Documente Academic
Documente Profesional
Documente Cultură
337005/02 - EN - 07/2014
The above information may change over time. Only the online version is up-to-date.
74 85 141 104
337005 1
CONTENTS
Generalities . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . A-1 8
GENERALITIES
DANGER! Non-observance of the procedure described or lack of care or attention, risk causing serious injury
or even death.
WARNING! Any different or inappropriate working method risks causing damage to the product.
Comply without fail with the regulations in force relative to the recovery and treatment of used parts and
waste.
The vehicle is broken down into several zones each designated by an item number.
Heightwise breakdown :
Reserved for the bodywork, 4 zones designated by a small letter
Widthwise breakdown :
3 zones designated by a capital letter
A : RH side and RH sidemember
B : Central part
C : LH side and LH sidemember
Lengthwise breakdown :
9 zones designated by a figure.
Zone 7 is specific for 6x2 - 6x4 - 6x6 - 8x4.
Zone 1 indicates :
- on the chassis, the bumper and the components it supports.
- on the cab, the front end components accessible through the grille
Example :
A1 : bumper RH section (headlamps...)
C3 : LH front wheel (ABS sensor...)
C2b : dashboard
A3c : passenger's seat
If the information is available in vector format and if you have installed the application to view it, it is possible to find
the title of the diagram by clicking on the code referencing the page, and to find the vehicle type by clicking on the
code referencing the diagram.
Appliances
Each appliance shown in the diagram is identified by an after-sales
code number.
If the after-sales code number is framed (item (1) of the illustration
opposite), it indicates a single appliance or an assembly comprising
several functions.
If the after-sales code number is not framed (item (2) of the
illustration opposite), it indicates a single appliance. It is then to be
found inside the symbol.
All the terminals of each appliance are defined by a numerical or
alphanumerical code number, if necessary (item (3) of the
illustration opposite).
If the information is available in vector format and if you have installed the application to view it, it is possible to find
the function of the unit by clicking on it.
Polarities
Polarities are identified by a numerical code number.
For each function, there is one same, single code number.
Example :
2007 = battery "positive" direct current power supply.
1 = earth.
If the information is available in vector format and if you have installed the application to view it, it is possible to find
the function of the wires by clicking on them. However the information is only available for wires with a numeric
reference.
Graphic conventions
When an intersection is not reinforced by a connection point, the
polarities cross each other and are distinct (mark (4) on the
illustration opposite).
When an intersection is reinforced by a connection point, we have
the same level of information on the wires (same potential) (mark (1)
on the illustration opposite).
It is possible for supplementary connection points to be applied to
the diagram for reasons of legibility (mark (1) on the illustration
opposite).
The item (2) represents a terminal of the connector located on the
electrical distribution box.
Example with an alphanumerical item XCIM2 :17 :
– XCIM2 : name of the connector;
– 17 : number of the terminal of that connector.
If the information is available in vector format and if you have installed the application to view it, it is possible to find
"the variant" of the wire by clicking on the information.
Wiring harnesses
Presentation of connectors :
(1) : connector number
(2) : code number of appliance to which it is connected
(3) : terminal number
(4) : number of the wire in the terminal
The list below shows the correlation between the first letter of a code and the associated devices
Letters Devices
A ECUs, amplifiers, radio set, component assembly
B Sensors, microphones, speakers
C Capacities, condensers
E Bulbs
F Fuses.
G Batteries, alternator
H Audible warnings
K Relays
M Motors
P Available power supply connectors
R Resistors
S Controls
U Voltage transformers, modulators
V Diodes.
W Antennas
X Sockets, connectors, earth collectors
Y Solenoid valves, electric valves
There is no information on the function of the wires when the vector format viewing feature is used
Electrical distribution
The electric distribution box inside the cab contains most of the fuses and relays for the vehicle
electrical network.
The terminals of the electrical distribution box are also shown in the basic diagram.
Each side of the electrical distribution box is detailed in the "Electrical distribution" chapter.
ZA : chassis zone
ZB : ECU bracket on dashboard
ZC : overhead ledge zone
ZD : dashboard zone
ZE : doors zone
SHARED FUNCTIONS
The term "Shared Functions" refers to an overview wiring diagram giving the main equipotentials of the system, the
different communication buses, and the devices affecting the function. This set of overview diagrams may be
considered as the high level of diagrammatics. The conventional diagram gives details of electrical operation.
JH : dual use
BS : 4x2 vehicles
DD : 6x2 vehicles
JH : dual use
ELECTRICAL DIAGRAM
Summary of diagrams
AU : left-hand drive
AV : right-hand drive
AU : left-hand drive
AV : right-hand drive
AU : left-hand drive
AV : right-hand drive
BS : 4X2 vehicles
DD : 6X2 vehicles
AU : left-hand drive
AV : right-hand drive
AU : left-hand drive
AV : right-hand drive
AU : left-hand drive
AV : right-hand drive
AU : left-hand drive
AV : right-hand drive
AU : left-hand drive
AV : right-hand drive
FS : with pre-equipment for driving assistance system
FT : without pre-equipment for driving assistance system
GO : with breathalyzer ignition interlock device
GP : without breathalyzer ignition interlock device
AU : left-hand drive
AV : right-hand drive
AU : left-hand drive
AV : right-hand drive
FS : with pre-equipment for driving assistance system
FT : without pre-equipment for driving assistance system
HH : with camera unit plus object detection and lane change sensors (LPOS) and without object detection and
distance radar sensor (FLS)
HK : with camera unit plus object detection and lane change sensors (LPOS) and with object detection and
distance radar sensors (FLS)
AU : left-hand drive
AV : right-hand drive
AU : left-hand drive
AV : right-hand drive
IY : with 4 kW air/air independent heating
IZ : with 2 kW air/air independent heating
AU : left-hand drive
AV : right-hand drive
AU : left-hand drive
AV : right-hand drive
AU : left-hand drive
AV : right-hand drive
GE : with 11A transformer in overhead ledge
GF : with 20A transformer in overhead ledge
AU : left-hand drive
AV : right-hand drive
GE : with 11A transformer in overhead ledge
GF : with 20A transformer in overhead ledge
GG : with 20A transformer under the dashboard
GH : with 25A transformer under the dashboard
JC : non-standard equipment
AU : left-hand drive
AV : right-hand drive
AU : left-hand drive
AV : right-hand drive
JA : with repositionable control unit (group 1)
JB : without repositionable control unit (group 1)
AU : left-hand drive
AV : right-hand drive
AU : left-hand drive
AV : right-hand drive
BJ : rigid vehicle
ER : tractor vehicle
GB : without fuel heating equipment
JH : dual use
AU : left-hand drive
AV : right-hand drive
BJ : rigid vehicle
ER : tractor vehicle
JH : dual use
AU : left-hand drive
AV : right-hand drive
FS : with pre-equipment for driving assistance system
FT : without pre-equipment for driving assistance system
AU : left-hand drive
AV : right-hand drive
FS : with pre-equipment for driving assistance system
FT : without pre-equipment for driving assistance system
PINPOINTING OF APPLIANCES
Urea input management with right-hand side tank under the cab
See page E-30
Fuel management
See page E-80
Door management
See page E-92
Radio (1/2)
See page E-110
Radio (2/2)
See page E-112
Driving assist
See page E-120
Cab earth
See page E-147
Distribution box
Key to appliances
GM : Bosch alternator
GN : Melco alternator
GM : Bosch alternator
GN : Melco alternator
Urea input management with right-hand side tank under the cab
Key to appliances
Fuel management
Key to appliances
Door management
Key to appliances
Radio (1/2)
Key to appliances
Radio (2/2)
Key to appliances
Driving assist
Key to appliances
Cab earth
LAYOUT OF CONTROLS
Switch blocks S264 - S266 - S268 - S261 and the switches they comprise are interchangeable. The locations in this
manual show the switches fitted in standard production
Switch blocks S264 - S266 - S268 - S261 and the switches they comprise are interchangeable. The locations in this
manual show the switches fitted in standard production
Folio Folio
Code Function Fuse Amperage
(code) (fuse)
X07 12 volt power supply socket GEA F01 10 GEA
- Fuse not used - F02 - -
A48 Television set GE2 F03 10 GEA
X163 Docking station for mobile telephones GEA F03 10 GEA
Available power supply (Telephone pre-
XALD09 GEA F03 10 GEA
equipment)
HBD/HBE/
X03 15-pin trailer socket F04 15 JAF
HBF
X03_2 15-pin trailer socket, dual use HBF F04 15 JAF
X05 Trailer connection (7-pin type 24 S) HBD F04 15 JAF
Bodybuilder pre-equipment connector no.
