Documente Academic
Documente Profesional
Documente Cultură
MANUAL
This service manual describes the latest service information NEVER connect the transceiver to an AC outlet or to a DC
for the IC-M45/IC-M45EURO VHF MARINE TRANSCEIVER power supply that uses more than 16 V. This will ruin the
at the time of publication. transceiver.
2 versions of the IC-M45/IC-M45EURO have been designed. DO NOT expose the transceiver to rain, snow or any liquids.
This service manual covers each version. DO NOT reverse the polarities of the power supply when
connecting the transceiver.
MODEL VERSION COLOR SYNBOL DO NOT apply an RF signal of more than 20 dBm (100mW)
U.S.A. U-Black to the antenna connector. This could damage the trans-
IC-M45 USA
U.S.A.-1 U-White ceiver's front end.
ITA E-White
IC-M45EURO EUR
FRA E-Black
Be sure to include the following four points when ordering 1. Make sure a problem is internal before disassembling
replacement parts: the transceiver.
1. 10-digit order numbers 2. DO NOT open the transceiver until the transceiver is dis-
2. Component part number and name connected from its power source.
3. Equipment model name and unit name 3. DO NOT force any of the variable components. Turn
4. Quantity required them slowly and smoothly.
4. DO NOT short any circuits or electronic parts. An insulat-
<SAMPLE ORDER> ed turning tool MUST be used for all adjustments.
5. DO NOT keep power ON for a long time when the trans-
1110003490 S.IC TA31136FN IC-M45 MAIN UNIT 5 pieces ceiver is defective.
8810008660 Screw PH BO M3x8 NI IC-M45 Chassis 10 pieces 6. DO NOT transmit power into a signal generator or a
sweep generator.
Addresses are provided on the inside back cover for your 7. ALWAYS connect a 40 dB to 50 dB attenuator between
convenience. the transceiver and a deviation meter or spectrum ana-
lyzer when using such test equipment.
8. READ the instructions of test equipment thoroughly
before connecting equipment to the transceiver.
SECTION 1 SPECIFICATIONS
VHF MARINE CHANNEL LIST . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-2
‘ GENERAL
• Frequency coverage : 156.025–157.425 MHz (Tx)
156.025–163.275 MHz (Rx)
• Mode : 16K0G3E (FM)
• Usable channels :
Channel
Model Version INT USA CAN WX
[USA]
IC-M45
[USA-1]
[ITA]
IC-M45EURO
[FRA]
‘ TRANSMITTER
• Output power (at 13.8 V DC) : High 25 W
Low 1W
• Modulation : Variable reactance frequency modulation
• Maximum frequency deviation : ±5.0 kHz
• Spurious emissions : 70 dB
• Adjacent channel power : 60 dB
• Residual modulation : 40 dB
• Audio harmonic distortion : Less than 10% at 70% deviation
• Audio frequency response : +1 dB to –3 dB of 6 dB octave from 300 Hz to 3000 Hz
‘ RECEIVER
• Receive system : Double conversion superheterodyne system
• Intermediate frequencies : 1st 30.85 MHz
2nd 450 kHz
• Sensitivity : 0.22 µV typical at 12 dB SINAD
• Squelch sensitivity : 0.22 µV typical
• Adjacent channel selectivity : 70 dB typical
• Spurious response : 70 dB typical
• Intermodulation rejection ratio : 70 dB typical
• Hum and noise : 40 dB
• Audio output power (at 13.8 V DC) : 4.0 W typical at 10% distortion with an 4 Ω load
• Audio frequency responce : +2 dB to –8 dB of –6 dB octave from 300 Hz to 3000 Hz
1-1
Downloaded from www.Manualslib.com manuals search engine
‘ VHF MARINE CHANNEL LIST
Channel No. Frequency (MHz) Channel No. Frequency (MHz) Channel No. Frequency (MHz)
USA INT CAN Transmit Receive USA INT CAN Transmit Receive USA INT CAN Transmit Receive
01 01 156.050 160.650 21A 21A 157.050 157.050 73 73 73 156.675 156.675
01A 156.050 156.050 22 157.100 161.700 74 74 74 156.725 156.725
02 02 156.100 160.700 22A 22A 157.100 157.100 77*1 77 77*1 156.875 156.875
03 03 156.150 160.750 23 23 157.150 161.750 78 156.925 161.525
03A 156.150 156.150 23A 157.150 157.150 78A 78A 156.925 156.925
04 156.200 160.800 24 24 24 157.200 161.800 79 156.975 161.575
04A 156.200 156.200 25 25 25 157.250 161.850 79A 79A 156.975 156.975
05 156.250 160.850 26 26 26 157.300 161.900 80 157.025 161.625
05A 05A 156.250 156.250 27 27 27 157.350 161.950 80A 80A 157.025 157.025
06 06 06 156.300 156.300 28 28 28 157.400 162.000 81 157.075 161.675
07 156.350 160.950 60 60 156.025 160.625 81A 81A 157.075 157.075
07A 07A 156.350 156.350 61 156.075 160.675 82 157.125 161.725
08 08 08 156.400 156.400 61A 61A 156.075 156.075 82A 82A 157.125 157.125
09 09 09 156.450 156.450 62 156.125 160.725 83 83 157.175 161.775
10 10 10 156.500 156.500 62A 156.125 156.125 83A 83A 157.175 157.175
11 11 11 156.550 156.550 63 156.175 160.775 84 84 84 157.225 161.825
12 12 12 156.600 156.600 63A 156.175 156.175 84A 157.225 157.225
13*2 13 13*1 156.650 156.650 64 64 156.225 160.825 85 85 85 157.275 161.875
14 14 14 156.700 156.700 64A 64A 156.225 156.225 85A 157.275 157.275
15*2 15*1 15*1 156.750 156.750 65 156.275 160.875 86 86 86 157.325 161.925
16 16 16 156.800 156.800 65A 65A 65A 156.275 156.275 86A 157.325 157.325
17*1 17 17*1 156.850 156.850 66 156.325 160.925 87 87 87 157.375 161.975
18 156.900 161.500 66A 66A 66A* 1
156.325 156.325 87A 157.375 157.375
18A 18A 156.900 156.900 67*2 67 67 156.375 156.375 88 88 88 157.425 162.025
19 156.950 161.550 68 68 68 156.425 156.425 88A 157.425 157.425
19A 19A 156.950 156.950 69 69 69 156.475 156.475
20 20 20 157.000 161.600 70*3 70*3 70*3 156.525 156.525
20A 157.000 157.000 71 71 71 156.575 156.575
21 21 157.050 161.650 72 72 72 156.625 156.625
*1 Low power only, *2 Momentary high power, *3 Receive only
NOTE: Channels 3, 21, 23, 61, 64, 81, 82 and 83 CANNOT be used by the general public in USA waters.
‘ WX CHANNEL LIST
Weather Frequency (MHz) Weather Frequency (MHz)
channel Transmit Receive channel Transmit Receive
WX01 Receive only 162.550 WX06 Receive only 162.500
WX02 Receive only 162.400 WX07 Receive only 162.525
WX03 Receive only 162.475 WX08 Receive only 161.650
WX04 Receive only 162.425 WX09 Receive only 161.775
WX05 Receive only 162.450 WX10 Receive only 163.275
1-2
Downloaded from www.Manualslib.com manuals search engine
SECTION 2 DISASSEMBLY INSTRUCTIONS
C B
2-1
FM X1
detector 15.2 MHz
IC1 TA31136F
9 10 11 13 16
AF signal "DET" C42 1st IF (30.85 MHz)
R25 from Q3
C51 C50 R23 X2 "SQL" signal to the CPU pin 22
R5
R22
3-1
Downloaded from www.Manualslib.com manuals search engine
3-1-6 SQUELCH CIRCUIT 3-2-2 MODULATION CIRCUIT
A squelch circuit cuts out AF signals when no RF signals are The modulation circuit modulates the VCO oscillating signal
received. By detecting noise components in the AF signals, (RF signal) using the microphone audio signals.
the squelch circuit switches the AF mute switch.
