Documente Academic
Documente Profesional
Documente Cultură
1907/2006 (REACH)
Printed 29-04-19
Revision 29-04-19 (GB) Version 2.4
Tudalen 13 F
2. HAZARDS IDENTIFICATION
3. COMPOSITION/INFORMATION ON INGREDIENTS
Chemical characterization
100% of mineral oil. CAS Nr. 64742-54-7, 64742-65-0
The PCA content (DSMO extract according to IP346) of dangerous components is lower than 3%.
General information
Remove contaminated soaked clothing immediately.
In case of inhalation
In the event of symptoms refer for medical treatment.
In case of ingestion
Do not induce vomiting.
Summon a doctor immediately.
Page 1/6
Safety data-sheet according to Regulation (EC) No.
1907/2006 (REACH)
Printed 29-04-19
Revision 29-04-19 (GB) Version 2.4
Tudalen 13 F
5. FIRE-FIGHTING MEASURES
Special exposure hazards arising from the substance, combustible products or resulting gases
Soot and other organic products.
Nitrogen oxides (NOx)
Carbon monooxide (CO)
Sulphur dioxide (SO2)
Additional information
Cool containers at risk with water spray jet.
Personal precautions
Use breathing apparatus if exposed to vapours/aerosol with filter Typ A2, A2/P2 or ABEX.
Use personal protective clothing.
Environmental precautions
Do not discharge into the drains/surface water/groundwater.
Prevent spread over a wide area (e.g. by containment or oil barrires).
Do not discharge into the subsoil/soil.
Page 2/6
Safety data-sheet according to Regulation (EC) No.
1907/2006 (REACH)
Printed 29-04-19
Revision 29-04-19 (GB) Version 2.4
Tudalen 13 F
Storage group 10
Fire class B
Respiratory protection
Respiratory equipment in case of nebulosity or aerosol: Use a mask with a filter type A2, A2/P2 or ABEX.
Hand protection
Use safety gloves of following materials: NBR (nitrile) / neopren / viton (permeationslevel 5 -6), Cat. II according to norm EN 388
Eye protection
Safety goggles with side protection, in case of increased risk add protective face shield.
Skin protection
Oil-resistant and hardly inflammable protective clothing.
Hyginene measures
Clean skin thoroughly after working.
Cloths contaminated with product should not be kept in trouser pockets.
At work do not eat, drink, smoke or take drugs.
Keep away from food and drink.
Page 3/6
Safety data-sheet according to Regulation (EC) No.
1907/2006 (REACH)
Printed 29-04-19
Revision 29-04-19 (GB) Version 2.4
Tudalen 13 F
Additional information
The data are subject to usual tolerances.
Conditions to avoid
No hazardous reactions known.
Materials to avoid
Reactions with strong oxidising agents.
Acute toxicity/Irritability/Sensitization
Page 4/6
Irritability eye non-irritant
Sensitization non-sensitising
respiratory system
General regulation
Do not discharge product unmonitored into the environment.
Wastes marked with an asterisk are considered to be hazardous waste pursuant to Directive 91/689/EEC on hazardous waste.
Page 5/6
Air trasport ICAO/IATA-DGR
No hazardous material as defined by the prescriptions.
National regulations
Decree for case of interference/ Accident regulation, appendix I: not specifed
remarks
Further information
Above information corresponds to our present knowledge and experience. It is not a guarantee that no errors or incompleate data
may be contained.
Page 6/6