BB3 JAF F05 15 JAF
3
Central electrical distribution unit for
BBEC1A bodybuilder pre-equipment connector no. JAF F06 5 JAF
1
Bodybuilder pre-equipment connector no.
BB3 JAF F07 30 JAF
3
HBD/HBE/
X03 15-pin trailer socket F07 30 JAF
HBF
X03_2 15-pin trailer socket, dual use HBF F07 30 JAF
X05 Trailer connection (7-pin type 24 S) HBD F07 30 JAF
Central electrical distribution unit for
BBEC1A bodybuilder pre-equipment connector no. JAF F08 20 JAF
1
Central electrical distribution unit for
BBEC2A bodybuilder pre-equipment connector no. JAF F08 20 JAF
2
- Fuse not used - F09 - -
X107 24 volt power supply socket GEQ F10 15 GEQ
Available power supply (additional external
XALD01 JAG F11 15 JAG
lighting on roof)
Available power s up p l y ( f r o n t p a n e l
XALD02 JAG F11 15 JAG
additional lighting)
EL4AL Left-hand rotary beacon on roof JAG F12 15 JAG
EL4AR Right-hand rotary beacon on roof JAG F12 15 JAG
A06 Driver's heated seat unit GC1 F13 15 GC1
A132 Vehicle immobiliser interlock ECU DAK F13 15 GC1
Folio Folio
Code Function Fuse Amperage
(code) (fuse)
EL3 Work area illumination light JAG F34 5 JAG
- Fuse not used - F35 - -
- Fuse not used - F36 - -
A21 Braking management ECU (EBS) CF3 F37 20 CF3
A34B Air conditioning management ECU GBP F38 20 GBP
BCCT3 Temperature sensor inside the cab GBP F38 20 GBP
R46 Fuel heating resistor CCL F39 20 CCL
A33 Tachograph CB1 F40 3 CB1
A14 Engine management ECU CC3/CCH F41 15 CCA
A43 Engine fan speed regulator unit CC4/CCG F42 15 CCA
M15 Electric fuel priming pump CCG/CCH F42 15 CCA
Engine cooling fan regulation solenoid
Y35 CC4/CCG F42 15 CCA
valve
Y109 Water pump electromagnetic clutch CCG/CCH F42 15 CCA
Y111 Piston cooling solenoid valve CC3/CCH F42 15 CCA
- Fuse not used - F43 10 CCA
Y37 Exhaust brake solenoid valve unit CCH F44 10 CCA
Y39 VTC engine brake solenoid valve CC3/CCH F44 10 CCA
Y110 Oil cooling solenoid valve CC3/CCH F44 10 CCA
Y151 Exhaust brake solenoid valve unit CC3 F44 10 CCA
M11 Cab tilt motor HA1 F45 30 HA1
HBD/HBE/ HBD/HBE/
X02 ABS/EBS trailer socket F46 20
HBF HBF
HBD/HBE/
X02_2 ABS/EBS trailer socket, dual use HBF F46 20
HBF
- Fuse not used - F47 - -
- Fuse not used - F48 - -
R55 Microwave oven GEQ F49 50 GEQ
R11 Electric cafetiere GEQ F50 30 GEQ
K05 Windscreen wiper motor power supply relay FA1 F51 20 FA1
Folio Folio
Code Function Fuse Amperage
(code) (fuse)
X105 24 volt power supply socket GEQ F64 15 GEQ
X106 24 volt power supply socket GEQ F65 15 GEQ
Onboard management system interface
A125 CBT F66 3 CBT
ECU
Additional telematics management ECU
A175 CBT F66 3 CBT
(TESP)
R04 Cigar lighter GEQ F67 15 GEQ
A187 Main vehicle management ECU (VMCU) JAD F68 15 JAD
A211 Air/air independent heater GB1 F69 15 GB1/GBA
E128 Air/water independent heater GBA F69 15 GB1/GBA
A13B Robotized transmission management ECU CD5 F70 20 CD5
M03 Headlamp washer pump motor FA1 F71 15 FA1
- Fuse not used - F72 - -
Central electrical distribution unit for
BBEC2A bodybuilder pre-equipment connector no. JAF F73 30 JAF
2
Bodybuilder pre-equipment connector no.
BB3 JAF F74 20 JAF
3
A189 Refrigerator GEQ F75 10 GEQ
K02 Fog driving lights power supply relay GEQ F75 10 GEQ
Central electrical distribution unit for
BBEC1A bodybuilder pre-equipment connector no. JAF F76 15 JAG
1
HBD/HBE/
X03 15-pin trailer socket F76 15 JAG
HBF
X03_2 15-pin trailer socket, dual use HBF F76 15 JAG
X05 Trailer connection (7-pin type 24 S) HBD F76 15 JAG
- Fuse not used - F77 - -
- Fuse not used - F78 - -
- Fuse not used - F79 - -
- Fuse not used - F80 - -
- Fuse not used - F81 - -
- Fuse not used - F82 - -
- Fuse not used - F83 - -
- Fuse not used - F84 - -
Folio Folio
Code Function Relay Amperage
(code) (Relay)
- Relay not used - K01 - -
HBD/HBE/
X03 15-pin trailer socket K07 40 JAF
HBF
Available power s up p l y ( f r o n t p a n e l
XALD02 JAG K10 20 JAG
additional lighting)
Available power s up p l y ( f r o n t p a n e l
XALD02 JAG K12 10 JAG
additional lighting)
Folio Folio
Code Function Relay Amperage
(code) (Relay)
HBD/HBE/
X03 15-pin trailer socket K19 20 JAG
HBF
Folio Folio
Code Function Fuse Amperage
(code) (fuse)
A33 Tachograph CB1 F92 1 BA3
B250 24 V DC battery charge status sensor BA2 F94 1 BA2
B250 24 V DC battery charge status sensor BA2 F95 1 BA2
M05 Axle lift hydraulic pump motor CK1 FM1 200 BA2
A01 Electric distribution unit in cab BA2 FM2 100 BA2
Front chassis area information
A162 EA1 FM3 30 BA2
management ECU (FCIOM)
Central chassis area information
A163 BAH FM4 30 BA2
management ECU (CCIOM)
Rear chassis area information management
A164 EAA FM5 30 BA2
ECU (RCIOM)
Front chassis area information
A162 EA1 FM6 30 BA2
management ECU (FCIOM)
Central chassis area information
A163 BAH FM7 30 BA2
management ECU (CCIOM)
Rear chassis area information management
A164 EAA FM8 30 BA2
ECU (RCIOM)
- Fuse not used - FM9 - -
- Fuse not used - FM10 - -
Exhaust gases post-treatment
A174B CCX FM11 23 BA2
management ECU (ACM)
FM15 Power fuses box BA2 - - -
Folio Folio
Code Function Relay Amperage
(code) (Relay)
Bodybuilder pre-equipment connector no.