Audio signals from the splatter filter (IC6b) pass through the
A portion of the AF signals from the FM IF IC (IC1, pin 9) frequency deviation adjustment pot (R130) and are then
pass through the [SQUELCH] control pot, and are then applied to the modulation circuit (D7) to change the reac-
applied to the active filter section (IC1, pin 8). The active fil- tance of D7, and modulate the oscillated signal at the TX-
ter section amplifies and filters noise components. The fil- VCO (Q4).
tered signals are applied to the noise detector section and
output from pin 13 as the “SQL” signal. The “SQL” signal is
applied to the CPU (LOGIC unit; IC1, pin 22). The CPU ana- 3-2-3 DRIVE AMPLIFIER CIRCUIT
lyzes the noise condition and outputs the RMUT signal via The drive amplifier circuit amplifies the VCO oscillating sig-
the I/O expander IC (IC7) to toggle the analog switches (IC5, nal to a level needed at the power amplifier.
pins 4, 3) as an AF mute switch.
The VCO output is buffer-amplified by Q7 and Q9, and is
then applied to the T/R switch (D9). The transmit signal from
3-1-7 WEATHER ALERT DECODER CIRCUIT the T/R switch is amplified to the pre-drive (Q10) and drive
[USA version only] (Q11) amplifiers to obtain an approximate 400 mW signal
When the weather alert function is activated and a 1050 Hz level. The amplified signal is then applied to the RF power
alert tone from an NOAA weather radio broadcast is amplifier (IC2).
received, the IC-M45 emits beep tones and indicates flash-
ing “ALT” on the display to inform of an emergency weather
report on the air. 3-2-4 POWER AMPLIFIER CIRCUIT
The power amplifier circuit amplifies the driver signal to an
AF signals from the FM IF IC (IC1, pin 9) are applied to the output power level.
tone decoder (IC10, pin 3). When a 1050 Hz signal is detect-
ed, the tone decoder outputs a low level signal from pin 8 IC2 is a power module which has amplification output capa-
and the output signals are applied to the CPU (LOGIC unit; bilities of about 35 W. The output from IC2 (pin 4) is passed
IC1) to control beep tones and the “ALT” indicator. through the antenna switching circuit (D13) and is then
applied to the antenna connector via the low-pass filter.
The amplified signals are applied to the IDC amplifier (IC6a, The reflected power from the antenna connector is detected
pin 2) via the analog switch (IC5, pins 8, 9) and are passed at D12 and is then applied to the CPU. The detected voltage
through the splatter filter (IC6b) to suppress unwanted 3 kHz increases when the antenna is mismatched, causing the
or higher signals. The filtered signals are then applied to the output power to be switched from High to Low to protect the
modulation circuit. power module (IC2).
• APC CIRCUIT
3-2
Downloaded from www.Manualslib.com manuals search engine
3-3 PLL CIRCUITS The phase detector compares the input signal with a refer-
3-3-1 GENERAL ence frequency, and then outputs the out-of-phase signal
(pulse-type signal) from pin 13.
The PLL circuit provides stable oscillation of the transmit fre-
quency and receive 1st LO frequency. The PLL circuit com-
The pulse-type signal is converted into DC voltage (lock
pares the phase of the divided VCO frequency to the refer-
voltage) at the loop filter (R34, R37, R38, C64, C73), and
ence frequency. The PLL output frequency is controlled by a
then applied to varactor diode (D8) of the RX-VCO to stabi-
crystal oscillator and the divided ratio of the programmable
lize the oscillated frequency. The lockvoltage is also used for
divider. IC3 is a dual PLL IC which controls both VCO cir-
the receiver circuit for the bandpass filter center frequency.
cuits for Tx and Rx.
The lock voltage from the loop filter is amplified at the buffer-
amplifier (Q6) and then applied to the RF circuit.
The PLL circuit , using a one chip PLL IC (IC3), directly gen-
erates the transmit frequency and receive 1st IF frequency
with VCOs. The PLL sets the divided ratio based on serial
data from the CPU on the LOGIC unit and compares the 3-3-4 VCO CIRCUIT
phases of VCO signals with the reference oscillator fre- The VCO outputs from Q4 (Tx) and Q5 (Rx) are buffer-
quency. The PLL IC detects the out-of-step phase and out- amplified at Q7 and Q9, and are then sent to the T/R switch
put from pins 8 and 13 for Tx and Rx, respectively. The ref- (D9). The receive LO signal is applied to the 1st mixer circuit
erence frequency (15.2 MHz) is oscillated at X1. (Q2) through a low-pass filter, and the transmit signal is
applied to the pre-drive amplifier (Q10). A portion of the VCO
output is reapplied to the PLL IC (IC10, pin 2 or pin 13) via
3-3-2 TX LOOP Q8.
The generated signal at the TX-VCO (Q4, D6, D7) enters
the PLL IC (IC3, pin 2) and is divided at the programmable
divider section and is then applied to the phase detector
section. 3-4 POWER SUPPLY CIRCUITS
LINE DESCRIPTION
The phase detector compares the input signal with a refer-
ence frequency, and then outputs the out-of-phase signal The voltage from the connected DC power sup-
HV
(pulse-type signal) from pin 8. ply.
Same voltage as the HV line which is passed
The pulse-type signal is converted into DC voltage (lock HVS
through the [PWR] switch (VR-A unit; R1).
voltage) at the loop filter (R41–R43, C75–C77), and then
applied to varactor diodes (D6, D7) of the TX-VCO to stabi- Common 5 V converted from the HVS line at the
5V
lize the oscillated frequency. 5V regulator circuit (IC8).
Receive 5 V converted from the 5V line at the R5
R5 regulator circuit (Q19, Q20). The regulated volt-
3-3-3 RX LOOP age is applied to the receiver circuits.
The generated signal at the RX-VCO (Q5, D8) enters the
PLL IC (IC3, pin 19) and is divided at the programmable Transmit 5 V converted from the 5V line at the T5
T5
divider section and is then applied to the phase detector regulator circuit (Q17, Q18).
section.
• PLL CIRCUIT
TX VCO Buffer D9
to transmitter circuit
Q9
Buffer to 1st mixer circuit
Q4, D6, D7
Q7
RX VCO Buffer
Q8
Q5, D8
Loop IC3 (PLL IC)
filter
8 Phase Programmable 2
Prescaler
detector counter
30.4 MHz signal 3
to the FM IF IC Programmable P.STB
17 4
×2 Shift register CK
divider 5 DATA
X1 16
15.2 MHz
3-3
Downloaded from www.Manualslib.com manuals search engine
3-5 PORT ALLOCATIONS
3-5-1 CPU (LOGIC unit; IC1) 3-5-2 OUTPUT EXPANDER (MAIN unit; IC7)
Pin Port Pin Port
Description Description
number name number name
Input port for the connected power Outputs the R5 regulator (Q19, Q20)
3 LBATT supply voltage detection (low voltage 4 RCV control signal.
indicator). Low : While receiving
5 PTT.M Input port for the PTT switch. Outputs the T5 regulator (Q17, Q18)
5 SEND control signal.
Input port for the “TX” indicator from
Low : While transmitting
6 TXDET the power detector circuit (Main unit;
D11, D12). Output port fo RF output power (High
11 HI/LO or Low) select signal.
7 SQLV Input port for the squelch volume level.
Low : While low power is selected
Input port for the smart mic functions.
Outputs the reset signal for optional
2.02 V: [UP] is pushed 12 OP.RST
8 KEY.M unit via J5 (MAIN unit).
3.00 V: [DN] is pushed
3.84 V: [HI/LO] is pushed Outputs the analog switch (IC5) con-
13 RMUT trol signal.
10 BEEP Outputs beep audio signals.
Low : While squelched
Outputs strobe signals for the output
13 OEX.STB Outputs transmit mute signal.
expander (MAIN unit; IC7). 14 TMUT
Low : While transmitting
Outputs strobe signals for the PLL cir-
14 P.STB
cuit.
