0 evaluări0% au considerat acest document util (0 voturi)
27 vizualizări1 pagină
This document summarizes a quiz about PPP configuration and troubleshooting. It contains 14 multiple choice questions about topics like:
- PPP encapsulation and messages sent during session establishment
- The functions of protocols like NCP, IPCP, and CHAP
- Configuring and troubleshooting a PPP multilink connection
- Standards for transmission rates like T1, E1, OC-1
This document summarizes a quiz about PPP configuration and troubleshooting. It contains 14 multiple choice questions about topics like:
- PPP encapsulation and messages sent during session establishment
- The functions of protocols like NCP, IPCP, and CHAP
- Configuring and troubleshooting a PPP multilink connection
- Standards for transmission rates like T1, E1, OC-1
This document summarizes a quiz about PPP configuration and troubleshooting. It contains 14 multiple choice questions about topics like:
- PPP encapsulation and messages sent during session establishment
- The functions of protocols like NCP, IPCP, and CHAP
- Configuring and troubleshooting a PPP multilink connection
- Standards for transmission rates like T1, E1, OC-1
1. During a PPP session establishment Configure-Reject 6. A network engineer is troubleshooting an ip address
phase, which two messages are sent by Configure-Nak unsuccessful PPP multilink connection 192.168.10.1 the requested party if the options are between two routers. The multilink 255.255.255.252 not acceptable? (Choose two.) interface has been created and assigned a number, the interface has been enabled 2. Fill in the blank. HDLC for multilink PPP, and the interface has The default encapsulation for WAN been assigned a multilink group number interfaces is that matches the group assigned to the member physical serial interfaces. The on Cisco routers. physical serial interfaces have also been 3. Fill in the blank. ppp enabled for PPP multilink. Which When a Cisco router is being additional command should to be issued connected to a non-Cisco router on the multilink interface? across a point-to-point serial link, the 7. PPP authentication is performed at which Layer 2 encapsulation should be configured. OSI layer? 4. Match the PPP frame field to the Flag - a single byte 8. What function does NCP perform in the It completes description. (Not all options are used.) that designates the establishment of a PPP session? the specific beginning or end configuration of of a PPP frame the network layer protocol Address - a byte that is being filled with all 1s used. Control - a field 9. Which additional functionality is available authentication with 00000011 so on an interface when the encapsulation is that data link changed from HDLC to PPP? establishment is 10. Which PPP option enables load balancing Multilink not required on PPP-enabled interfaces that connect to a single destination? Protocol - one (if compression 11. Which PPP protocol allows a device to IPCP allowed) or two specify an IP address for routing over the bytes PPP link? 12. Which protocol is used by PPP to provide CHAP Data - 0 to 1500 authentication and protection from bytes of playback attacks? information 13. Which two options are negotiated via NCP the algorithm during the establishment of a PPP to compress Frame Check connection that will use the IPv4 network TCP and IP Sequence - up to 4 layer protocol? (Choose two.) headers bytes for error detection an IPv4 5. Match the transmission rate standards T1 - 1.544 mb/s address to use with their designated bandwidth. (Not for routing IP all options are used.) DS0 - 64 kb/s over the PPP link OC-1 - 51.84 mb/s 14. With which layers of the OSI model do NCP interfaces the PPP control protocols interface? with Layer 3; E1 - 2.048 mb/s LCP interfaces with Layer 1 T3 44.736 mb/s