Documente Academic
Documente Profesional
Documente Cultură
2° LABORATORIO DE FÍSICA 1
Erika Bello, Elisa Gómez, Yesica Mendivil, Yhoany Monterroza.
Programa de Biología
29/03/2017
RESUMEN
Al iniciar la práctica de Movimiento Rectilíneo Uniforme, en el laboratorio de física; fue
necesario antes haber leído la guía que indicaba lo que se habría de hacer. Primero se
tomaron las medidas en Cm de diez en diez sobre la mesa, marcando los números sobre una
cinta de enmascarar. Inmediatamente se utilizó un carrito el cual recorría la distancia; a
medida que éste avanzaba se tomaba el tiempo en cada punto marcado, este procedimiento
fue realizado 5 veces para así obtener un promedio y plasmarlos en una tabla. Seguido a
esto, se llevó a cabo el mismo método pero en el piso. Luego se calculó la velocidad en
cada punto referenciado, se halló la pendiente y el coeficiente para ambos, logrando así los
resultados. Cabe resaltar que fue necesario graficar en un papel milimetrado y en Excel,
también realizar una regresión lineal.
ABSTRACT
When initiating the practice of Uniform Rectilinear Motion, in the physics laboratory; it
was necessary before reading the guide that indicated what was to be done. Measures were
first taken in Cm by tens on the table, marking the numbers on a masking tape. Immediately
a cart was used which ran the distance; as this progressed, time was taken at each marked
point, this procedure was performed 5 times to obtain an average and to translate them into
a table. Following this, the same method was performed but on the floor. Then the velocity
was calculated at each referenced point, the slope and coefficient were found for both, thus
achieving the results. It should be noted that it was necessary to graph in a graph paper and
also to perform a linear regression.
10−0
1) V= 0.76−0 = 13.15 cm/s 70−60
7) V= 4.86−4.11 = 13.33 cm/s
20−0
2) V= 1.30−0.76 = 18.51 cm/s 80−70
8) V= 5.59−4.86 = 13. 69 cm/s
90−80
3)
30−20
V= 1.92−1.30 = 16.12 cm/s
9) V= 6.29−5.59 = 14.28 cm/s
100−90
4)
40−30
V= 2.62−1.92 = 14.28 cm/s
10) V= 7.01−6.29 =13.88 cm/s
x T x.t t x
0 0 0 0 0
10 0.76 7.6 0.57 100
20 1.30 26.0 1.69 400
30 1.92 57.6 3.68 900
40 2.62 104.8 6.86 1600
50 3.39 169.5 11.49 2500
60 4.11 246.6 16.89 3600
70 4.86 340.2 23.61 4900
80 5.59 447.2 31.24 6400
90 6.29 566.1 39.56 8100
100 7.01 701.0 49.14 10000
Total: 500 Total: 37.85 Total: 2666.6 Total: 184.77 Total: 38500
x vs t
120
100
f(x) = 14.19 x + 1.16
R² = 1
80
60
40
20
0
0 1 2 3 4 5 6 7 8
y=mx+b
y = 14.196 t + 1.153
x (cm) t (s)
1.153 0
11.94 0.76
19.60 1.30
28.40 1.92
38.34 2.62
49.27 3.39
59.49 4.11
70.14 4.86
80.50 5.59
90.44 6.29
100.6 7.01
Tabla 3. Datos de obtenidos al momento de hacer la ecuación lineal de la mesa.
x vs t 1 2 3 4 5 T (s) V (cm/s)
0 0 0 0 0 0 0 0
10 0.35 ± 0.70 ± 0.54 ± 0.53 ± 0.48 ± 0.52 ± 19.23
0.01 0.01 0.01 0.01 0.01 0.01
20 0.87 ± 1.13 ± 1.03 ± 1.01 ± 1.13 ± 1.03 ± 19.60
0.01 0.01 0.01 0.01 0.01 0.01
30 1.44 ± 1.66 ± 1.54 ± 1.77 ± 1.77 ± 1.63 ± 16.66
0.01 0.01 0.01 0.01 0.01 0.01
40 2.07 ± 2.26 ± 2.20 ± 2.42 ± 2.40 ± 2.27 ± 15.62
0.01 0.01 0.01 0.01 0.01 0.01
50 3.05 ± 2.87 ± 2.90 ± 3.04 ± 3.14 ± 3.00 ± 13.64
0.01 0.01 0.01 0.01 0.01 0.01
60 3.78 ± 3.64 ± 3.49 ± 3.66 ± 3.88 ± 3.69 ± 14.49
0.01 0.01 0.01 0.01 0.01 0.01
70 4.57 ± 4.31 ± 4.10 ± 4.43 ± 4.52 ± 4.38 ± 14.49
0.01 0.01 0.01 0.01 0.01 0.01
80 5.36 ± 4.98 ± 4.88 ± 5.12 ± 5.17 ± 5.10 ± 13.88
0.01 0.01 0.01 0.01 0.01 0.01
90 6.12 ± 5.65 ± 5.64 ± 5.79 ± 5.95 ± 5.83 ± 13.69
0.01 0.01 0.01 0.01 0.01 0.01
100 7.15 ± 6.39 ± 6.32 ± 6.60 ± 6.69 ± 6.62 ± 12.65
0.01 0.01 0.01 0.01 0.01 0.01
Tabla 4. Resultados del procedimiento en el piso del laboratorio
Dado que la velocidad es igual a la tiempo entonces:
sumatoria de la distancia entre la del
Xf −Xi
V=
tf −ti
10−0
1) V = = 19.23 cm/s
0.52−0
20−10
2) V = = 19.60 cm/s
1.03−0.52
30−20
3) V = = 16.66 cm/s
1.63−1.03
40−30
4) V = = 15.62 cm/s
2.27−1.63
50−60
5) V = = 13.69 cm/s
3.00−2.27
60−50
6) V = = 14.49 cm/s
3.69−3.00
70−60
7) V = = 14.49 cm/s
4.38−3.69
80−70
8) V = = 13.88 cm/s
5.10−4.38
90−80
9) V = = 13. 69 cm/s
5.83−5.10
100−90
10) V = = 12.65 cm/s
6,62−5.83
x T x.t t x
0 0 0 0 0
10 0.52 5.2 0.27 100
20 1.03 20.6 1.06 400
30 1.63 48.9 2.65 900
40 2.27 90.8 5.15 1600
50 3.00 150.0 9.00 2500
60 3.69 221.4 13.18 3600
70 4.38 306.6 19.18 4900
80 5.10 408.0 26.01 6400
90 5.83 524.7 33.98 8100
100 6.62 662.0 43.82 10000
Total: 500 Total: 34.07 Total: 2438.2 Total: 154.73 Total: 38500
Tabla 5. Regresión Del Procedimiento en el Piso
X vs t
120
100
f(x) = 14.92 x + 3.79
R² = 1
80
60
40
20
0
0 1 2 3 4 5 6 7
y=mx+b
y = 14.93 t + 3.76
x (cm) t (s)
3.76 0
11.52 0.52
19.13 1.03
28.09 1.63
37.65 2.27
48.55 3.00
58.85 3.69
69.15 4.38
79.90 5.10
90.80 5.83
102.59 6.62
Tabla 6. Datos de obtenidos al momento de hacer la ecuación lineal del piso.
ANALISIS
1. De la tabla de datos y de la gráfica realizada ¿qué relación existe entre x y t? explique.
La regresión que existe es que los puntos tienden a una línea recta debido a que sus
magnitudes son directamente proporcional, es decir que si aumenta la posición por ende
aumenta el tiempo.
CONCLUCIONES
BIBLIOGRAFIA