Outputs data signals to the EEPROM
15 DATA (IC4), PLL IC (MAIN unit; IC3) and
expander ICs (MAIN unit; IC7), etc.
Outputs clock signal to the EEPROM
16 CK (IC4), PLL IC (MAIN unit; IC3) and
expander ICs (MAIN unit; IC7), etc.
Input port for the data signals from the
17 ESI
EEPROM (IC4).
Input port from the FM IF IC (MAIN
22 SQL
unit; IC1) for the squelch operation.
Input port for the PLL unlock signal.
23 UNLK
Low : While PLL is locked.
Input port for the weather alert tone
decode signal.
24 TONE
Low : Weather alert tone (1050 Hz)
is detected.
LAMP2, Outputs LCD backlight control signal.
26, 27
LAMP1 High : While LCD backlight is ON.
Input port for the microphone hanger
31 HANG detection signal.
Low : Microphone on hook
33 DOWN Input port for the [DOWN] switch.
34 UP Input port for the [UP] switch.
35 H/L Input port for the [H/L] switch.
36 SCAN Input port for the [SCAN] switch.
37 CH/WX Input port for the [CH/WX] switch.
38 CH16/9 Input port for the [16/9] switch.
3-4
Downloaded from www.Manualslib.com manuals search engine
SECTION 4 ADJUSTMENT PROCEDURES
4-1 PREPARATION
■ REQUIRED TEST EQUIPMENT
EQUIPMENT GRADE AND RANGE EQUIPMENT GRADE AND RANGE
Output voltage : 13.8 V DC Frequency range : 300–3000 Hz
DC power supply Audio generator
Current capacity : 10 A or more Measuring range : 1–500 mV
Measuring range : 1–50 W Frequency range : 0.1–300 MHz
Standard signal
RF power meter Frequency range : 100–300 MHz Output level : 0.1 µV–32 mV
generator (SSG)
(terminated type) Impedance : 50 Ω (–127 to –17 dBm)
SWR : Less than 1.2 : 1
Frequency range : DC–20 MHz
Oscilloscope
Frequency range : 0.1–300 MHz Measuring range : 0.01–20 V
Frequency counter Frequency accuracy : ±1 ppm or better
Sensitivity : 100 mV or better AC millivoltmeter Measuring range : 10 mV–10 V
‘ CONNECTIONS
+
RF power meter DC power supply
— 13.8 V /15 A
50 ‰ / 1—50 W
Frequency
counter to DC cable
FM deviation
meter
Red Black
Attenuator
40 dB or 50 dB
4-1
Downloaded from www.Manualslib.com manuals search engine
4-2 PLL ADJUSTMENTS
ADJUSTMENT
MEASUREMENT
ADJUSTMENT ADJUSTMENT CONDITION VALUE POINT
UNIT LOCATION UNIT ADJUST
LOCK 1 • Operating channel : ch16 MAIN Connect a digital 2.6 V MAIN L13
VOLTAGE • Receiving multi-meter or oscil-
loscope to the
check point CP1.
2 • Operating channel : ch16 Connect a digital 2.8 V L12
• Output power : Low multi-meter or oscil-
• Transmitting loscope to the
check point CP2.
REFERENCE 1 • Operating channel : ch16 Rear Loosely couple the 156.8000 MHz MAIN C117
FREQUENCY • Output power : Low Panel frequency counter
• Connect an RF power meter or a to the antenna con-
50 Ω dummy load to the antenna nector.
connector.
• Transmitting
4-2
Downloaded from www.Manualslib.com manuals search engine
+ DC power supply
– 13.8 V /15 A
to DC cable
Red Black
C117
Reference frequency
adjustment CP1 PLL lock voltage
check point for [RX]
CP3 Sensitivity
check point
y
Audio generator + t
300 Hz to 3 kHz – [PTT]
r
AC millivoltmeter
2–200 mV
4-3
Downloaded from www.Manualslib.com manuals search engine
SECTION 5 PARTS LIST
5-1
Downloaded from www.Manualslib.com manuals search engine
[MAIN UNIT] [MAIN UNIT]
REF ORDER REF ORDER
NO. NO. DESCRIPTION DESCRIPTION
NO. NO.
Q8 1530002600 S.TRANSISTOR 2SC4215-O (TE85R) R6 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
Q9 1530002600 S.TRANSISTOR 2SC4215-O (TE85R) R7 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)
Q10 1530002240 S.TRANSISTOR 2SC3775-3-TB R8 7030003790 S.RESISTOR ERJ3GEYJ 824 V (820 kΩ)
Q11 1530002340 S.TRANSISTOR 2SC2954-T2B R9 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ)
Q12 1520000380 TRANSISTOR 2SB1143 S R10 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
Q13 1590000670 S.TRANSISTOR FMW1 T148 R11 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
Q14 1590000420 S.TRANSISTOR RN1404 (TE85R) R12 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω)
Q15 1590000420 S.TRANSISTOR RN1404 (TE85R) R13 7030003420 S.RESISTOR ERJ3GEYJ 681 V (680 Ω)
Q16 1590000460 S.TRANSISTOR RN1402 (TE85R) R14 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω)
Q17 1590000420 S.TRANSISTOR RN1404 (TE85R) R15 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ)
Q18 1520000460 S.TRANSISTOR 2SB1132 T100 R R17 7030003410 S.RESISTOR ERJ3GEYJ 561 V (560 Ω)
Q19 1590000420 S.TRANSISTOR RN1404 (TE85R) R18 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ)
Q20 1520000460 S.TRANSISTOR 2SB1132 T100 R R19 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
Q21 1530000160 S.TRANSISTOR 2SC2712-Y (TE85RTEM) R20 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)
Q22 1530000160 S.TRANSISTOR 2SC2712-Y (TE85RTEM) R21 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ)
Q23 1540000550 S.TRANSISTOR 2SD1664 T100Q R22 7030003390 S.RESISTOR ERJ3GEYJ 391 V (390 Ω)
Q24 1590001190 S.TRANSISTOR XP6501-(TX) .AB [USA] only R23 7030003450 S.RESISTOR ERJ3GEYJ 122 V (1.2 kΩ)
Q25 1520000460 S.TRANSISTOR 2SB1132 T100 R [USA] only R24 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R25 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)
R26 7030003690 S.RESISTOR ERJ3GEYJ 124 V (120 kΩ)
D1 1710001080 DIODE XB15A308 R27 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ)
D2 1720000370 S.VARICAP HVU350TRF R28 7030003490 S.RESISTOR ERJ3GEYJ 272 V (2.7 kΩ)
D3 1720000370 S.VARICAP HVU350TRF R29 7030003610 S.RESISTOR ERJ3GEYJ 273 V (27 kΩ)
D4 1720000370 S.VARICAP HVU350TRF R30 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
D5 1750000470 S.DIODE 1SS321 (TE85R) R31 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω)
D6 1790000640 S.VARICAP MA363B (TX) R32 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω)
D7 1790000640 S.VARICAP MA363B (TX) R33 7030003310 S.RESISTOR ERJ3GEYJ 820 V (82 Ω)
D8 1790000640 S.VARICAP MA363B (TX) R34 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
D9 1790000450 S.DIODE MA862 (TX) R35 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
D10 1750000060 S.DIODE 1SS196 (TE85R) R36 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
D11 1790000690 S.DIODE HSM88ASR-TR R37 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
D12 1790000690 S.DIODE HSM88ASR-TR R38 7030003590 S.RESISTOR ERJ3GEYJ 183 V (18 kΩ)
D13 1710000290 DIODE MI308 R39 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
