Documente Academic
Documente Profesional
Documente Cultură
(elevator)
A
Application unit name: Canny Elevator Co., Ltd.
Applicant's registered address: Kangli Road, Fenhu High-tech Industrial Development Zone, Jiangsu Province number
Registered address of manufacturing unit: Kangli Road, Fenhu High-tech Industrial Development Zone, Jiangsu Province number
After the type test, it was confirmed that the prototype conforms to the "Elevator Type Test Rules" TGS
T70070-2016 Provisions.
The sample comply with GB 7588-2003"Safety Code for Elevator Manufacturing and Installation" Contain First 1 Amendment Number and EN81-1+A3:2009 Safety rules for
the construction and installation of lifts part 1 electric lifts Relevant regulations.
The scope and configuration of product parameters applicable to this certificate are shown in the attached table.
Certificate No TSX311003820170011
product name Sightseeing elevator without machine room Product number KLWG
Speed mode AC frequency conversion speed regulation Name of manufacturing unit of speed Canny Elevator Co., Ltd.
governor
the company
Drive method Traction drive Control device manufacturing unit name Canny Elevator Co., Ltd.
the company
Control cabinet layout area Part of the shaft inside part of the shaft outside working environment indoor
Car overspeed protection Acting on traction sheave Car accident movement protection device Acting on traction sheave
Device type Type
Jacking method / Device for preventing car settlement /
Description: /
Report number:2017AF0309
(elevator)
C
Shenzhen Special Equipment Safety Inspection and Research Institute
Precautions
1 This report is based on "Elevator Type Test Rules" G 7007-201 The conclusion report of the type test.
2 This report should be printed out by a computer, or filled out with a pen or signature pen, with neat handwriting and invalidation.
3 This report has no test, review, signature of approved personnel, and the type approval agency's approval certificate number, seal, and riding seam seal are invalid.
This report is available in electronic and printed versions and has the same effect.
5 If the applicant has any objection to the conclusion of the type test, it shall submit it to the type test institution within 15 working days after obtaining this report.
Type test institution name: Shenzhen Special Equipment Safety Inspection and Research Institute Type
test institution address: Type test institution approval certificate No. 1032, Honggang Road, Luohu
District, Shenzhen 7 1003 2017 Postal code: 51 029
Type Test Organization Division Name: Shenzhen Special Equipment Safety Inspection and Research Institute, Qinghu Branch Type Test Organization
Division Address: Chuangye Road, Shunchengji Industrial Zone, Dahe Road, Qinghu, Longhua New District, Shenzhen Postal Code: 51 109
Telephone: 0755 2 079 21; 0755 2 079351
Mesh Record
product name Sightseeing elevator without machine room Product number KLWG
Application unit registration Kangli Road, Fenhu High-tech Industrial Development Zone, Jiangsu Province number
address
Manufacturing unit registered Kangli Road, Fenhu High-tech Industrial Development Zone, Jiangsu Province number
address
Test Location Kangli Road, Fenhu High-tech Industrial Development Zone, Jiangsu Province No. in the manufacturing plant
test:
Inspection
Seal 2017-4-7
Review:
Inspection agency
Approve: special seal
2017 year month
7 day
Shenzhen Special Equipment Safety Report number:2017AF0309
Inspection and Research Institute Special equipment
TS7610038-2017 type test report First 2 Total pages 10
page
1. Prototype technical parameters and configuration table
(elevator)
Product variety Traction drive passenger elevator product name Sightseeing elevator without machine
room
Door type Automatic level midpoint Car door type Automatic level midpoint
working area Drive host Car top Control cabinet Part of the shaft inside part of the shaft outside
position
Emergency operation Outside the well Dynamic test screen Outside the well
screen
Drive method Traction drive Overall structure type Permanent magnet synchronous gearless
Drive host model KGT-U Manufacturing unit name Canny Elevator Co., Ltd.
motor model KGT-U Manufacturing unit name Canny Elevator Co., Ltd.
Drive host Drive method Traction drive Overall structure type Permanent magnet synchronous gearless
Configuration
two Hydraulic
power station model WSG-08.4 Manufacturing unit name WITTUR Electric Drives GmbH
Shenzhen Special Equipment Safety report number:2017AF0309
Inspection and Research Institute Special equipment
TS7610038-2017 type test report First 3 Total pages 10
page
(elevator)
Prototype technical parameters and configuration table (continued)
d r i v e Dynamic
host configuration Output wheel pitch Reduction ratio
400mm 1:1
two Hydraulic diameter
power station
motor model WSG-08.4 Manufacturing unit name WITTUR Electric Drives GmbH
Suspension rope structure model 10 NAT 8×19S+F Rope way Single winding
1570/1770 ZS
Pedestal
Car suspension method
Shenzhen Special Equipment Safety report number:2017AF0309
Inspection and Research Institute Special equipment
TS7610038-2017 type test report First 4 Total pages 10
page
(elevator)
Prototype technical parameters and configuration table (continued)
Control cabinet model KLW/VF Manufacturing unit name Canny Elevator Co., Ltd.