BB3 JAF K30 20 JAF
3
R46 Fuel heating resistor CCL K69 20 CCL
S227 Fuel heating resistor control CCL K69 20 CCL
EL3 Work area illumination light JAG K94 10 JAG
R55 Microwave oven GEQ K95 40 GEQ
Connector Number of
Function name Colour
item N° ways
A01.CT1_P1 Top ledge wiring harness BK 18
A01.CT1_P2 Top ledge wiring harness BK 9
A01.CT1_P3 Top ledge wiring harness NL 9
A01.CT2 Top ledge wiring harness GY 4
Connector Number of
Function name Colour
item N° ways
A01.CB1 Cab tilt and trailer socket wiring harness GY 4
A01.CB2_P1 Distribution wiring harness for power supplies and information NL 7
A01.CB2_P2 Distribution wiring harness for power supplies and information BK 18
A01.CB3_P1 Distribution wiring harness for power supplies and information NL 7
A01.CB3_P2 Distribution wiring harness for power supplies and information BK 18
A01.CB4 Microwave oven harness BK 1
A01.CB5 Bodybuilder equipment wiring harness GY 4
A01.CB6 Bodybuilder equipment wiring harness GY 2
A01.CB7 Cab tilting equipment BK 8
A01.CB8 Independent heating equipment GY 8
A01.CB9 Power supply equipment (earth) NL 1
A01.CB10 Distribution wiring harness for power supplies and information GY 8
A01.CB11 Electric coffee maker wiring harness GY 2
A01.CB12_P1 Distribution wiring harness for power supplies and information BK 7
A01.CB12_P2 Distribution wiring harness for power supplies and information NL 18
Connector Number of
Function name Colour
item N° ways
XC201 Cab tilt and trailer socket wiring harness GY 4
XC202 Bodybuilder equipment wiring harness GY 25
XC203 Distribution wiring harness for power supplies and information BN 36
XC204 Bodybuilder equipment wiring harness VT 36
XC205 + 24 Volts power supply wiring harness NL 1
XC206 Not used - -
XC207 ADR equipment wiring harness YE 9
XC208 Wiring harness for automatic gearbox and fuel heating resistor GN 12
XC209 Available power supply (front panel additional lighting) NL 6
XC210 Distribution wiring harness for power supplies and information VT 12
XC211 Cab rear wiring harness NL 9
XC212 Not used - -
XC213 Distribution wiring harness for power supplies and information BK 25
TRAILER SOCKETS
There is a high risk of irreparable damage being caused to the ECUs if electrical loads are applied without
integrated protection.
Location 1
Key to appliances
Fuse item
Function Polarity N° Amperage
N°
Available power supply (vehicle earth) 1 - -
Available power supply (vehicle earth) 1 - -
Available power supply (supplementary lighting lamp on the front) 8062 F11 15
Available power supply (exterior logo lighting lamp) 8064 F15 10
Location 2
Key to appliances
Fuse item
Function Polarity N° Amperage
N°
Available power supply (vehicle earth) 1 - -
Available power supply (supplementary lighting lamp on roof) 8062 F11 15
Available power supply (rotating beacon light) 8063 F12 15
Available power supply (sign lighting lamp on roof) 8064 F15 10
Location 3
Key to appliances
Fuse item
Function Polarity N° Amperage
N°
Available power supply (CB +) 4016 - 10
Available power supply (CB -) 1069 - 10
Pre-arrangement for CB radio cable antenna 4164 - -
Fuse item
Function Polarity N° Amperage
N°
Available power supply (television set -) 1069 - 10
Available power supply (television set +) 4012 - 5
Location 5
Key to appliances
Fuse item
Function Polarity N° Amperage
N°
Available power supply (vehicle earth) 1 - -
Available power supply (console accessories) 4017 F56 10
Location 6
Key to appliances
Fuse item
Function Polarity N° Amperage
N°
Available power supply (vehicle earth) 1 - -
Available power supply (CAN bus J2284 high level) 7008 - 3
Available power supply (CAN bus J2284 low level) 7009 - 3
Available power supply (Video ECU) 2091 F53 5
Location 7
Key to appliances
Fuse item
Function Polarity N° Amperage
N°
Available power supply (vehicle earth) 1 - -
Available power supply (vehicle starting) 0022 - 3
Available power supply (vehicle starting) 0022 - 3
Available power supply (after ignition) 2020 - 3
Available power supply (engine running) 2038 - 7
Available power supply (CAN bus J2284 high level) 7026 - 3
Available power supply (CAN bus J2284 low level) 7027 - 3
Available power supply (breathalyser test ECU) 2039 F88 5
Location 8
Key to appliances
Fuse item
Function Polarity N° Amperage
N°
Available power supply (vehicle earth) 1 - -
Available power supply (Camera unit plus object detection and lane - 3
2122
change sensors)
Available power supply (high level CAN bus J1939) 7004 - 5
Available power supply (low level CAN bus J1939) 7005 - 5
Available power supply (CAN bus J2284 high level) 7006 - 5
Available power supply (CAN bus J2284 low level) 7007 - 5
Available power supply (CAN bus J2284 high level) 7026 - 3
Available power supply (CAN bus J2284 low level) 7027 - 3
Available power supply (CAN bus J2284 high level) 7073 - 5
Available power supply (CAN bus J2284 low level) 7074 - 5
Available power supply (driving assist management ECU) 2121 F31 5
Available power supply (earth) 1052 - 3
Fuse item
Function Polarity N° Amperage
N°
Available power supply (radio-telephone -) 1069 - 10
Telephone set antenna 4179 - -
Available power supply (radio-telephone +) 4012 F03 10
Location BBEC1A
Key to appliances
Fuse item
Function Polarity N° Amperage
N°
Available power supply (trailer loading alarm) 0159 - 5
Available power supply (engine running or neutral or parking brake - 5
8000
signal)
Available power supply (block of repositionable controls) 8002 - 5
Available power supply (tail lift or crane control) 8004 - 5
Available power supply (block of repositionable controls) 8083 - 5
Available power supply (bodybuilder equipment control) 8084 - 3
Available power supply (bodybuilder equipment control) 8085 - 3
Available power supply (bodybuilder equipment control) 8086 - 3
Available power supply (tail lift information) 8045 - 5
Available power supply (supplementary trailer lighting) 8020 F76 15
Location BBEC2A
Key to appliances
Fuse item
Function Polarity N° Amperage
N°
Available power supply (vehicle earth) 1 - -
Available power supply (vehicle earth) 1 - -
Available power supply 8025 F08 20
Available power supply (vehicle starting) 8027 F73 30
Location BBEC3A
Key to appliances
Fuse item
Function Polarity N° Amperage
N°
Available power supply 8032 - 10
Available power supply 8033 - 10
Available power supply 8034 - 10
Available power supply 8035 - 10
Available power supply 8036 - 17
Available power supply 8037 - 17
Available power supply 8038 - 17
Available power supply 8046 - 10
Available power supply 8047 - 10
Available power supply 8048 - 10
Available power supply 8049 - 10
Available power supply 8050 - 10
Available power supply 8051 - 10
Available power supply 8052 - 10
A passage for the bodybuilder's wiring harness is reserved for that purpose on the chassis-cab connection.
