Off Latching SmartPlex Switches x x x x x x x
44W-003 SmartPlex Indicator Lamps (0-Red, 0-Amber, 3-Green) x x x 44R-008 8 On/Off Latching SmartPlex Switches x x x x x x x x
44W-010 SmartPlex Indicator Lamps (0-Red, 1-Amber, 0-Green) x 44R-009 9 On/Off Latching SmartPlex Switches x x x x x x x x x
44W-011 SmartPlex Indicator Lamps (0-Red, 1-Amber, 1-Green) x x 44R-010 10 On/Off Latching SmartPlex Switches x x x x x x x x x x
44W-012 SmartPlex Indicator Lamps (0-Red, 1-Amber, 2-Green) x x x 44S-998 No On/Off Momentary SmartPlex Switches
44S-001 1 On/Off Momentary SmartPlex Switch x
44W-013 SmartPlex Indicator Lamps (0-Red, 1-Amber, 3-Green) x x x x
44S-002 2 On/Off Momentary SmartPlex Switches x x
44W-020 SmartPlex Indicator Lamps (0-Red, 2-Amber, 0-Green) x x
44S-003 3 On/Off Momentary SmartPlex Switches x x x
44W-021 SmartPlex Indicator Lamps (0-Red, 2-Amber, 1-Green) x x x
44S-004 4 On/Off Momentary SmartPlex Switches x x x x
44W-022 SmartPlex Indicator Lamps (0-Red, 2-Amber, 2-Green) x x x x
44S-005 5 On/Off Momentary SmartPlex Switches x x x x x
44W-023 SmartPlex Indicator Lamps (0-Red, 2-Amber, 3-Green) x x x x x
44T-998 No On/Off/On Latching SmartPlex Switches
44W-030 SmartPlex Indicator Lamps (0-Red, 3-Amber, 0-Green) x x x
44T-001 1 On/Off/On Latching SmartPlex Switch x
44W-031 SmartPlex Indicator Lamps (0-Red, 3-Amber, 1-Green) x x x x
44T-002 2 On/Off/On Latching SmartPlex Switches x x
44W-032 SmartPlex Indicator Lamps (0-Red, 3-Amber, 2-Green) x x x x x
44T-003 3 On/Off/On Latching SmartPlex Switches x x x
44W-033 SmartPlex Indicator Lamps (0-Red, 3-Amber, 3-Green) x x x x x x 44T-004 4 On/Off/On Latching SmartPlex Switches x x x x
44W-100 SmartPlex Indicator Lamps (1-Red, 0-Amber, 0-Green) x 44T-005 5 On/Off/On Latching SmartPlex Switches x x x x x
44W-101 SmartPlex Indicator Lamps (1-Red, 0-Amber, 1-Green) x x 44U-998 No On/Off/On Momentary SmartPlex Switches
44W-102 SmartPlex Indicator Lamps (1-Red, 0-Amber, 2-Green) x x x 44U-001 1 On/Off/On Momentary SmartPlex Switch x
44W-103 SmartPlex Indicator Lamps (1-Red, 0-Amber, 3-Green) x x x x 44U-002 2 On/Off/On Momentary SmartPlex Switches x x
44W-110 SmartPlex Indicator Lamps (1-Red, 1-Amber, 0-Green) x x 44U-003 3 On/Off/On Momentary SmartPlex Switches x x x
44W-111 SmartPlex Indicator Lamps (1-Red, 1-Amber, 1-Green) x x x 44U-004 4 On/Off/On Momentary SmartPlex Switches x x x x
44W-112 SmartPlex Indicator Lamps (1-Red, 1-Amber, 2-Green) x x x x 44U-005 5 On/Off/On Momentary SmartPlex Switches x x x x x
44W-113 SmartPlex Indicator Lamps (1-Red, 1-Amber, 3-Green) x x x x x
44W-120 SmartPlex Indicator Lamps (1-Red, 2-Amber, 0-Green) x x x
44W-121 SmartPlex Indicator Lamps (1-Red, 2-Amber, 1-Green) x x x x
44W-122 SmartPlex Indicator Lamps (1-Red, 2-Amber, 2-Green) x x x x x
44W-123 SmartPlex Indicator Lamps (1-Red, 2-Amber, 3-Green) x x x x x x
44W-130 SmartPlex Indicator Lamps (1-Red, 3-Amber, 0-Green) x x x x
44W-131 SmartPlex Indicator Lamps (1-Red, 3-Amber, 1-Green) x x x x x
44W-132 SmartPlex Indicator Lamps (1-Red, 3-Amber, 2-Green) x x x x x x Rev - B

Page 45
SmartPlex Schematic Dash

SmartPlex Electrical System

SmartPlex Schematic Overhead

Rev - B

Page 46
SmartPlex Schematic Backwall SmartPlex Electrical System

Rev - B

Page 47

S-ar putea să vă placă și