D14 1750000060 S.DIODE 1SS196 (TE85R) [EUR] only R40 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)
D15 1730000730 S.ZENER RD6.2M-T2B2 [EUR] only R41 7030003410 S.RESISTOR ERJ3GEYJ 561 V (560 Ω)
D16 1750000070 S.DIODE 1SS226 (TE85R) R42 7030003550 S.RESISTOR ERJ3GEYJ 822 V (8.2 kΩ)
D17 1790000700 DIODE DSA3A1 R43 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
D18 1790000640 S.VARICAP MA363B (TX) R44 7030003380 S.RESISTOR ERJ3GEYJ 331 V (330 Ω)
D19 1790000640 S.VARICAP MA363B (TX) R45 7030003380 S.RESISTOR ERJ3GEYJ 331 V (330 Ω)
R46 7030003420 S.RESISTOR ERJ3GEYJ 681 V (680 Ω)
R47 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ)
FI1 2010001610 MONOLITH FL-202 (30.850 MHz) R48 7030003420 S.RESISTOR ERJ3GEYJ 681 V (680 Ω)
FI2 2020001210 CERAMIC CFWS450E R49 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ)
R50 7030003390 S.RESISTOR ERJ3GEYJ 391 V (390 Ω)
R51 7030003630 S.RESISTOR ERJ3GEYJ 393 V (39 kΩ)
X1 6050009640 XTAL CR-528 (15.2 MHz) R52 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
X2 6070000210 S.DISCRIMINATOR CDBCA450CX24 R53 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)
R54 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)
R55 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ)
L1 6110001670 COIL LA-253 R56 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)
L2 6110001600 COIL LA-243 R57 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)
L3 6110001130 COIL LA-149 R58 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)
L4 6110001600 COIL LA-243 R59 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω)
L5 6150004360 S.COIL LS-491 R60 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
L6 6150004360 S.COIL LS-491 R61 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)
L7 6150004360 S.COIL LS-491 R62 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
L8 6200004790 S.COIL MLF1608D R47K-T R63 7030003220 S.RESISTOR ERJ3GEYJ 150 V (15 Ω)
L9 6200002430 S.COIL NL 252018T-082J R64 7030003220 S.RESISTOR ERJ3GEYJ 150 V (15 Ω)
L10 6200003320 S.COIL NL 322522T-3R3J-3 R65 7030000240 S.RESISTOR MCR10EZHJ 68 Ω (680)
L11 6200003100 S.COIL NL 322522T-3R9J-3 R66 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ)
L12 6130002370 S.COIL LB-258 R67 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ)
L13 6130002360 S.COIL LB-257 R68 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
L14 6200003090 S.COIL NL 322522T-2R7J-3 R69 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ)
L15 6200003090 S.COIL NL 322522T-2R7J-3 R70 7310002740 S.TRIMMER RV-150 (RH03A3A14X0FC) 103
L16 6200004700 S.COIL MLR1608M R10K-T R71 7310002670 S.TRIMMER RV-143 (RH03A3AS2) 471
L17 6200004700 S.COIL MLR1608M R10K-T R72 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
L18 6200004700 S.COIL MLR1608M R10K-T R73 7030003360 S.RESISTOR ERJ3GEYJ 221 V (220 Ω)
L19 6200002430 S.COIL NL 252018T-082J R74 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ)
L20 6200002430 S.COIL NL 252018T-082J R75 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 kΩ)
L21 6170000230 COIL LW-25 R76 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
L22 6110001600 COIL LA-243 R77 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)
L23 6200004660 S.COIL MLF1608A 1R8K-T R78 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)
L24 6200004660 S.COIL MLF1608A 1R8K-T R79 7410000990 S.ARRAY EXB-V8V 470JV
L25 6110001580 COIL LA-238 R80 7410000990 S.ARRAY EXB-V8V 470JV
L26 6200002600 S.COIL NL 252018T-047J R81 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω)
R82 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω)
R83 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω)
R1 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω) R84 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)
R2 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) R85 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)
R3 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ) R86 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)
R4 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ) R87 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)
R5 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ) R88 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
5-2
Downloaded from www.Manualslib.com manuals search engine
[MAIN UNIT] [MAIN UNIT]
REF ORDER REF ORDER
NO. NO. DESCRIPTION DESCRIPTION
NO. NO.
R89 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) C9 4030011190 S.CERAMIC GRM42-6 CH 270J 500PT
R90 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) C10 4030007010 S.CERAMIC C1608 CH 1H 100D-T-A
R91 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) C11 4030011220 S.CERAMIC GRM42-6 CH 360J 500PT
R92 7030003550 S.RESISTOR ERJ3GEYJ 822 V (8.2 kΩ) C12 4030006970 S.CERAMIC C1608 CH 1H 060D-T-A
R93 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) C13 4030009510 S.CERAMIC C1608 CH 1H 010B-T-A
R94 7030003770 S.RESISTOR ERJ3GEYJ 564 V (560 kΩ) C14 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
R95 7030003710 S.RESISTOR ERJ3GEYJ 184 V (180 kΩ) C15 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
R96 7030003490 S.RESISTOR ERJ3GEYJ 272 V (2.7 kΩ) C16 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
R97 7030003380 S.RESISTOR ERJ3GEYJ 331 V (330 Ω) C17 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
R98 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ) C18 4030009920 S.CERAMIC C1608 CH 1H 050B-T-A
R99 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ) C19 4030006970 S.CERAMIC C1608 CH 1H 060D-T-A
R100 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) C20 4030009570 S.CERAMIC C1608 CH 1H 0R3B-T-A
R101 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) C21 4030006970 S.CERAMIC C1608 CH 1H 060D-T-A
R102 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) C22 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
R103 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) C23 4030009510 S.CERAMIC C1608 CH 1H 010B-T-A
R104 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) C24 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
R105 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 kΩ) C25 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