Location 1
Key to appliances
Fuse item
Function Polarity N° Amperage
N°
Available power supply (vehicle earth) 1 - -
Available power supply (vehicle earth) 1 - -
Available power supply (rear side parking lights) 3066 - 5
Available power supply (front side parking lights) 3017 - 5
Available power supply (side position light) 3066 - 5
Available power supply (side position light) 3017 - 5
Location 2
Key to appliances
Fuse item
Function Polarity N° Amperage
N°
Available power supply (vehicle earth) 1 - -
Available power supply (work area illumination light) 8067 F34 5
Location BB1
Key to appliances
Fuse item
Function Polarity N° Amperage
N°
Available power supply 8046 - 10
Available power supply 8047 - 10
Available power supply 8048 - 10
Available power supply 8049 - 10
Available power supply 8050 - 10
Available power supply 8051 - 10
Available power supply 8045 - 10
Fuse item
Function Polarity N° Amperage
N°
Available power supply 8032 - 10
Available power supply 8033 - 10
Available power supply 8034 - 10
Available power supply 8035 - 10
Available power supply 8036 - 17
Available power supply 8037 - 17
Available power supply 8038 - 17
Location BB3
Key to appliances
Fuse item
Function Polarity N° Amperage
N°
Available power supply (vehicle earth) 1 - -
Available power supply (vehicle earth) 1 - -
Available power supply (independent heating deactivation) 0156 - 10
Available power supply 8042 - 10
Available power supply (tail lift information) 8045 - 5
Available power supply (power supply to tail lift or crane) 8031 F58 20
Available power supply (after ignition) 8043 F74 20
WIRING HARNESSES
Number
Code Function Connectors Colour
of tracks
A01 Electric distribution unit in cab A01.STUD :1 NL 1
Front chassis area information management
A162 A162.X1 BK 29
ECU (FCIOM)
Front chassis area information management
A162 A162.X2 GY 29
ECU (FCIOM)
Central chassis area information management
A163 A163.X4 BK 2
ECU (CCIOM)
Rear chassis area information management ECU
A164 A164.X4 BK 2
(RCIOM)
Exhaust gases post-treatment management
A174B A174B GY 62
ECU (ACM)
B250 24 V DC battery charge status sensor B250.A BK 3
G01A 12V DC battery No. 1 A1 - -
G01A 12V DC battery No. 1 B1 - -
G01A 12V DC battery No. 1 C1 - -
G01A 12V DC battery No. 1 D1 - -
G01B 12V DC battery No. 2 A1 - -
G01B 12V DC battery No. 2 B1 - -
G01B 12V DC battery No. 2 C1 - -
Plug-in connector between the dashboard
XC205 XC205 NL 1
harness and the +24 volts power supply harness
Plug-in connector between the chassis front
XC315 XC315 BK 4
harness and the battery box harness
Plug-in connector between the bumper harness
XC321 XC321 BK 2
and the power fuse box power supplies harness
Plug-in connector between the bumper harness
XC322 XC322 GY 2
and the power fuse box power supplies harness
Plug-in connector between the chassis central
XC323 harness and the power fuse box power supplies XC323 BK 2
harness
Plug-in connector between the harness for the
XC328 ADR equipment adaptation on the chassis and XC328 BK 16
the ADR equipment harness on the chassis
Number
Code Function Connectors Colour
of tracks
A13B Robotized transmission management ECU A13B GY 62
A14 Engine management ECU A14.EB - 62
A21 Braking management ECU (EBS) A21.X1 BK 16
A26 Driver's trip computer ECU (DECU) A26.A GY 12
A26 Driver's trip computer ECU (DECU) A26.B BK 18
A33 Tachograph A33.A WH 8
Bodybuilder pre-equipment management ECU
A36 A36.A GN 12
(BBM)
A160 Cab information management ECU (CIOM) A160.A GN 30
Man/machine interface management ECU
A161 A161 BK 26
(HMIIOM)
Exhaust gases post-treatment management
A174B A174B GY 62
ECU (ACM)
A187 Main vehicle management ECU (VMCU) A187.CN3 BK 26
XC169 Plug-in connector between 2 wiring harnesses XC169 BK 25
XC180 Plug-in connector between 2 wiring harnesses XC180 BU 6
Plug-in connector between the dashboard
XC203 XC203 BN 36
harness and the chassis front harness
Interface connector between the chassis and the
XC302 XC302 GN 39
engine
Interface connector between the chassis and the
XC303 XC303 GN 39
gearbox
Number
Code Function Connectors Colour
of tracks
A01 Electric distribution unit in cab A01.CB3_p1 NL 7
A01 Electric distribution unit in cab A01.CB3_p2 BK 18
A01 Electric distribution unit in cab A01.CB12_p1 NL 7
A01 Electric distribution unit in cab A01.CB12_p2 BK 18
A03A Main information display A03A.A BK 12
A03A Main information display A03A.B BK 12
A154 Video display A154A.A BK 6
A154 Video display A154A.B - 2
Man/machine interface management ECU
A161 A161 BK 26
(HMIIOM)
A169 Video ECU (VS) A169.A - -
A169 Video ECU (VS) A169.B - -
A169 Video ECU (VS) A169.C - -
A169 Video ECU (VS) A169.D - -
A175 Additional telematics management ECU (TESP) A175.X2 - 2
XC181 Plug-in connector between 2 wiring harnesses XC181 BU 6
Number
Code Function Connector Colour
of tracks
A01 Electric distribution unit in cab A01.CB12_p1 NL 7
A01 Electric distribution unit in cab A01.CB12_p2 BK 18
A01 Electric distribution unit in cab A01.CT1_p1 BK 18
A01 Electric distribution unit in cab A01.CT1_p2 BK 9
A01 Electric distribution unit in cab A01.CT1_p3 NL 9
A33 Tachograph A33.A WH 8
A33 Tachograph A33.B YE 8
A33 Tachograph A33.C RD 8
A33 Tachograph A33.D BN 8
A122 Tele-payment system ECU A122.B YE 8
A125 Onboard management system interface ECU A125.X1 GY 40
X26 Onboard management pre-arrangement (ECU) X26 GN 12
Plug-in connector between the dashboard
XC169 XC169 BK 25
harness and the overhead console harness
Plug-in connector between the dashboard
XC170 XC170 VT 12
harness and the overhead console harness
Plug-in connector between the dashboard
XC203 XC203 BN 36
harness and the chassis front harness
Number
Code Function Connectors Colour
of tracks
A14 Engine management ECU A14.EA BK 62
A14 Engine management ECU A14.EB GR 62
A43 Engine fan speed regulator unit A43 SB 6
Combustion engine speed sensor on engine
B04 B04 SB 2
flywheel
B05 Combustion engine speed sensor on camshaft B05 SB 2
Boost circuit air pressure and temperature
B37 B37 SB 4
sensors assembly
B39 Air filter pressure and temperature sensor B39 SB 4
B54 Pressure sensor inside engine block B54 SB 4
B102 Key switch engine immobilizer and starting B102 SB 2
B118 Combustion engine oil pressure sensor B118 SB 4
B119 Engine oil level and temperature sensors unit B119 SB 4
B187 Inter-axle diff lock control B187 SB 4
B207 Piston cooling oil pressure sensor B207 SB 4
B222 Rail fuel high pressure sensor B222 - 3
B231 Engine cooling circuit temperature sensor B231 SB 2
B260 Exhaust backpressure sensor B260 SB 4
B265 Fuel heating unit B265 GR 4
Connector between the engine wiring harness
C1 C1 SB 4
and the engine oil level and temperature sensor
Connector between the engine wiring harness
C2 C2 GR 2
and the engine cooling circuit temperature sensor
G02 Alternator B1+ - 1
G02 Alternator B2+ - 1
G02 Alternator G02.A SB 4
K01_A Air intake pre-heating unit K01_A.1 - 1
K01_A Air intake pre-heating unit K01_A.2 - 1
K01_A Air intake pre-heating unit K01_A.3 SB 3
M04 Starter B+ - 1
M04 Starter M04.1 GR 2
R01 Intake air preheating resistor R01.1 - 1
R01 Intake air preheating resistor R01.1-2N - 1
R01 Intake air preheating resistor R01.2 - 1
S68 Combustion engine coolant level sensor S68 SB 3
S112 Combustion engine shut down control S112 SB 4
Number
Code Function Connectors Colour
of tracks
A14 Engine management ECU A14.EA SB 62
A14 Engine management ECU A14.EB GR 62
A43 Engine fan speed regulator unit A43 SB 6
A45 Fuel heating unit A45 GR 4
Combustion engine speed sensor on engine
B04 B04 SB 2
flywheel
B05 Combustion engine speed sensor on camshaft B05 SB 2
