Documente Academic
Documente Profesional
Documente Cultură
Group B
Short answer type question 5x1=5
2.Draw and explain the phasor diagram of single phase transformer under no load condition. 3+2
BASIC ELECTRONICS PART
Group A
1. Multiple choice questions 10x1=10
i. A negative feedback amplifier has a gain A and feedback path gain is β. What will be the overall gain of the amplifier?
A 1+ A A 1+ A
(a ) (b) (c) (d)
1+ Aβ 1+ Aβ 1− Aβ 1+ Aβ
ii. The transfer characteristics of a voltage amplifier is
Vo Io Io Vo
(a) Av= (b) AI= (c) gm= (d) rm=
Vs Is Vs Is
iii. The advantage of a negative feedback amplifier are
(a) high input impedance (b) increase in gain stability (c) low output impedance (d) all of these
Vo Io Io Vo
iv. The transfer characteristic of a trans-conductance amplifier is (a) Av= (b) Ai= (c) gm= (d) rm=
Vs Is Vs Is
v. An amplifier has gain of -1000 and feedback of β= -0.1. If it had a gain change of 20% due to temperature, what will be the change in
gain of the feedback amplifier? (a)1% (b) 2% (c) 0.5% (d) 0.2%
vi. An amplifier has gain of -1000 and feedback of β= -0.1. If it had a gain change of 20% due to temperature, what will be the change in
gain of the feedback amplifier? (a)1% (b) 2% (c) 0.5% (d) 0.2%
vii. A trans-conductance amplifier has
(a) high input impedance and high output impedance (b) high input impedance and high output impedance (c) low input impedance and
low output impedance (d) low input impedance and high output impedance
viii. . Negative feedback increase the performance parameter except
(a) Gain (b) input impedance (c) noise distortion (d) 3 dB frequency
ix. The input impedance of a JFET is in the range of
(a) above 1 MΩ (b) 200 kΩ (c) 2kΩ (d) 200Ω
x. A FET is a
(a) Voltage –controlled device (b) current controlled device (c) impedance –controlled device (d) resistance-controlled device
Group B
Short answer type question 5x1=5
2. Describe the working principle of a inverting adder with a suitable diagram. 5