R106 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ) C26 4030006960 S.CERAMIC C1608 CH 1H 050C-T-A
R107 7030003740 S.RESISTOR ERJ3GEYJ 334 V (330 kΩ) C28 4030006980 S.CERAMIC C1608 CH 1H 070D-T-A
R108 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) C29 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
R109 7030000100 S.RESISTOR MCR10EZHJ 4.7 Ω (4R7) C30 4030007110 S.CERAMIC C1608 CH 1H 680J-T-A
R111 7030003490 S.RESISTOR ERJ3GEYJ 272 V (2.7 kΩ) C31 4030008880 S.CERAMIC C1608 JB 1C 223K-T-A
R112 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) C32 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
R113 7030003730 S.RESISTOR ERJ3GEYJ 274 V (270 kΩ) C33 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
R114 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) C34 4030008880 S.CERAMIC C1608 JB 1C 223K-T-A
R115 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) [USA] C35 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
7030003690 S.RESISTOR ERJ3GEYJ 124 V (120 kΩ) [EUR] C36 4030007010 S.CERAMIC C1608 CH 1H 100D-T-A
R116 7030003590 S.RESISTOR ERJ3GEYJ 183 V (18 kΩ) C37 4030009660 S.CERAMIC C1608 JF 1C 224Z-T-A
R117 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ) C38 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
R118 7030003670 S.RESISTOR ERJ3GEYJ 823 V (82 kΩ) C39 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
R119 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) C40 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
R120 7030003740 S.RESISTOR ERJ3GEYJ 334 V (330 kΩ) C41 4030008920 S.CERAMIC C1608 JB 1C 473K-T-A
R122 7030003670 S.RESISTOR ERJ3GEYJ 823 V (82 kΩ) C42 4030007130 S.CERAMIC C1608 CH 1H 101J-T-A
R123 7030003700 S.RESISTOR ERJ3GEYJ 154 V (150 kΩ) C43 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
R124 7030003670 S.RESISTOR ERJ3GEYJ 823 V (82 kΩ) C44 4510004630 S.ELECTROLYTIC ECEV1CA100SR
R125 7030003670 S.RESISTOR ERJ3GEYJ 823 V (82 kΩ) C45 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
R126 7030003630 S.RESISTOR ERJ3GEYJ 393 V (39 kΩ) C46 4030008680 S.CERAMIC C2012 JF 1C 105Z-T-A
R127 7510000750 S.THERMISTOR NTCCS2012 3NH 103KC-T C47 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
R128 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ) C50 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
R129 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ) C51 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
R130 7310002600 S.TRIMMER RV-110 (RH03A3AS4X0AA) 473 C52 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
R131 7030003550 S.RESISTOR ERJ3GEYJ 822 V (8.2 kΩ) C53 4030007170 S.CERAMIC C1608 CH 1H 221J-T-A
R132 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ) C54 4030007170 S.CERAMIC C1608 CH 1H 221J-T-A
R133 7030003630 S.RESISTOR ERJ3GEYJ 393 V (39 kΩ) C55 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
R134 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) C56 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
R135 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) C57 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
[USA] only C58 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
R136 7030003840 S.RESISTOR ERJ3GEYJ 225 V (2.2 MΩ) C59 4550006250 S.TANTALUM TEMSVA 1A 106M-8L
[USA] only C61 4030009510 S.CERAMIC C1608 CH 1H 010B-T-A
R137 7030007590 S.RESISTOR RR0816R-433-D (43 kΩ) C62 4030009910 S.CERAMIC C1608 CH 1H 040B-T-A
[USA] only C63 4030009530 S.CERAMIC C1608 CH 1H 030B-T-A
R138 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) C64 4030009500 S.CERAMIC C1608 CH 1H 0R5B-T-A
R139 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) C65 4030008920 S.CERAMIC C1608 JB 1C 473K-T-A
R140 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) C67 4030009520 S.CERAMIC C1608 CH 1H 020B-T-A
R141 7030000240 S.RESISTOR MCR10EZHJ 68 Ω (680) C68 4030009910 S.CERAMIC C1608 CH 1H 040B-T-A
R142 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) C69 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
R143 7030001070 S.RESISTOR MCR50JZHJ 33 Ω (330) C70 4550006250 S.TANTALUM TEMSVA 1A 106M-8L
R144 7030003540 S.RESISTOR ERJ3GEYJ 682 V (6.8 kΩ) C71 4030009560 S.CERAMIC C1608 CH 1H R75B-T-A
R145 7030003590 S.RESISTOR ERJ3GEYJ 183 V (18 kΩ) C72 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
R146 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω) C73 4030008920 S.CERAMIC C1608 JB 1C 473K-T-A
R147 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω) C74 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
R148 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω) C75 4550000730 S.TANTALUM TESVA 0J 225M1-8L
R149 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω) C76 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
R150 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω) C77 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
R151 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω) C78 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
R152 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) C79 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
[USA] only C80 4030009920 S.CERAMIC C1608 CH 1H 050B-T-A
R153 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) C81 4030009990 S.CERAMIC C1608 CH 1H 200J-T-A
[USA] only C82 4030007020 S.CERAMIC C1608 CH 1H 120J-T-A
R154 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω) C83 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
R155 7030003300 S.RESISTOR ERJ3GEYJ 680 V (68 Ω) C84 4030007040 S.CERAMIC C1608 CH 1H 180J-T-A
R156 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) C85 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
R157 7030003410 S.RESISTOR ERJ3GEYJ 561 V (560 Ω) C86 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C87 4030007010 S.CERAMIC C1608 CH 1H 100D-T-A
C88 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C1 4030011160 S.CERAMIC GRM42-6 CH 150J 500PT C89 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C2 4030011110 S.CERAMIC GRM42-6 CH 090D 500PT C90 4030007040 S.CERAMIC C1608 CH 1H 180J-T-A