Combustion engine coolant circuit temperature
B21 B21 SB 2
sensor
Boost circuit air pressure and temperature
B37 B37 SB 4
sensors assembly
B39 Air filter pressure and temperature sensor B39 SB 4
B54 Pressure sensor inside engine block B54 SB 4
B102 Oil temperature sensor on oil filter bracket B102 SB 2
B118 Combustion engine oil pressure sensor B118 SB 4
B119 Engine oil level and temperature sensors unit B119 SB 4
B187 Inter-axle diff lock control B187 SB 4
B207 Piston cooling oil pressure sensor B207 SB 4
B213 Exhaust backpressure sensor B213 SB 4
G02 Alternator B2+
G02 Alternator G02.D GR 5
K01_A Air intake pre-heating unit K01_A.A SB 3
K01_A Air intake pre-heating unit K01_A.B1 SB 1
K01_A Air intake pre-heating unit K01_A.C1 SB 1
M04 Starter B+ - -
M04 Starter M04 GR 2
M15 Electric fuel priming pump M15 GR 2
M19 Exhaust gases recycling solenoid valve M19 GR 2
R01 Intake air preheating resistor R01.1-2N - 1
R01 Intake air preheating resistor R01.2 - 1
S68 Combustion engine coolant level sensor S68 SB 2
S112 Combustion engine shut down control S112 SB 2
Connector between the engine wiring harness
VCI VCI SB 12
and the injectors wiring harness
Connector between the engine wiring harness
VCI2 VCI2 SB 14
and the injectors wiring harness
Number
Code Function Connectors Colour
of tracks
Exhaust gases post-treatment management
A174B A174B GY 62
ECU (ACM)
Air control solenoid and AdBlue temperature
A190 A190 GY 4
sensor assembly
Exhaust temperature sensor upstream of
B85 B85 GR 2
particulate filter
B96 Nitrogen oxide concentration sensor B96 GR 4
Nitrogen oxide concentration sensor after
B96B B96B GR 4
catalytic converter
Exhaust gas temperature sensor before catalytic
B97 B97 GR 2
converter
Exhaust gas temperature sensor after catalytic
B98 B98 GR 2
converter
B142B AdBlue tank temperature and level sensors unit B142B BK 4
Pressure sensor for exhaust gas in particulate
B115 B115 SB 3
filter
B262 AdBlue pressure sensor B262 BK 2
B263 Air pressure sensor in AdBlue tank B263 GN 3
M73 AdBlue supply metering pump M73.A BU 2
AdBlue heating resistor (on the circuit between
R56A R56A BK 2
the tank and the pump module, yellow hose)
AdBlue heating resistor (on the circuit between
R57A R57A GN 2
the pump module and the injector, black hose)
Plug-in connector between the chassis front
XC302 XC302 GN 39
harness and the engine harness
Plug-in connector between the chassis front
XC312 XC312 BK 21
harness and the catalytic converter harness
Plug-in connector between the chassis front
XC313 harness and the AdBlue management harness XC313 BK 21
extension
Plug-in connector between the AdBlue
XC316 management harness extension and the AdBlue XC316 BK 16
management harness
Y81C AdBlue cooling solenoid valve Y81C GY 2
Number
Code Function Connectors Colour
of tracks
A01 Electric distribution unit in cab A01.CB3_p1 NL 7
Number
Code Function Connectors Colour
of tracks
A41 Retarder equipment unit A41 R 7
B09B Gearbox oil temperature sensor B09B SB 2
B12 Vehicle speed sensor for tachograph B12 SB 4
B69 Retarder coolant temperature sensor B69 SB 4
S47 Position sensor - low speed range engaged S47 SB 4
S49 Position sensor - reverse gear engaged S49 SB 4
S63 Position sensor - low speed range engaged S63 SB 4
S101 Gear selector neutral position sensor S101 SB 4
S124C PTO no. 1 position sensor S124C SB 4
Y06 Range change locking solenoid valve Y06 SB 4
Y31 First gear locking solenoid valve Y31 SB 4
Interface connector between the chassis and the
XC303 XC303 GN 39
gearbox
Number
Code Function Connectors Colour
of tracks
A13B Robotized transmission management ECU A13B.A - -
A13B Robotized transmission management ECU A13B.B - -
A41 Retarder equipment unit A41 SB 4
B12 Vehicle speed sensor for tachograph B12 SB 4
B69 Retarder coolant temperature sensor B69 SB 4
S124C PTO no. 1 position sensor S124C SB 4
Interface connector between the chassis and the
XC303 XC303 SB 39
gearbox
Number
Code Function Connectors Colour
of tracks
A21 Braking management ECU (EBS) A21.X1 BK 16
A21 Braking management ECU (EBS) A21.X2 GY 18
A21 Braking management ECU (EBS) A21.X3 BK 18
A21 Braking management ECU (EBS) A21.X4 BK 12
Braking assistance modulator (drive axle no. 1)
U03A U03A.X1 BK 4
(EBS)
Braking assistance modulator (drive axle no. 1)
U03A U03A.X2 BK 6
(EBS)
Braking assistance modulator (drive axle no. 1)
U03A U03A.X3 BK 2
(EBS)
Braking assistance modulator (drive axle no. 1)
U03A U03A.X4 BK 2
(EBS)
U05 Trailer brake control modulator U05 BK 7
U08 Braking modulator on front axle U08.X1 BK 4
U08 Braking modulator on front axle U08.X2 BK 6
U08 Braking modulator on front axle U08.X3 BK 2
U08 Braking modulator on front axle U08.X4 BK 2
Plug-in connector between the chassis front
XC302 XC302 GN 39
harness and the engine harness
Y11 LH wheel ABS solenoid valve Y11 BK 3
Y12 RH wheel ABS solenoid valve Y12 BK 3
Number
Code Function Connectors Colour
of tracks
Central chassis area information management
A163 A163.X1 BK 29
ECU (CCIOM)
Central chassis area information management
A163 A163.X2 GY 18
ECU (CCIOM)
Rear chassis area information management ECU
A164 A164.X1 BK 29
(RCIOM)
Rear chassis area information management ECU
A164 A164.X2 GY 29
(RCIOM)
Rear chassis area information management ECU
A164 A164.X3 BU 29
(RCIOM)
Rear chassis area information management ECU
A164 A164.X4 BK 2
(RCIOM)
B28 Front axle suspension position sensor B28 BK 4
B29B Rear drive axle suspension LH position sensor B29B BK 4
B30 Rear drive axle suspension RH position sensor B30 BK 4
Sensor for air pressure in front axle suspension
B56 B56 BK 4
cushion
Sensor for air pressure in left suspension cushion
B57 B57 BK 4
(rear axle no. 1)
Sensor for air pressure in right suspension
B58 B58 BK 4
cushion (rear axle no. 1)
Plug-in connector between the chassis front
XC302 XC302 GN 39
harness and the engine harness
Plug-in connector between the chassis central
XC323 harness and the power fuse box power XC323 BK 2
supplies harness
Y40 Front suspension solenoid valve Y40 BK 4
Y135 Rear axle suspension control electrovalve unit Y135 BK 4
Number
Code Function Connectors Colour
of tracks
A01 Electric distribution unit in cab A01.CB12_p1 NL 7
A01 Electric distribution unit in cab A01.CB12_p2 BK 18
Left-hand door information management ECU
A165L A165L.X1 GN 12
(DDM/PDM)
Left-hand door information management ECU
A165L A165L.X2 GY 12
(DDM/PDM)
Left-hand door information management ECU
A165L A165L.X3 GY 6
(DDM/PDM)
Right-hand door information management ECU
A165R A165R.X1 GN 12
(DDM/PDM)
Right-hand door information management ECU
A165R A165R.X2 GY 12
(DDM/PDM)
Right-hand door information management ECU
A165R A165R.X3 GY 6
(DDM/PDM)
E130L Left-hand door illumination light E130L BK 2
E130R Right-hand door illumination light E130R BK 2
M09L Front left-hand door locking system unit M09L BK 6
M09R Front right-hand door locking system unit M09R BK 6
Front left-hand door window mechanism motor
M44L M44L GY 6
with anti-pinch system
Front right-hand door window mechanism motor
M44R M44R GY 6
with anti-pinch system
M45L Front left-hand door window mechanism motor M45L GY 2
M45R Front right-hand door window mechanism motor M45R GY 2
Control for front right-hand window mechanism
S36R S36R GY 3
motor
Control for front left-hand window mechanism
S36L S36L GY 3
motor
R02AL Left-hand electric external rear-view mirror R02AL BK 12
R02AR Right-hand electric external rear-view mirror R02AR BK 12
Plug-in connector between the left-hand door
XC163_1 harness extension and the left-hand door XC163_1 BK 18
harness