Speed control device model KLS- MDD-01A Manufacturing unit name Canny Elevator Co., Ltd.
Control device model KLS- MD-01A Manufacturing unit name Canny Elevator Co., Ltd.
Landing door lock type number 161 type regulation Rated voltage AC110V
spec
Rated current AC 0.2A
Manufacturing unit name Canny Elevator Co., Ltd.
Car door lock type number XD-CS01 regulation Rated voltage: AC110V
spec
Rated current: AC0.1A
Manufacturing unit name Canny Elevator Co., Ltd.
Safety gear type number AQ11B specification Rated speed range 0.25m/s-2.5m/s
Programmable
type number / Safety functions and SIL /
electronic
security phase grade
Off system
Manufacturing unit name /
Car accident type number KLS-UCMP type formula Acting on traction sheave
movement
protection
Device
Manufacturing unit name Canny Elevator Co., Ltd.
11 H5.11 Record and report of continuous operation test of the whole machine Complete information qualified
4 H6.1.4 Phase failure and phase failure protection Meet the requirements qualified
5 H6.1.5 Stop driving the host and check its stop status Meet the requirements qualified
7 H6.1.7 Safety circuit ground fault protection Meet the requirements qualified
Loose rope for indirect acting hydraulic elevator Or loose chain safety
16 H6.1.16 equipment Not applicable /
Leveling, releveling and anti-leveling when the door is not closed and locked
19 H6.2.2 Settlement control Meet the requirements qualified
twenty H6.2.4 Emergency electric operation control Meet the requirements qualified
one
twenty H6.2.5 Landing door and car door bypass device Meet the requirements qualified
two
26 H6.3.2 Other triggering methods of hydraulic elevator safety gear Not applicable /
The hydraulic elevator prevents the car from overspeeding down, sinking and the car
27 H6.3.3 or leveling Weight-loss measures Not applicable /
31 H6.3.7 Car ascending overspeed protection device Meet the requirements qualified
32 H6.3.8 Car accident movement protection device Meet the requirements qualified
36 H6.3.12 Description of safety signs and warnings (shown) Meet the requirements qualified
42 H6.5.1 Clearance between landing door and car door system Meet the requirements qualified
Shenzhen Special Equipment report
Safety Inspection and Special equipment number:2017AF0309
Research Institute
TS7610038-2017 type test report First 8 Total
pages 10 page
Serial Item Number (elevator)
Project content and requirements test results in
number conclusion
43 H6.5.2 Floor and car door dimensions Meet the requirements qualified
48 H6.5.7 Protection of automatic horizontal sliding door movement Meet the requirements qualified
49 H6.5.8 Landing door locking and closing inspection Meet the requirements qualified
50 H6.5.9 Car door locking and closing inspection Meet the requirements qualified
55 H6.8.1 Safety space and maintenance space Meet the requirements qualified
57 H6.8.3 Emergency operation and dynamic test device Meet the requirements qualified
58 H6.9.1 input signal Additional requirements for elevators in case of fire Not applicable /
59 H6.9.2 Stop position of elevator Additional requirements for elevators in case of fire Not applicable /
60 H6.9.3 Prohibition sign Additional requirements for elevators in case of fire Not applicable /
Interface requirements between fire alarm system and elevator control system
61 H6.9.4 Additional requirements for elevators in case of fire Not applicable /
63 H6.9.6 Designated layer Additional requirements for elevators in case of fire Not applicable /
66 H6.10.3 Firefighters trapped in the car for rescue Firefighter lift Not applicable /
67 H6.10.4 Car doors and landing doors Fireman elevator requirements Not applicable /
68 H6.10.5 Firefighter elevator host and related equipment Firefighter lift Not applicable /
70 H6.10.7 System power supply and conversion Firefighter lift Not applicable /
71 H6.10.8 Control device of car and hall Firefighter lift Not applicable /
Shenzhen Special Equipment report
Safety Inspection and Special equipment number:2017AF0309
Research Institute
TS7610038-2017 type test report First 9 Total
pages 10 page
Serial Item Number (elevator)
Project content and requirements test results in
number conclusion
speed:1.73m/s deviation: -1 %
76 H6.14 Car running speed qualified
79 H6.17 Traction drive and forced drive elevator acceleration and 1.28m/s2 qualified
deceleration Most small A95 Acceleration and deceleration:
1.13 m/s2
80 H6.18 Vibration acceleration of traction drive and forced drive Horizontal direction: qualified
elevator car
Maximum peak-to-peak value:0.05 m/s2
Accuracy: -2 mm
82 H6.20 Leveling accuracy and leveling accuracy Maintain accuracy:3 mm qualified
2 See the attached page for the "Change Status Page" of the type test report.