C3 4030011290 S.CERAMIC GRM42-6 CH 240J 500PT C91 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C4 4030011070 S.CERAMIC GRM42-6 CH 050C 500PT C92 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C5 4030011160 S.CERAMIC GRM42-6 CH 150J 500PT C93 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C7 4030011100 S.CERAMIC GRM42-6 CH 080D 500PT C94 4030007020 S.CERAMIC C1608 CH 1H 120J-T-A
C8 4030011260 S.CERAMIC GRM42-6 W5R 102K 500PT C95 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
5-3
Downloaded from www.Manualslib.com manuals search engine
[MAIN UNIT] [MAIN UNIT]
REF ORDER REF ORDER
NO. NO. DESCRIPTION DESCRIPTION
NO. NO.
C96 4550002830 S.TANTALUM TESVD2 1V 685M-12R C179 4030008890 S.CERAMIC C1608 JB 1C 273K-T-A
C97 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A C180 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
C98 4510004590 ELECTROLYTIC 16 MV 470 HC C181 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
C99 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A C182 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
C100 4030011290 S.CERAMIC GRM42-6 CH 240J 500PT C183 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
C101 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A C184 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
C102 4030011170 S.CERAMIC GRM42-6 CH 180J 500PT C185 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
C103 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A C186 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
C104 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A C187 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
C105 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A C188 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
C106 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A C189 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
C107 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A C190 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
C108 4030006850 S.CERAMIC C1608 JB 1H 471K-T-A C191 4510005900 S.ELECTROLYTIC ECEV0GA101SR
C109 4510004440 S.ELECTROLYTIC ECEV1HA010SR C192 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
C110 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A C193 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
C111 4030008880 S.CERAMIC C1608 JB 1C 223K-T-A C194 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
C112 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A C195 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
C113 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A C196 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
C114 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A C197 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
C115 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A C198 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A [USA] only
C116 4030007030 S.CERAMIC C1608 CH 1H 150J-T-A C199 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
C117 4610002150 S.TRIMMER CTZ3S-10A-W1-AF C200 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
C118 4030007070 S.CERAMIC C1608 CH 1H 330J-T-A C201 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
C119 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A C202 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
C120 4030009910 S.CERAMIC C1608 CH 1H 040B-T-A C203 4030006980 S.CERAMIC C1608 CH 1H 070D-T-A
C121 4030006990 S.CERAMIC C1608 CH 1H 080D-T-A C204 4030009500 S.CERAMIC C1608 CH 1H 0R5B-T-A
C122 4030009520 S.CERAMIC C1608 CH 1H 020B-T-A C205 4030009910 S.CERAMIC C1608 CH 1H 040B-T-A
C123 4030006980 S.CERAMIC C1608 CH 1H 070D-T-A C206 4030006990 S.CERAMIC C1608 CH 1H 080D-T-A
C124 4030009530 S.CERAMIC C1608 CH 1H 030B-T-A
C125 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C126 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A J1 6510019420 S.CONNECTOR B8B-ZR-SM3-TF
C127 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A J2 6510003430 CONNECTOR B07B-EH-S
C128 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A J3 6450001060 CONNECTOR HSJ1493-01-010
C129 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A J4 6510019070 S.CONNECTOR 52559-3092
C130 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A J5 6510019250 S.CONNECTOR B11B-ZR-SM3-TF
C131 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C132 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A [EUR] only
C133 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A W1 7120000470 JUMPER ERDS2T0
C134 4030008770 S.CERAMIC C1608 JB 1H 562K-T-A W2 7120000470 JUMPER ERDS2T0
C135 4550000510 S.TANTALUM TESVA 1V 473M1-8L
C136 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
C137 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A EP1 0910049084 PCB B 5034D
C138 4030008650 S.CERAMIC C1608 JB 1H 332K-T-A EP2 9040902902 TUBE IRRAX 0.7 (d) L=2 mm
C139 4030007110 S.CERAMIC C1608 CH 1H 680J-T-A
C140 4030008470 S.CERAMIC C1608 JB 1H 272K-T-A
C141 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
C142 4510004630 S.ELECTROLYTIC ECEV1CA100SR
C143 4510004630 S.ELECTROLYTIC ECEV1CA100SR
C144 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A
C145 4510004630 S.ELECTROLYTIC ECEV1CA100SR
C146 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
C147 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
C148 4510005320 S.ELECTROLYTIC ECEV0JA101SP
C149 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C150 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C151 4030008680 S.CERAMIC C2012 JF 1C 105Z-T-A
C152 4550006130 S.TANTALUM ECST1VY224R
C153 4030008890 S.CERAMIC C1608 JB 1C 273K-T-A
C154 4030006870 S.CERAMIC C1608 JB 1H 222K-T-A
C155 4030009490 S.CERAMIC C1608 JB 1H 821K-T-A
C156 4510004630 S.ELECTROLYTIC ECEV1CA100SR
C157 4550006150 S.TANTALUM ECST1CY105R
C158 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C159 4550006130 S.TANTALUM ECST1VY224R
C160 4550006170 S.TANTALUM ECST1AY225R
C161 4550006170 S.TANTALUM ECST1AY225R
C162 4030008920 S.CERAMIC C1608 JB 1C 473K-T-A
C163 4510004590 ELECTROLYTIC 16 MV 470 HC
C164 4510004590 ELECTROLYTIC 16 MV 470 HC
C165 4030008960 S.CERAMIC C2012 JB 1C 104K-T-A
C166 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C167 4510004630 S.ELECTROLYTIC ECEV1CA100SR [USA] only
C168 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A [USA] only