Plug-in connector between the right-hand door
XC163_2 harness extension and the right-hand door XC163_2 BK 18
harness
Plug-in connector between the dashboard
XC164_1 harness and the left-hand door harness XC164_1 BK 25
extension
Plug-in connector between the dashboard
XC164_2 harness and the right-hand door harness XC164_2 BK 25
extension
Number
Code Function Connectors Colour
of tracks
A01 Electric distribution unit in cab A01.CB12_p1 NL 7
A01 Electric distribution unit in cab A01.CB12_p2 BK 18
A31 Vehicle anti-theft system ECU A31 BN 21
Ultrasound decoder for anti-intrusion protection
B242 B242 BK 4
(UIP)
E104 Light for storage compartment under bunk no. 1 E104 GY 4
H06 Horn - alarm siren H06 BK 3
S95A Alarm panic control S95A BK 10
V07 Vehicle alarm sounding diode V07 BK 3
XC169 Plug-in connector between 2 wiring harnesses XC169 BK 25
XC171 Plug-in connector between 2 wiring harnesses XC171 YE 9
XC175 Plug-in connector between 2 wiring harnesses XC175_p1 NL 7
XC175 Plug-in connector between 2 wiring harnesses XC175_p2 BK 18
XC188 Plug-in connector between 2 wiring harnesses XC188 GY 12
XC190 Plug-in connector between 2 wiring harnesses XC190_p1 BK 18
XC190 Plug-in connector between 2 wiring harnesses XC190_p2 BK 9
XC190 Plug-in connector between 2 wiring harnesses XC190_p3 NL 9
XC204 Plug-in connector between 2 wiring harnesses XC204 VT 36
XC301 Plug-in connector between 2 wiring harnesses XC301 BK 26
Number
Code Function Connectors Colour
of tracks
A01 Electric distribution unit in cab A01.CB2_p1 NL 7
A01 Electric distribution unit in cab A01.CB2_p2 BK 18
A01 Electric distribution unit in cab A01.CB8 GY 8
A34B Air conditioning management ECU A34B.X1 GY 2
A34B Air conditioning management ECU A34B.X2 BK 18
Front chassis area information management
A162 A162.X2 GY 29
ECU (FCIOM)
A170A Cab air conditioning control panel A170A YE 3
A211 Air/air independent heater A211 BK 10
B22 External air temperature sensor B22 BK 2
B236 Mist on windscreen sensor B236 BK 3
XC161 Plug-in connector between 2 wiring harnesses XC161 BK 16
XC174 Plug-in connector between 2 wiring harnesses XC174 BU 9
XC190 Plug-in connector between 2 wiring harnesses XC190 BN 36
XC203 Plug-in connector between 2 wiring harnesses XC203 BN 36
XC213 Plug-in connector between 2 wiring harnesses XC213 BK 25
Number
Code Function Connectors Colour
of tracks
A01 Electric distribution unit in cab A01.CB12_p1 NL 7
A01 Electric distribution unit in cab A01.CB12_p2 BK 18
A07 Radio set A07.A GY 8
A07 Radio set A07.B BN 8
A07 Radio set A07.C1 YE 6
A07 Radio set A07.C2 GN 6
A07 Radio set A07.X1 - 10
A07 Radio set A07.X3 - 2
A175 Additional telematics management ECU (TESP) A175.X1 BK 18
A188 FM signal distributor A188.A - 2
A188 FM signal distributor A188.C - -
B60L LH front loudspeaker B60L GY 2
B60R RH front loudspeaker B60R GY 2
B60LR Rear left-hand speaker B60LR GY 2
B60RR Rear right-hand speaker B60RR GY 2
B63 Microphone B63 BK 4
B252L Tweeter speaker, left-hand side B252L BK 3
B252R Tweeter speaker, right-hand side B252R BK 3
U30 Voltage transformer 24 V / 12 V - 20A U30 GN 12
U34 Voltage transformer 24 V / 12 V - 25A U34 VT 15
XC160 Plug-in connector between 2 wiring harnesses XC160 GY 25
XC163_1 Plug-in connector between 2 wiring harnesses XC163_1 BK 18
XC163_2 Plug-in connector between 2 wiring harnesses XC163_2 BK 18
XC164_1 Plug-in connector between 2 wiring harnesses XC164_1 BK 25
XC164_2 Plug-in connector between 2 wiring harnesses XC164_2 BK 25
XC169 Plug-in connector between 2 wiring harnesses XC169_p1 NL 7
XC169 Plug-in connector between 2 wiring harnesses XC169_p2 BK 18
Plug-in connector between the dashboard
XC172 XC172 GN 12
harness and the overhead console harness
Number
Code Function Connectors Colour
of tracks
A01 Electric distribution unit in cab A01.CB10 GY 8
A01 Electric distribution unit in cab A01.CB12_p1 NL 7
A01 Electric distribution unit in cab A01.CB12_p2 BK 18
A01 Electric distribution unit in cab A01.CT1_p1 BK 18
A01 Electric distribution unit in cab A01.CT1_p2 BK 9
A01 Electric distribution unit in cab A01.CT1p_3 NL 9
A01 Electric distribution unit in cab A01.CT2 GY 4
A06 Driver's heated seat unit A06 BK 4
A189 Refrigerator A189 GY 4
M43A Front panel motor M43A GY 2
M51A Sunroof electric motor M51A GY 2
R04 Cigar lighter R04 WH 3
S238 Passenger side front panel control S238 BK 10
U29 Voltage transformer 24V / 12V – 11A U29 BK 8
U30 Voltage transformer 24V / 12V - 20A U30 GN 12
U33 Voltage transformer 24V / 12V – 20 A U33 GN 12
U34 Voltage transformer 24V / 12V - 25A U34 VT 15
X07 12 volt power supply socket X07 BN 3
X105 24 volt power supply socket X105 GN 3
X106 24 volt power supply socket X106 GN 3
X107 24 volt power supply socket X107 GN 3
X165 12 Volt power supply socket on bunk X165 YE 3
XC160 Plug-in connector between 2 wiring harnesses XC160 GY 25
XC166 Plug-in connector between 2 wiring harnesses XC166 GY 12
XC175 Plug-in connector between 2 wiring harnesses XC175 BK 25
Number
Code Function Connectors Colour
of tracks
A01 Electric distribution unit in cab A01.CB3_p1 NL 7
A01 Electric distribution unit in cab A01.CB3_p2 BK 18
A26 Driver's trip computer ECU (DECU) A26.A GY 12
A26 Driver's trip computer ECU (DECU) A26.B BK 18
Camera unit plus object detection and change of
A176 A176 BK 12
lane sensors (LPOS)
B238 Object detection and distance radar sensor (FLS) B238 BK 8
XC172 Plug-in connector between 2 wiring harnesses XC172 GN 12
XC186 Plug-in connector between 2 wiring harnesses XC186 GY 4
XC189 Plug-in connector between 2 wiring harnesses XC189 BU 12
XC190 Plug-in connector between 2 wiring harnesses XC190_p1 BK 18
XC190 Plug-in connector between 2 wiring harnesses XC190_p2 BK 9
XC190 Plug-in connector between 2 wiring harnesses XC190_p3 NL 9
XC204 Plug-in connector between 2 wiring harnesses XC204 VT 36
XC301 Plug-in connector between 2 wiring harnesses XC301 BK 26
Number
Code Function Connectors Colour
of tracks
A01 Electric distribution unit in cab A01.CB1 GY 4
A01 Electric distribution unit in cab A01.CB7 BK 8
A187 Main vehicle management ECU (VMCU) A187.CN2 BK 26
M11 Cab tilt motor M11 BK 2
S26 Cab tilt control S26 BK 2
S52L Left-hand position sensor - cab tilt safety feature S52L BK 2
Right-hand position sensor - cab tilt safety
S52R S52R BK 2
feature
XC161 Plug-in connector between 2 wiring harnesses XC161 BK 16
Plug-in connector between 2 under floor
XC199 XC199 BK 3
harnesses on the right-hand side
XC201 Plug-in connector between 2 wiring harnesses XC201 GY 4
XC211 Plug-in connector between 2 wiring harnesses XC211 NL 9
XC213 Plug-in connector between 2 wiring harnesses XC213 BK 25
XC301 Plug-in connector between 2 wiring harnesses XC301 BK 26
Number
Code Function Connectors Colour
of tracks
A01 Electric distribution unit in cab A01.CB12_p1 NL 7
A01 Electric distribution unit in cab A01.CB12_p2 BK 18
A01 Electric distribution unit in cab A01.CT1_p1 BK 18
A01 Electric distribution unit in cab A01.CT1_p2 BK 9
A01 Electric distribution unit in cab A01.CT1_p3 NL 9
Front chassis area information management
A162 A162.X2 GY 29
ECU (FCIOM)
A187 Main vehicle management ECU (VMCU) A187.CN1 BK 26
E100L Lighting unit, left-hand cabin light (environment) E100L GY 2
E100R Lighting unit, right-hand cabin light (environment) E100R GY 2
E101L Reading light, left-hand side E101L - -
E101R Reading light, right-hand side E101R - -
E102 Instrument panel lighting (environment) E102 BK 3
E103C Centre console light (environment) E103C - -
E103L Left-hand console light (environment) E103L - -
E103R Right-hand console light (environment) E103R - -
