Sunteți pe pagina 1din 5

GENERAL REMARKS

Instructions for using wiring diagrams

1 Name of component (here: diode V100 on the central fuse, relay and terminal box (“ZE”),
position 53)
2 Mounting position on the front panel of the central fuse, relay and terminal box (“ZE”) (here:
engraved position number 53)
3 Plug connector on the rear of the central fuse, relay and terminal box (“ZE”) (here: plug 78,
connection 8)
2
4 Cable number; printed on the cable at short intervals (cross-section only if greater than 1 )
5 Sheet number (not page number) and circuit number
Marking to show on which sheet and circuit the conductor continues
(here: continuation of conductor 31002 on sheet 2 on circuit 4)
6 Plug connector (here: single-pin connector X104 in the ZE area)
7 Component mounting position (here: 21-pin connector X238 Pin R
– wiring harness cab to engine – in central portion)
8 Circuit number (please note: sheets are numbered consecutively from 1 to 55)

Important note on the use of the wiring diagram legends: A three-digit number is shown in brackets
after various item numbers. This number is the coded part number for this component!
These part numbers can be found in the T60 device list.

K 90 1.60 - 1
GENERAL REMARKS

Mounting positions for left-hand drive

1.60 - 2 K 90
GENERAL REMARKS

Marks Mounting position


A
............................................................................................................. Tail
B1
............................................................................................................. Engine
B2
............................................................................................................. Gearbox
C
............................................................................................................. Front
C1
............................................................................................................. Bumper
C2
............................................................................................................. Entrance right
C3
............................................................................................................. Entrance left
E6
............................................................................................................. Central electrics area
E7
............................................................................................................. Control unit racks
E8
............................................................................................................. Rear wall of cab
F
............................................................................................................. Instrument panel
F1
............................................................................................................. Central part
F2
............................................................................................................. Steering wheel/column
F3
............................................................................................................. Foot pedals
F4
............................................................................................................. Front wall, inside left
F5
............................................................................................................. Front wall, inside right
F6
............................................................................................................. Driving seat
F7
............................................................................................................. Passenger seat
F8
............................................................................................................. Control panel
G
............................................................................................................. Battery box
H1
............................................................................................................. B-pillar on driver's side
H2
............................................................................................................. A-pillar on driver's side
J1
............................................................................................................. B-pillar on passenger's side
J2
............................................................................................................. A-pillar on passenger's side
L
............................................................................................................. Ceiling/roof
N
............................................................................................................. Front axle
P
............................................................................................................. Rear axle
R1
............................................................................................................. Front parts of frame
R2
............................................................................................................. Rear part of frame
S1
............................................................................................................. Door left
S2
............................................................................................................. Door right

K 90 1.60 - 3
GENERAL REMARKS

Mounting positions for right-hand drive

1.60 - 4 K 90
GENERAL REMARKS

Marks Mounting position


A
............................................................................................................. Tail
B1
............................................................................................................. Engine
B2
............................................................................................................. Gearbox
C
............................................................................................................. Front
C1
............................................................................................................. Bumper
C2
............................................................................................................. Entrance right
C3
............................................................................................................. Entrance left
E6
............................................................................................................. Central electrics area
E7
............................................................................................................. Control unit racks
E8
............................................................................................................. Rear wall of cab
F
............................................................................................................. Instrument panel
F1
............................................................................................................. Central part
F2
............................................................................................................. Steering wheel/column
F3
............................................................................................................. Foot pedals
F4
............................................................................................................. Front wall, inside left
F5
............................................................................................................. Front wall, inside right
F6
............................................................................................................. Driving seat
F7
............................................................................................................. Passenger seat
F8
............................................................................................................. Control panel
G
............................................................................................................. Battery box
H1
............................................................................................................. B-pillar on driver's side
H2
............................................................................................................. A-pillar on driver's side
J1
............................................................................................................. B-pillar on passenger's side
J2
............................................................................................................. A-pillar on passenger's side
L
............................................................................................................. Ceiling/roof
N
............................................................................................................. Front axle
P
............................................................................................................. Rear axle
R1
............................................................................................................. Front parts of frame
R2
............................................................................................................. Rear part of frame
S1
............................................................................................................. Door left
S2
............................................................................................................. Door right

K 90 1.60 - 5

S-ar putea să vă placă și