C169 4550006170 S.TANTALUM ECST1AY225R [USA] only
C170 4550006150 S.TANTALUM ECST1CY105R [USA] only
C171 4030008630 S.CERAMIC C1608 JF 1C 104Z-T-A [USA] only
C172 4340000010 S.MYLAR ECWU 1C 223JB5 [USA] only
C174 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C175 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C176 4030011340 S.CERAMIC C1608 CH 1H 471J-T-A
C177 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
C178 4030011730 S.CERAMIC GRM42-6 CH 101J 500PT
5-4
Downloaded from www.Manualslib.com manuals search engine
SECTION 6 MECHANICAL PARTS AND DISASSEMBLY
MP2 8010017264 2040 Chassis-4 1 MP1 8950004140 1632 MIC hanger [U-Black] only 1
MP3 8930045700 2040 IC clip 1 8950004770 1632 MIC hanger (A) [U-White] only 1
MP4 8510011530 2040 Case [U-Black] 1 MP2 8010017250 2040 Mobile bracket [Black] 1
8510011550 2040 Case (A) [U-White] 1 8010017270 2040 Mobile bracket (A) [White] 1
8510011880 2040 Case (B) [E-White] 1 MP3 8610010560 2040 Knob bolt [Black] 2
8510012510 2040 Case (C) [E-Black] 1 8610010590 2040 Knob bolt (A) [White] 2
MP5 8210015210 2040 Front panel [U-Black] 1 MP4 8810001470 Screw PH A0 M3.5x30 SUS 2
8210015260 2040 Front panel (A) [U-White] 1 MP5 8810001490 Screw PH A0 M5x20 SUS 2
8210015510 2040 Front panel (B) [E-White] 1 MP6 8850000180 Flat washer M5 SUS 2
8210016230 2040 Front panel (C) [E-Black] 1 MP7 8850000500 Spring washer M5 SUS 2
MP6 8930045260 2040 6-KEY [USA] 1
8930046650 2040 6-KEY (A) [EUR] 1
MP7 8930045270 2040 R-packing 1
MP8 8930045280 2040 F-packing 1
MP10 8610010550 Knob N-264 [Black] 2
8610010580 Knob N-264 (A) [White] 2 MP4
MP12 8930033470 1542 Jack bush 1
MP13 8930045290 2040 Bush plate 1
MP2 MP1
MP15 8930014280 SP net 1
MP16 8810008630 Screw PH B0 M3x6 NI-ZU (BT) 7 MP5
MP17 8810008660 Screw PH B0 M3x8 NI-ZU (BT) 4
MP18 8810008660 Screw PH B0 M3x8 NI-ZU (BT) 2
MP19 8810004540 Screw BiH M3x8 SUS 2
MP6
MP20 8810004540 Screw BiH M3x8 SUS 4
W1 MP3 MP7
MP21 8810008680 Screw PH M3x8 NI 4
[LOGIC UNIT]
Screw abbreviations A, B0, BT: Self-tapping
REF. NO. ORDER NO. DESCRIPTION QTY. PH: Pan head
DS1 5030001373 LCD LD-HU4549J-1 1 FH: Flat head
DS2 5080000170 Lamp HRS-7219A-Y2 30 1 BiH: Bind head
DS3 5080000170 Lamp HRS-7219A-Y2 30 1 NI: Nickel
SUS: Stainless
W3 8900005320 FFC OPC-519 1
ZK: Black
EP2 8930045650 LCD contact SRCN-2040-SP-N-W 1
[VR-A UNIT]
[VR-B UNIT ]
6-1
MP4 (C)
EP2 (L)
J1 (C) MP19 (C)
LOGIC UNIT
MP2 (L)
MP7 (C)
SP1 (C)
MP21 (C)
DS1 (L)
MP8 (C)
R1 (VB)
VR-A UNIT
VR-B UNIT
MP2 (C)
R1 (VA)
MP12 (C)
MP6 (C)
MP21 (C)
MP3 (C)
MP5 (C)
MAIN UNIT
W3 (L)
MP16 (C)
MP3 (M)
UNIT abbreviation (C): CHASSIS PARTS (L): LOGIC UNIT (M): MAIN UNIT
IC2 (M)
(VA): VR-A UNIT (VB): VR-B UNIT
6-2
B
E C
B
C
E
B D
D S D G1
C C S G S
G D G S G2
E
B E C
C E B
E B C
• DIODES
1SS196 1SS226 1SS272 1SS321 HSM88ASR
(Symbol: G3) (Symbol: C3) (Symbol: A1) (Symbol: F9) (Symbol: C3)
7-1
DS2
SP+
SP—
SP—
GND C20 Q5
C15
BEEP
R25
PTT R19
ICF3 C21 Q4
R26 R18
HANG
R23 R21
TXDET
R20 R24
R22
OEX. OE
P. STB
C10
OEX.STB
R33
TONE
J1
R31
S.METER R32
SQL
C16
C19
PTT. S
UNLK
C4
J2
C3
CK
R30
C13
R3
C14
C12
1 KEY.M DATA R29
GND DATAM
J2
R27
C11
R28
1
DATAS D2
FROM R34
MICROPHONE SQLV C5 R2
BUSY R1
GND
IC1
GND
F. MODE
C9
IC4
HVS
NC
D4
1 5V R16
C18
R17
TO MAIN C8
R15
UNIT J4 Q1
IC3 R8
R7
D1
R9
R12
X1
R14
R11
Q2 C7 R5
IC2
R13
C6
R6
R10 C17
DS3
D3 Q3 R4
C1
C2
SQLV
SQLI
GND
HVS
HV
TO MAIN TO MAIN
UNIT J1 UNIT J1 R1
R1
8-1
8-2
J2
1
SP+
7
SP+ AF2
11
1
SP— GND
UNIT
MIC
J5
SP—
GND GND
5V
DET
DSC
ICF3
GND
HANG
BUSY
PTT.S
RMUT
DATAS
BEEP
DATAM
OP.RST
PTT PTT
1
ICF3 AF1
FROM MICROPHON
FROM OPTIONAL
HANG
TXDET
OEX.OE
P.STB
OEX.STB C161
C160
TONE R85 Q12 IC9
J3
SQL.C
SQL
C163
PTT.S R105
C191
IC5
UNLK C158
C164
DATAS
SQLV C145
C143
BUSY
8-3
GND R133
C167
C146
R114
R118
GND
C135
NC
IC6
C143
IC8
R120
HVS C125
C170
C181
NC C126 R131 R132
R128
5V
30
C169 C147
R130
R127
C140
R126
R129
C168 C142
1
C148
J2
R79
IC7
J4
Q25
1
R137
R80
C144
R136
D17
Q24 J5
C207
L20
C193
1
C194
R64
C92
C93
R62
R63
R61
J1
C91
Q14
8
VOL2
VOL1
GND C150 C149
L19
C89
R100 D10
C96
R60
C157
HVS
C177
C155
J1
C189
C154
Q17
Q20
Q19
HV Q18
Q22
C192
SQLV R99
C156 R91 R89
SQLI R98
R90 R88 C187
C186
C179
1
1
SQLG
Q21
R145 R96 C115
R154 R155
C153 R93 C114 R75
R156
R92 R94 C110
Q15
FROM
R78
R95 R76
C152
IC3
R97
C151
C117 C106
Q13
R22 C47 R73
VR-A UNIT P1
FI2
C98
R72
Q16
C124 C122 C120
R70
C44
X1
L23
L24
C123
C121
R71
C69
W1
D8
L11 C101
D11
R35
L15
R68
R66
Q5
L13
X2
IC1 C105 C104
C68
C71
C65
R34
C205
D19
C67
D12
C70 R32 L22
C81
L10 C58
Q23
R67
L17
C103
L14
C77 L12 Q8 C79
Q4
D6
R33 C204
C202
R43
R41 C64
C62
C61
R140
C63
D7
C203
D18
Q7
R47
R29
R42
C76
C59
D13
C80
R49
L16 R48
C185
FE1B
C56 C188
L3
C197 C82
R50
L9 R51
W2
C28 C84
L18
Q9
C83
C196
L26
C201
L4
FI1A
D1
R12
C32
C31
L7
L6
L5
C20
L8
C30
R13
L1
L2
L25
• BOTTOM VIEW
IC2
RED BLK
C127
C128
C1
C165
C3
R109
C2
C102
C173
C95
C94
C4
C97
C100
C162
C180
C6
R69
C5 C175
C7 C8
C174
C176
C99
R141
C108
C107
R59
C9 R65
R74 R56 C90
R57
C87
C130
Q10
C131
C129
R134
C178
C88
R58
C11
C133
R142
R112
R111
C10
R55 R113
R3 C86 R46
C134
IC4
C141
C12 C78
C16
R54
C183
R144
R116
C132
C13 D14
D2
R115
R53
C85
R2
C199
C14
D15
C15
C118
C116
D9
Q1
R1
C166
R45
R102
C19 C182
C17
C29
R122
C137
R123
R87
C119
D3
C18 R119
R86
R101
R103
R104
C200 R84
R124
R125
R138
C21
R5
D4
C23 R136
C75
C139
C190 C113 C111
C206
C24
C26
R6
R37
R8
R117
R81
Q6
R146
C34 R39 R38
C72
Q2
C46
R14
C41
R21
C49
R108
R16
C38 R19
C35 R157
C45
C42
C37
R17
C36
C40
R139
R23 R26
C171
C53
R28
C54
C51
R138
C52
R25
D5
R27 C50
R135
R153
C198
8-4
RMUT
MAIN UNIT
SQL
X1: CPU
PBRC 4.91 BR IC1:
TONE TONE
M38223M4-432HP DE-
HI/LO
TMUT
CODER
RESET IC10: BA1604F [M45] only
9-1
IC2:
S-80742SL-A6
BLOCK DIAGRAM
PATTERN
SWITCH
UNLK
DSC
UNIT X1: CR-528
(OPTION) 15.2MHz
PLL BUFF
IC3:UPD3140GS COMMON LINE
Q8:
2SC4215 O
RX LINE
IC7: EXPAND
BU4094BCF TX LINE
LOOP BUFF
VCO BUFF
FIL
LINE
RCV
IC8: Q20: Q18: Q7: Q9:
SEND
POWER SW TA7805F 2SB1132 R 2SB1132 R 2SC4215 O 2SC4215 O
Q4: 2SK210 GR
(VR-A unit) DATA BUS LINE
13.8V REVERSE R5 T5 Q5: 2SK210 GR
CONECT REG CTRL CTRL
PROTECT HVS
D17:
DSA3A1
HV 5V R5 T5
IC4:
TA75S558F(TE85L)
IC6A: IC6B:
M5218AFP 600C M5218AFP 600C
SECTION 10 VOLTAGE DIAGRAM
DS3
HRS-7219-A-Y2 30
DS1 DS2
S31 LD-HU4549J-1 HRS-7219A-Y2 30
S30
S29
S28
S27
S25
S24
S23
S22
S21
S26
S20
S19
S18
S17
S15
S14
S13
S12
S11
S10
S16
C1
C0