E104 Light for storage compartment under bunk no. 1 E104 GY 4
E105 Light for storage compartment under bunk no. 2 E105 GY 2
E116L Directional reading light, left-hand side E116L BK 3
E116R Directional reading light, right-hand side E116R BK 3
E117C Light for storage compartment in centre console E117C - -
Light for storage compartment in left-hand
E117L E117L - -
console
Light for storage compartment in right-hand
E117R E117R - -
console
E119 Step light, driver's side E119 - -
S286C Centre console lighting contact S286C - -
S286L Left-hand console lighting contact S286L - -
S286R Right-hand console lighting contact S286R - -
XC166 Plug-in connector between 2 wiring harnesses XC166 GY 12
XC167 Plug-in connector between 2 wiring harnesses XC167 GY 4
XC175 Plug-in connector between 2 wiring harnesses XC175_p1 NL 7
XC175 Plug-in connector between 2 wiring harnesses XC175_p2 BK 18
Number
Code Function Connectors Colour
of tracks
A01 Electric distribution unit in cab A01.CT1_p1 BK 18
A01 Electric distribution unit in cab A01.CT1_p2 BK 9
A01 Electric distribution unit in cab A01.CT1_p3 NL 9
A187 Main vehicle management ECU (VMCU) A187.CN12 GY 8
E115L Marker light, LH E115L BK 3
E115R Marker light, RH E115R BK 3
E120C Central identification light on the roof E120C BK 3
E120L Left-hand identification light on the roof E120L BK 3
E120R Right-hand identification light on the roof E120R BK 3
S210 Identification lights on roof control S210 BK 10
Plug-in connector between the overhead console
XC166 XC166 GY 12
harness and the harness under the roof
XC169 Plug-in connector between 2 wiring harnesses XC169_p1 NL 7
XC169 Plug-in connector between 2 wiring harnesses XC169_p2 BK 18
Number
Code Function Connectors Colour
of tracks
Front chassis area information management
A162 A162.X1 BK 29
ECU (FCIOM)
Front chassis area information management
A162 A162.X2 GY 29
ECU (FCIOM)
Rear chassis area information management ECU
A164 A164.X1 BK 2
(RCIOM)
Rear chassis area information management ECU
A164 A164.X2 GY 29
(RCIOM)
E27L LH tail lights unit E27L BK 7
E27R RH tail lights unit E27R BK 7
E83AL LH light unit E83AL.A BK 8
E83AL LH light unit E83AL.B BK 60
E83AL LH light unit E83AL.C BK 6
E83AR RH light unit E83AR.A BK 8
E83AR RH light unit E83AR.B BK 60
E83AR RH light unit E83AR.C BK 6
E119 Step light, driver's side E119 BK 2
Plug-in connector between the chassis front
XC301 XC301 BK 26
harness and the bumper harness
Plug-in connector between the chassis front
XC302 XC302 GN 39
harness and the engine harness
Plug-in connector between the chassis front
XC317 XC317 BK 26
harness and the chassis central harness
Number
Code Function Connectors Colour
of tracks
A01 Electric distribution unit in cab A01.CB2_p1 NL 7
A01 Electric distribution unit in cab A01.CB2_p2 BK 18
A160 Cab information management ECU (CIOM) A160.B GN 12
Front chassis area information management
A162 A162.X2 GY 29
ECU (FCIOM)
A187 Main vehicle management ECU (VMCU) A187.CN1 BK 26
B239 Rain and light detection sensors unit B239 WH 3
B249 Screen wash level sensor B249 GY 2
M01 Windscreen wiper drive motor M01 BK 4
M02 Windscreen wash pump motor M02 BK 2
M03 Headlamp washer pump motor M03 BU 2
Plug-in connector between the dashboard
XC171 XC171 YE 9
harness and the overhead console harness
Plug-in connector between the dashboard
XC213 XC213 BK 25
harness and the front end harness
Plug-in connector between the chassis front
XC301 XC301 BK 26
harness and the bumper harness
Number
Code Function Connectors Colour
of tracks
A01 Electric distribution unit in cab A01.CB12_P1 BK 18
A01 Electric distribution unit in cab A01.CB12_P2 NL 7
A160 Cab information management ECU (CIOM) A160.A GN 30
A160 Cab information management ECU (CIOM) A160.B GN 12
A160 Cab information management ECU (CIOM) A160.C GY 12
Man/machine interface management ECU
A161 A161 BK 26
(HMIIOM)
Onboard equipment auxiliaries management
S253 S253 BK 3
remote control (LECM)
S261 Re-positionable control unit (group 5) S261 BK 3
S264 Re-positionable control unit (group 1) S264 BK 3
S266 Re-positionable control unit (group 2) S266 BK 3
S268 Re-positionable control unit (group 3) S268 BK 3
S274 Steering wheel mounted controls S274 BK 6
S277 External lighting controls unit S277 BU 3
S278 Cruise control commands unit S278 BU 3
S280 Cab lighting control S280 BU 3
X115C Rotary switch under steering wheel X115C.A BK 6
X115C Rotary switch under steering wheel X115C.B BN 6
XC160 Plug-in connector between 2 wiring harnesses XC160_p1 NL 7
XC160 Plug-in connector between 2 wiring harnesses XC160_p2 BK 18
XC171 Plug-in connector between 2 wiring harnesses XC171 YE 9
Connectors
Connectors - Contents
Connectors - Dashboard wiring harness (1/10)
See page K-2-2
Number
Code Function Connectors Colour
of tracks
A01 Electric distribution unit in cab A01.CB1 GY 4
A01 Electric distribution unit in cab A01.CB2_P1 NL 7
A01 Electric distribution unit in cab A01.CB2_P2 BK 18
A01 Electric distribution unit in cab A01.CB3_P1 NL 7
A01 Electric distribution unit in cab A01.CB3_P2 BK 18
A01 Electric distribution unit in cab A01.CB4 BK 1
A01 Electric distribution unit in cab A01.CB5 GY 4
A01 Electric distribution unit in cab A01.CB6 GY 2
A01 Electric distribution unit in cab A01.CB7 BK 8
A01 Electric distribution unit in cab A01.CB8 GY 8
A01 Electric distribution unit in cab A01.CB9 NL 1
A01 Electric distribution unit in cab A01.CB10 GY 8
A01 Electric distribution unit in cab A01.CB11 GY 2
Number
Code Function Connectors Colour
of tracks
A01 Electric distribution unit in cab A01.CB12_P1 NL 7
A01 Electric distribution unit in cab A01.CB12_P2 BK 18
A03A Main information display A03A.A BK 12
A03A Main information display A03A.B BK 12
A26 Driver's trip computer ECU (DECU) A26.A GY 12
A26 Driver's trip computer ECU (DECU) A26.B BK 18
A31 Vehicle anti-theft system ECU A31 BN 21
A34B Air conditioning management ECU A34B.X1 GY 2
A34B Air conditioning management ECU A34B.X2 BK 18
A154 Video display A154.A BK 6
Number
Code Function Connectors Colour
of tracks
A160 Cab information management ECU (CIOM) A160.A GN 30
A160 Cab information management ECU (CIOM) A160.B GN 12
A160 Cab information management ECU (CIOM) A160.C GY 12
Man / machine interface management
A161 A161 BK 26
ECU (HMIIOM)
A170A Cab air conditioning control panel A170A YE 3
Infra-red receiver for interconnection between
A172 the keypad and the Navigation functions A172 BK 6
management ECU
A173A Parking brake electrical control A173A WH 3
A175 Additional telematics management ECU (TESP) A175.X1 BK 18
Number
Code Function Connectors Colour
of tracks
A187 Main vehicle management ECU (VMCU) A187.CN1 BK 26
A187 Main vehicle management ECU (VMCU) A187.CN2 BK 26
A187 Main vehicle management ECU (VMCU) A187.CN3 BK 26
A187 Main vehicle management ECU (VMCU) A187.CN11 BK 12
A187 Main vehicle management ECU (VMCU) A187.CN12 GY 8
Central electrical distribution unit for bodybuilder
BBEC BBEC1A.B VT 12
pre-equipment
Central electrical distribution unit for bodybuilder
BBEC BBEC2A.B GY 4
pre-equipment
Central electrical distribution unit for bodybuilder
BBEC BBEC3A.A BK 25
pre-equipment
Number
Code Function Connectors Colour
of tracks
B25 Accelerator pedal position sensor B25 BK 6
B26 Clutch pedal position sensor B26 BK 6
B49 Angle sensor wheel steering B49 BK 7
E102 Instrument panel lighting (environment) E102 BK 3
K69 Fuel heating resistor power supply relay K69 BK 9
K30 Rotating beacon power supply relay K30 BK 9
K94 Work light power supply relay K94 NL 10
X26 Onboard management pre-arrangement (ECU) X26 GN 12
