Documente Academic
Documente Profesional
Documente Cultură
STAINLESS STEEL TRIM ARE EXTREMELY SHARP! You are responsible for inspecting all packages containing E&G Classics' parts and
file a claim with the carrier for any damage disclosure by such inspection and notify E
such damage. This warranty does not extend to any of our products which have been
altered or repaired in any way. This warranty does not cover any accidental or conse
INSTALLATION INSTRUCTIONS: agreement. E&G Classics shall have no responsibility for any loss of time, inconvenien
shall E&G be liable for any injury or damage to persons or property by reason of any d
or products. This warranty gives you specific legal rights and you may also have othe
1. Open the hood and remove the factory radiator 2. Carefully unclip the entire front grille section. The 3. Pry the center fou
support panel cover by removing the push fasten- sides of the grille pull straight out to release the straight out with
ers. mounting clips. You can now car
out for the follow
4. Lay the grille onto a clean, flat work area and 5. Trim a 1/4” from the closed end of the supplied 7. Align the upper
apply masking tape to the grille surround to pre- vinyl caps and install them onto the three studs on the studs pass t
vent scratching the surface while installing the the upper grille and the center stud on the lower the factory grille
“Q” grille sections. grille. 8. Install the suppl
6. Remove the protective liner and thoroughly clean half nuts onto th
the “Q” grille fins with a mild solvent and soft
cloth to remove the remaining qlue residue.