S9
S8
S7
S6
S5
S4
S3
S2
S1
S0
10
11
12
13
14
15
16
17
18
19
21
22
23
24
25
26
27
28
29
30
31
32
33
34
20
1
2
3
4
5
6
7
8
9
DIM
SEG30
SEG29
SEG28
SEG27
SEG25
SEG24
SEG23
SEG22
SEG21
SEG26
SEG20
SEG19
SEG18
SEG17
SEG15
SEG14
SEG13
SEG12
SEG11
SEG10
SEG16
SEG31
DIM
COM1
COM0
SEG9
SEG8
SEG7
SEG6
SEG5
SEG4
SEG3
SEG2
SEG1
SEG0
C20
0.01
DIM3: 9.8 V
SEG10
SEG11
SEG12
SEG13
SEG14
SEG15
SEG16
SEG17
SEG18
SEG19
SEG20
SEG21
SEG22
SEG23
SEG24
SEG25
SEG26
SEG27
SEG28
SEG29
P42/INT0
P47 / SRDY
P56 / TOUT
B.E.
P46 / SCLK
P53 / RTP1
P52 / RTP0
21
P51 / INT3
P50 / INT2
P44 / RXD
P43/INT1
P57 / ADT
P45 / TXD
P67 / AN7
P66 / AN6
P65 / AN5
P64 / AN4
P63 / AN3
P62 / AN2
P61 / AN1
P60 / AN0
R30
C14 10 k 2.4 V
0.1
HANG
15
16
13
17
12
14
18
19
20
10
11
2
8
1
3
4
5
6
7
SP1
R34 47 k 1.2 V F45GO7-4
SP– W1
S.METER
OEX.STB
–
F.MODE
OEX.CE
DATAM
DATAS
TXDET
KEY.M
PTT.M
LBATT
P.STB
PTT.S
BUSY
SQLV
BEEP
DATA
+
ICF.C
SP+
ECS
ESI
CK
W2
C13 0.01
R27 150 k 5 4
IC2
NC
NC
R33 47 k
Q1 S-80742SL-A6 C2
0.001
C1
0.001
R32 47 k
2SC2712 GR
OUT
VDD
VSS
R28 C11
47 k 0.01 1 2 3
R31 47 k R9 100 k C7 R5
0.22 1k
LAMP2
LAMP1
TONE
UNLK
R7
SQL
220 k J1 to MAIN W3
unit J4 OPC-519
SP+
30
SP+
R8 D1 R6 R4 C6 29
220 k 1SS196 470 k 100 k 0.01 SP–
28
SP–
27
GND
26
BEEP
25
PTT
24
ICF3
23
HANG
22
TXDET
21
OEX.OE
20
Q5 P.STB
19
2SB1132Q R18 27 OEX.STB
18
TONE
17
S.METER
16
SQL
15
R19 27 PTT.S
14
UNLK 13
Q4 CK
12
2 1 FMW1 DATA
11
DATAM
LAMP2 10
DATAS 9
R20 68 k SQLV
R25 8
3.9 k R21 47 k
BUSY
7
3 4 5 LAMP1 GND
6
R22 39 k GND
5
R26 F.MODE
2.7 k 4
HVS
3
C21 R24 C10 R23 2
0.01 1 k 2.2 56 k 5V
1
KEY.M
DATAM
PTT.M
PTT.S
DATAS
ICF.3
ICF.C
PTT
ESI
R11
ECS
D3
IC4 R17 R16
47 k R14
6.8 k R10 1SS196 R2 R1
C18
0.01
X25080SI-2.7 47 k 100 k C8
0.01
33 k
100 k 10 k
8 VCC 1 D2
CS 1SS272
7
HOLD SO 2 C17 C4 C3 C19 C16 C15
CK 6 SCK WP
3 0.01 Q2 0.01 0.01 0.01 0.1 0.1
J2
DATA 5 4 8 1
SI VSS D4 1SS196
7 2 2SA1162 GR KEY.M 1
6 3 2 from Microphone
R15 5 4 Q3
47 k R13
C9
R12
47 k
10 k 2SC2712 GR R3 100 k
C5 0.01
0.01
IC3
TC7W02F
10 - 1
15
16
13
14
LA-253
C35 C32 C31 C201 5P 0.3 P Q1 10 P LA-243 0.001 LA-149 LA-243
9
Q25 27 P
7 FILOUT
1 8
OSCIN
VCC
2 7 43 k u only 47
IFIN
6
5
4
3
2
1
VDD
R30 0.1 15
VGG
0.1 0.1 0.001 L20 C174
27 k C185 0.001 SC-1302
PO
100 k u only 82 nH 0.001
PI
C182 C183 R46 R48 0.1 R50 R55 R56 L19 R60 C94 12 P L22
0.1 0.1 680 680 390 2.2 k 4.7 k 82 nH 1k C207 LA-243
J5 1 2 3 4
B11B-ZR-SM3-TF C57
0.001
Q4 C58
0.001 R32 C200 R53 C97 0.001
R66 R67
2.2 k
C61 2SK210 GR C59
10
47 0.1
D9
100 C90 18 P C95
0.001
2.2 k
D11
1
DSC 1P
C204
C79 R49 L17
0.1 H C83
MA862 Q10 R61
Q11 C101
HSM88ASR
DET D18 0.001 68 k
2 MA363B L12 LB258
C62
4P 0.5 P C78
0.001
R47
68 k L16
0.001 R51
39 k
R54 2SC3775 3 100 2SC2954 C100
0.001 C102 C103
5V C84 18 P 100 Tx(Hi): 7.8V 24 P 18 P 0.001
3 0.1 H L18 C87 C98
DATAM 0.1 H 10 P Tx(Lo): 5.0V 470
4 C64 C93 C96
from ICF3 L14 0.5 P 0.001 6.8
5 L10
optional unit 6
RMUT 3.3 H
C203
2.7 H
C80 R52
C85
0.001 R57 R58 C88 D10
C91
0.001 C93 Q13
C63 C81 R62
BUSY 7P 3P
R33 5P
Q8 20 P 1k 4.7 k 100 0.001 1SS196
1k R63 0.001
FMW1
7
PTT.S
82
Q7 C82
12 P
15 Q14 1 5
D12
8
OP.RST D6 2SC4215 O 2SC4215 O Q9 R155 RN1404 HSM88ASR
9 D7
10
DATAS MA363B MA363B 2SC4215 O 68 Q12 C108 4
470 P
11
GND 2SB1143 S
Q5 Q6 R36
1k 2 3
2SK210 GR 2SK880 Y R43 R41 Rx: 3.5V R78 R156
C115
0.001
IC3 R77 C109 C107 C106 R72
0.001
D19 C205
C70
10
10 k 560 100 100 C114
0.001
UPD3140GS 47 k 1 0.001 10 k
MA363B C72 C184 C197
4P 0.001 0.1 0.01 20 1 R68
C69
C76
0.1 19
GND1 VCC1
2 C112
Q15 R74
2.2 k R71 470 100 k
15.2MHz IN2 IN1 C111 R73
R34 L11 C67
2P
0.001 R42
8.2 k
CP2 C124
3P
C122
2P
C120
4P
18
VCC2 ENB
3 0.001 0.022 RN1404 220
1k 3.9 H
R37 17 4 R69
C71 1k C77 XB CLK C104 C105
0.1 16 5 1.5 k 0.001 0.1
L15 0.75 P R39 XI DATA
L13
2.7 H 10 k X1 CR-528 15 6 R44 R76
10 k
Q16
C68 R35 1 k XO T1 330
LB-257 4P R38
Tx: 2.7V L24
L23
1.8 H R45
14
GND2 LOK
7 RN1402
18 k (CH16) 1.8 H 330 13 8 R70
CP2 CP1 10 k
D8 R40 12 9
C65 C190 C74 FI2 FI1 C113 R75 C110
MA363B
TMUT
0.047 0.1 0.001 47 k C119 C116 11 10
P.STB
0.01 3.3 k 0.1
UNLK
DATA
C73 C75 C123 C121 0.001 C118 C117 15 P FO2 FO1
0.047 2.2 7P 8P 33 P 10 P
CK
Tx(Hi): 4.9V HI/LO
Tx(Lo): 0V C177
0.01
TXDET
Rx: 4.9V
C195 C166 5V 5V 5V
0.1 0.001
T5 R142 100
T5M T5M
R5 R131
HV 8.2 k SP—
C141 C142
SP+ 0.1 10 ICF3
SP— R132 R133 SP+
J4 C143 R101
52559-3092 15 k 39 k 10 k AF2
10
C125 C126 R113 R111
DSC.C
82 k
DSC
HANG
150 k HSJ1493-01-010
SP+ 0.1 R144
PTT
2
SP— R79 47 M5218AFP 600C IC6a IC5 6.8 k
Tx: 2.5V
R102
3
SP— 6 BEEP R129
R127
NTCCS20123NH 5 M5218AFP 600C 8
BU4066BCF 10 k
C191
100 C128 C127
4
GND 8 ICF3 12 k 103KCT 7 R125 R124 R122 3 R119
47 k
1 14 IC4 5 C134
0.0056 R112 0.001 0.001
5 82 k 82 k 82 k I/O VDD
6
6 10 TXDET R126
6 1 2
O/I CONT.A
13 TA75S558F 1 1k
P.STB 39 k 2 3 12 4 R134
7 12 O/I CONT.D
7 100 J2
8 R120 4 11 3
8 330 k 4 I/O I/O R116 B07B-EH-S
C138 5 10 18 k
9 13 R147 47 OEX.STB 0.0033
9 CONT.B O/I R103 C135
10 11 R146 47 OEX.OE 6 9 2 0.047 D14 AF1
10 R128 CONT.C O/I 47 k 1
7 8 1SS196 PTT
11 9 R82 47 HANG R130 12 k VEE I/O R104 R114 e only 2
11 C140 Tx: 2.6V C139 C137 47 k
12 7 R81 47 PTT 47 k 0.0027 68 P 0.001 1k HANG
12 R115 3
13 47 k u only GND from Microphone
13 R80 4
47 120 k e only MIC
14 14 TONE 5
to 14
15 16 SQL GND
LOGIC unit J1 15 6
16 18 UNLK C132 AF2
16 7
17 20 DATA C133 0.001 C131
17 0.001 e only 0.001
18 C130
18
19 21 R151 47 DATAM 0.001
19 C158
20 19 R150 47 CK HV R93 R105
20 1k 0.1 0.001 C159 C160
21 17 R149 47 PTT.S R5 0.22 2.2 C129
21 C163 D15
22
15 R148 47 SQL.C T5 Q22 C156
470 RD6.2M B2 0.001
e only
SQLV
5V
23
SQLV
R83 47
R94
560 k
R96
2.7 k
2SC2712 Y 10 R106 R107
DET
4 18 k
RCV C165
C192 C193 1 Q1 C152 C155 R100
0.1 0.1 STR. 5 SEND 0.22 R95 R97 0.1
2 330 820 P 2.2 k
Q2 6 MIC.C 180 k
D
3 Q3
CLK 7 DSC.C
15 Q4
OE 14 TMUT
Q5 J1
13 RMUT B8B-2R-SM3-TF
Q6 12 OP.RST
Q7 SQLG
11 HI/LO 1
Q8 Q20 Q18 SQLI 2
2SB1132 R 2SB1132 R IC8 SQLV 3
QS
9 TA7805F HV
4
10 R143 HVS
QS C149 33 5
R84 R86 R90 0.001 O HVS GND
R85 R87 C150 10 k R88 10 k I 6
47 k 8 47 k 47 k 47 k C189
NOTE 0.001
R91
0.1
G
VOL1
VOL2
7
8
C186
e : [EUR] IC7
2.2 k 0.1 R89
2.2 k
C187
0.1
HV
BU4094BCF
OEX.STD
u : [USA] RCV
OEX.OE
BEEP
0.1
Q19 100
C194 R154
GND
CK
10 - 2
J1
SQLI
3
SQLV R1
2
SQLG 10 k
1
P1
SQLG
1
SQLI
2
to MAIN unit J1
SQLV
3
HV
4
HVS
5
GND
6
VOL1 J2
7
VOL2 HV
8 1
GND
2
VOL2
3
VOL1
4
HVS R1
5 10 k
10 - 3