Documente Academic
Documente Profesional
Documente Cultură
This standard has been approved for use by agencies of the Department of Defense.
--`-`-`,,`,,`,`,,`---
2. Referenced Documents heat and pressure as a separate stage in manufacture. Other
2.1 ASTM Standards: materials may be added during manufacture to improve certain
C 168 Terminology Relating to Thermal Insulating Materi- properties.
als2 3.3 Definitions of Terms Specific to This Standard:
C 177 Test Method for Steady-State Heat Flux Measure- 3.3.1 board—refers to the material as received.
ments and Thermal Transmission Properties by Means of 3.3.2 sample—refers to the 36 by 48-in. (0.9 by 1.2-m)
the Guarded-Hot-Plate Apparatus2 piece cut from a board.
3.3.3 test specimen—refers to the test piece cut from a
sample unless otherwise specified in the test method.
1
These test methods are under the jurisdiction of ASTM Committee C-16 on
Thermal Insulation and are the direct responsibility of Subcommittee C16.32 on
Mechanical Properties.
3
Current edition approved April 10, 1998. Published June 1998. Originally Discontinued. See 1993 Annual Book of ASTM Standards, Vol 04.06.
4
published as C 209 – 46 T. Last previous edition C 209 – 92. Annual Book of ASTM Standards, Vol 04.10.
2 5
Annual Book of ASTM Standards, Vol 04.06. Annual Book of ASTM Standards, Vol 04.07.
The American Society for Testing and Materials takes no position respecting the validity of any patent rights asserted in connection
with any item mentioned in this standard. Users of this standard are expressly advised that determination of the validity of any such
patent rights, and the risk of infringement of such rights, are entirely their own responsibility.
This standard is subject to revision at any time by the responsible technical committee and must be reviewed every five years and
if not revised, either reapproved or withdrawn. Your comments are invited either for revision of this standard or for additional standards
and should be addressed to ASTM Headquarters. Your comments will receive careful consideration at a meeting of the responsible
technical committee, which you may attend. If you feel that your comments have not received a fair hearing you should make your
views known to the ASTM Committee on Standards, 100 Barr Harbor Drive, West Conshohocken, PA 19428.
--`-`-`,,`,,`,`,,`---