Documente Academic
Documente Profesional
Documente Cultură
SELF-LEARNING
MULTI-USER RECE/VER
NOVA RECEIVER _
CONFIGURING THE SYSTEM: lt's so easy to install!
Transmitter:
Each transmitter is uniquely coded at the factory. lt is NOT necessary to open
the transmitter, except when changíng the battery. To replace the REMOVE COVER
battery, rotate the inner casing, and remove from the outer clip. Using a
coin, prise apart the inner casing to expose the battery. Replace with type 1 . lnsert
GP23 or similar. screwdriver
intoslot.
Receiver:
Open the receiver housing by inserting a screwdriver into the slot at the 3. Remove cover
base and twisting (See diagram overleaf).
1) Locate the "LEARN" pins. WITH POWER ON, bridge the two pins
with the 1 . Mark position of f'.,_�
shunt provided. The red LEO will now illuminate. unit against
2) Press the required button on the transmitter. The red LEO will flash
mounting surface.
once. indicating that the button has been learned as a momentary
2. Using a Smm
button. 11 the red LED flashes rapidly. the memory is full, and the
masonry bit, drill
button cannot be memorised.
3) lffurther buttons are to be memorised, repeatfrom step 2. lf not, hales into mounting
remove the surface
bridgefrom the "LEARN" pins. The system is now readyfor use. 3. Mount the unit using
the fasteners
For latched operation: supplied.
1) Locatethe "ERASE" pins. WITH POWER OFF, bridge the two pins
with the
shunt provided. Power up the unit. The red LEO will now
illuminate. 0
2) Press the required button on the transmitter. The red LEO will flash
D
twice, indicating that the button has been learned as a latched WIRING
button. lf the red LEO flashes rapidly, the memory is full, and
the button cannot be memorised. 1 . Use a 6mm drill bit to
3) lffurther buttons are to be memorised, repeatfrom step2. lf not, open the required 0
remove the cable entry hale.
bridgefrom the "ERASE' pins. The system is now readyfor use. 2. Fix cable to wall
using cable
Note:
1) When programming a mu/ti button transmitter to a mu/ti channel saddles.
receiver, button 7 wi// operate channel 7, button 2 channel 2 etc. 3. Seal all hales with
2) The single channel receiver is capable of memorizing up to 62 silicon sealant.
buttons. The mu/ti channel receiver is capable of memorizing
up to 250 buttons
E&OE Centurion Systcms (Pty) Lid reserves thc nght to change products or spcc1hcations withoul prior ncüee.