X43 Vehicle diagnostic socket (OBD) X43 BU 18
Number
Code Function Connectors Colour
of tracks
R04 Cigar lighter R04 WH 3
S15A Key control contacts unit S15A GY 6
S95A Alarm panic control S95A BK 10
S105 Hazard lights control S105 BK 6
S243 Bodybuilder pre-equipment no. 1 control S243 BK 10
S244 Bodybuilder pre-equipment no. 2 control S244 BK 10
S245 Bodybuilder pre-equipment no. 3 control S245 BK 10
S264 Re-positionable control unit (group 1) S264 BK 3
S266 Re-positionable control unit (group 2) S266 BK 3
S268 Re-positionable control unit (group 3) S268 BK 3
S274 Steering wheel mounted controls S274 BK 6
S277 External lighting controls unit S277 BU 3
S278 Cruise control commands unit S278 BU 3
S279 Differential lock selector controls unit S279 BU 3
Number
Code Function Connectors Colour
of tracks
S227 Fuel heating resistor control S227 BK 10
S282 Air suspension controls assembly S282 BK 3
U30 Voltage transformer 24 V / 12 V - 20A U30 GN 12
U34 Voltage transformer 24 V / 12 V - 25A U34 VT 15
W02A Immobiliser antenna transponder W02A BK 3
X07 12 volt power supply socket X07 BN 3
Number
Code Function Connectors Colour
of tracks
X105 24 volt power supply socket X105 GN 3
X115C Rotary switch under steering wheel X115C.A BK 6
Plug-in connector between the dashboard
XC160 XC160_P1 NL 7
harness and the rear panel harness
Plug-in connector between the dashboard
XC160 XC160_P2 BK 18
harness and the rear panel harness
Plug-in connector between the dashboard
XC164_1 harness and the left-hand door harness XC164_1 BK 25
extension
Plug-in connector between the dashboard
XC164_2 harness and the right-hand door harness XC164_2 BK 25
extension
Plug-in connector between the dashboard
XC165 harness and the pre-equipped bodybuilder XC165 YE 9
equipment harness
Plug-in connector between the dashboard
XC170 XC170 VT 12
harness and the overhead console harness
Plug-in connector between the dashboard
XC171 XC171 YE 9
harness and the overhead console harness
Plug-in connector between the dashboard
XC172 XC172 GN 12
harness and the overhead console harness
Plug-in connector between the dashboard
XC174 XC174 BU 9
harness and the overhead console harness
Number
Code Function Connectors Colour
of tracks
Plug-in connector between the dashboard
XC175 XC175_P1 NL 7
harness and the floor harness
Plug-in connector between the dashboard
XC175 XC175_P2 BK 18
harness and the floor harness
Plug-in connector between the dashboard
XC177 XC177 BK 2
harness and the microwave harness
Plug-in connector between the dashboard
XC180 harness and the bodybuilder pre-equipment XC180 BU 6
management ECU harness
Plug-in connector between the dashboard
XC181 XC181 BU 6
harness and the video ECU harness
Plug-in connector between the dashboard
XC189 harness and the driving assistance management XC189 BU 12
ECU harness
P l u g -i n c o n n e c t o r b e t w e e n 2 d a s h b o a r d
XC190 XC190_P1 BK 18
harnesses
P l u g -i n c o n n e c t o r b e t w e e n 2 d a s h b o a r d
XC190 XC190_P2 BK 9
harnesses
P l u g -i n c o n n e c t o r b e t w e e n 2 d a s h b o a r d
XC190 XC190_P3 NL 9
harnesses
Plug-in connector between the dashboard
XC191 harness and the vehicle breathalyzer ignition XC191 NL 9
interlock device ECU harness
Plug-in connector between the dashboard
XC193 XC193 GY 2
harness and the electric coffee maker harness
P l u g -i n c o n n e c t o r b e t w e e n 2 d a s h b o a r d
XC197 XC197 GN 12
harnesses
Plug-in connector between the dashboard
XC201 XC201 GY 4
harness and the chassis front harness
Plug-in connector between the dashboard
XC202 harness and the pre-equipped bodybuilder XC202 GY 25
equipment harness on the chassis
Number
Code Function Connectors Colour
of tracks
Plug-in connector between the dashboard
XC203 XC203 BN 36
harness and the chassis front harness
Plug-in connector between the dashboard
XC204 XC204 VT 36
harness and the chassis front harness
Plug-in connector between the dashboard
XC207 harness and the harness for the ADR equipment XC207 YE 9
adaptation on the chassis
Plug-in connector between the dashboard
XC208 XC208 GN 12
harness and the chassis front harness
XC209 Pre-equipment connector for the exterior lighting XC209 NL 6
Plug-in connector between the dashboard
XC210 XC210 VT 12
harness and the chassis front harness
Plug-in connector between the dashboard
XC211 harness and the harness under the floor on the XC211 NL 9
right-hand side
Plug-in connector between the dashboard
XC213 XC213 BK 25
harness and the front end harness
Number
Code Function Connectors Colour
of tracks
A01 Electric distribution unit in cab A01.CT1_P1 BK 18
A01 Electric distribution unit in cab A01.CT1_P2 BK 9
A01 Electric distribution unit in cab A01.CT1_P3 NL 9
A01 Electric distribution unit in cab A01.CT2 GY 4
A07 Radio set A07.A GY 8
A07 Radio set A07.B BN 8
A07 Radio set A07.C1 YE 6
A07 Radio set A07.C2 GN 6
A33 Tachograph A33.A WH 8
A33 Tachograph A33.B YE 8
A33 Tachograph A33.C RD 8
A33 Tachograph A33.D BN 8
Number
Code Function Connectors Colour
of tracks
A122 Tele-payment system ECU A122.A WH 8
A122 Tele-payment system ECU A122.B YE 8
A122 Tele-payment system ECU A122.C RD 8
A123 Tele-payment sender unit A123 WH 8
A125 Onboard management system interface ECU A125.X1 GY 40
B236 Mist on windscreen sensor B236 BK 3
B239 Rain and light detection sensors unit B239 WH 3
B252L Tweeter speaker, left-hand side B252L BK 3
B252R Tweeter speaker, right-hand side B252R BK 3
Number
Code Function Connectors Colour
of tracks
B63 Microphone B63 BK 4
E115L Marker light, LH E115L BK 3
E115R Marker light, RH E115R BK 3
E116L Directional reading light, left-hand side E116L BK 3
E116R Directional reading light, right-hand side E116R BK 3
E99L Bunk lighting unit, left-hand side E99L WH 3
E99R Bunk lighting unit, right-hand side E99R WH 3
M43A Front panel motor M43A GY 2
S38 Vehicle emergency stop control S38 BK 10
S77 Emergency call control S77 BK 10
S210 Identification lights on roof control S210 BK 10
S238 Passenger side front panel control S238 BK 10
Number
Code Function Connectors Colour
of tracks
S261 Re-positionable control unit (group 5) S261 BK 3
U29 Voltage transformer 24 V / 12 V – 11 A U29 BK 8
U33 Voltage transformer 24 V / 12 V – 20 A U33 GN 12
V07 Vehicle alarm sounding diode V07 BK 3
X107 24 volt power supply socket X107 GN 3
Plug-in connector between the overhead console
XC166 XC166 GY 12
harness and the harness under the roof
Plug-in connector between the overhead console
XC167 XC167 GY 4
harness and the cab interior lamps harness
Plug-in connector between the dashboard
XC169 XC169_P1 NL 7
harness and the overhead console harness
Plug-in connector between the dashboard
XC169 XC169_P2 BK 18
harness and the overhead console harness
Plug-in connector between the dashboard
XC170 XC170 VT 12
harness and the overhead console harness
Number
Code Function Connectors Colour
of tracks
Plug-in connector between the dashboard
XC171 XC171 YE 9
harness and the overhead console harness
Plug-in connector between the dashboard
XC172 XC172 GN 12
harness and the overhead console harness
Plug-in connector between the dashboard
XC174 XC174 BU 9
harness and the overhead console harness
Plug-in connector between the overhead console
XC186 harness and the lane change and object XC186 GY 4
detection camera harness
Plug-in connector between the overhead console
XC187 harness and the lane change and object XC187 GY 4
detection camera harness
Plug-in connector between the overhead console
XC188 XC188 GY 12
harness and the harness under the roof